NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
373 reports56,979 miles · Jan 20, 2011
Service Brakes, Hydraulic
WHILE DRIVING ON LOCAL STREETS. BRAKING WARNING LIGHT CAME ON. WHEN APPLYING BRAKES I COULD A HEAR GRINDING NOISE COMING FROM THE CAR AND BRAKE PEDAL FEELS SPRINGY. TOOK IT TO LOCAL NISSAN DEALER TO HAVE IT CHECK. BUT ONCE THE CAR IS TURNED OFF AND ON. PROBLEMS DISAPPEARS. DEALER UNABLE TO DUPLICATE PROBLEMS. ONCE I TOOK IT HOME…
Read full complaint
WHILE DRIVING ON LOCAL STREETS. BRAKING WARNING LIGHT CAME ON. WHEN APPLYING BRAKES I COULD A HEAR GRINDING NOISE COMING FROM THE CAR AND BRAKE PEDAL FEELS SPRINGY. TOOK IT TO LOCAL NISSAN DEALER TO HAVE IT CHECK. BUT ONCE THE CAR IS TURNED OFF AND ON. PROBLEMS DISAPPEARS. DEALER UNABLE TO DUPLICATE PROBLEMS. ONCE I TOOK IT HOME BRAKE WARNING LIGHT CAME ON AGAIN WITH THE SAME PROBLEM. TURN CAR ON AND OFF AGAIN PROBLEM DISAPPEARS.
NHTSA ODI #10378963
66,000 miles · Jan 10, 2011
Fuel System, Other
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT AFTER REFUELING THE FUEL TANK, THE FUEL GAUGE WOULD DISPLAY INACCURATE READINGS THAT THE FUEL TANK WAS EMPTY. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 10V074000 (FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM) YET THE CONTACTS VIN WAS NOT INCLUDED IN THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT AFTER REFUELING THE FUEL TANK, THE FUEL GAUGE WOULD DISPLAY INACCURATE READINGS THAT THE FUEL TANK WAS EMPTY. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 10V074000 (FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM) YET THE CONTACTS VIN WAS NOT INCLUDED IN THE RECALL. THE TECHNICIAN INFORMED THE CONTACT THAT THE FUEL PUMP WOULD NEED TO BE REPLACED DUE TO THE FAULTY FUEL GAUGE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 66,000.
NHTSA ODI #10375384
110,000 miles · Dec 29, 2010
Fuel System, Gasoline
2005 NISSAN ARMADA FUEL GAUGE IS NOT ACCURATE AND CAUSING MY ARMADA TO RAN OUT OF FUEL IN THE MID OF HIGHWAY SPEED AT 65MPH. THE FUEL GAUGE SAYING I HAVE 1/4 TANK LEFT AS THE CAR SHUTDOWN IN THE BUSY 65MPH HIGHWAY TRAVELING, VERY CLOSE CALL ON ACCIDENT. TOOK THE SUV TO MOSSY NISSAN OF HOUSTON, I WAS TOLD THERE'S NO RECALL ON M…
Read full complaint
2005 NISSAN ARMADA FUEL GAUGE IS NOT ACCURATE AND CAUSING MY ARMADA TO RAN OUT OF FUEL IN THE MID OF HIGHWAY SPEED AT 65MPH. THE FUEL GAUGE SAYING I HAVE 1/4 TANK LEFT AS THE CAR SHUTDOWN IN THE BUSY 65MPH HIGHWAY TRAVELING, VERY CLOSE CALL ON ACCIDENT. TOOK THE SUV TO MOSSY NISSAN OF HOUSTON, I WAS TOLD THERE'S NO RECALL ON MY SUV VIN SPECIFIC. I WAS TOLD THERE'S A RECALL 2005-2009 BUT ON VIN # SPECIFIC ONLY. *TR
NHTSA ODI #10373271
18,000 miles · Dec 29, 2010
Service Brakes, Hydraulic
2005 NISSAN ARMADA BRAKE HYDRAULIC FAILURE. IT HAPPEN AT LEAST ONCE EVERY OTHER MONTH EVER SINCE I OWN THE ARMADA BACK WHEN IT'S ABOUT 15K MILES. WHILE DRIVING AT LOW SPEED AND COMING TO A STOP, THE BRAKE LIGHT LED UP AND THE BRAKING SYSTEM IS USELESS, IT MAKE GRINDING SOUND, SOUND LIKE SPRINGS POPPING OUT IN FRONT OF THE ARMA…
Read full complaint
2005 NISSAN ARMADA BRAKE HYDRAULIC FAILURE. IT HAPPEN AT LEAST ONCE EVERY OTHER MONTH EVER SINCE I OWN THE ARMADA BACK WHEN IT'S ABOUT 15K MILES. WHILE DRIVING AT LOW SPEED AND COMING TO A STOP, THE BRAKE LIGHT LED UP AND THE BRAKING SYSTEM IS USELESS, IT MAKE GRINDING SOUND, SOUND LIKE SPRINGS POPPING OUT IN FRONT OF THE ARMADA FROM TIRES. ALMOST CRASH THE ARMADA INTO ANOTHER CAR STOPPING IN FRONT SEVERAL TIMES DUE TO USELESS BRAKES. TOOK IT THE MOSSY NISSAN HOUSTON, THEY CAN'T "REPLICATE" THE ISSUE BACK YEARS AGO. ONCE YOU SHUT OFF THE ARMADA, IT RESET AND IT WENT BACK TO NORMAL. AND THE PROBLEM CONTINUE, PERHAPS UNTIL SOMEONE GET HURT OR KILL??????! *TR
NHTSA ODI #10373263
97,000 miles · Dec 15, 2010
Parking BrakeService Brakes, Hydraulic
WHILE DRIVING DOWN THE ROAD I WOULD BE APPROACHING A STOP SIGN OR LIGHT AND I APPLIED THE BRAKE AND SUDDENLY HEAR A LOUD GRINDING NOISE. WHEN I PULL OVER AND TURN THE VEHICLE OFF AND THEN START OVER, IT WAS LIKE IT RESET ITSELF. I FREAKED OUT BECAUSE I HAD CHILDREN WITH ME. NISSAN, PLEASE FIGURE THIS OUT!!! ALSO WHEN I TRY TO …
Read full complaint
WHILE DRIVING DOWN THE ROAD I WOULD BE APPROACHING A STOP SIGN OR LIGHT AND I APPLIED THE BRAKE AND SUDDENLY HEAR A LOUD GRINDING NOISE. WHEN I PULL OVER AND TURN THE VEHICLE OFF AND THEN START OVER, IT WAS LIKE IT RESET ITSELF. I FREAKED OUT BECAUSE I HAD CHILDREN WITH ME. NISSAN, PLEASE FIGURE THIS OUT!!! ALSO WHEN I TRY TO TURN MY AIR ON OR OFF I HEAR A VERY LOUD CLICKING NOISE. EVEN WHILE DRIVING DOWN THE ROAD WITHOUT TOUCHING THE AIR IT JUST RANDOMLY DOES IT. *TR
NHTSA ODI #10370849
52,000 miles · Dec 8, 2010
Fuel System, Other
TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING 60 MPH THE VEHICLE RAN OUT OF GASOLINE IN THE MIDDLE OF THE HIGHWAY. THE FUEL TANK WAS EMPTY BUT THE FUEL GAUGE DISPLAYED THAT THERE WAS A QUARTER TANK OF FUEL IN THE TANK. THE CONTACT TOWED THE VEHICLE TO A LOCAL GAS STATION IN ORDER TO ADD FUEL TO…
Read full complaint
TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING 60 MPH THE VEHICLE RAN OUT OF GASOLINE IN THE MIDDLE OF THE HIGHWAY. THE FUEL TANK WAS EMPTY BUT THE FUEL GAUGE DISPLAYED THAT THERE WAS A QUARTER TANK OF FUEL IN THE TANK. THE CONTACT TOWED THE VEHICLE TO A LOCAL GAS STATION IN ORDER TO ADD FUEL TO THE VEHICLE. THE CONTACT NOTICED A RECALL REGARDING THE FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM (10V074000) AND REQUESTED THAT THE DEALER PERFORM THE REPAIR; HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT STATED THAT THE MANUFACTURER SHOULD EXTEND THE RECALL SINCE THE FAILURE COULD HAVE CAUSED A CRASH. THE FAILURE MILEAGE WAS 52,000.
NHTSA ODI #10369662
96,500 miles · Dec 6, 2010
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT TURNED THE KEY OFF AND TRIED TO RESTART THE ENGINE AND THE VEHICLE WOULD NOT START. ALL OF THE ELECTRICAL COMPONENTS CONTINUED OPERATION. THE VEHICLE WAS TOWED TO A DEALER AND THE DEALER DISCOV…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT TURNED THE KEY OFF AND TRIED TO RESTART THE ENGINE AND THE VEHICLE WOULD NOT START. ALL OF THE ELECTRICAL COMPONENTS CONTINUED OPERATION. THE VEHICLE WAS TOWED TO A DEALER AND THE DEALER DISCOVERED A FAULTY SENDER UNIT. THE DEALER REPLACED THE SENDER UNIT. AFTER THE REPAIRS, THE CHECK ENGINE LIGHT ILLUMINATED SO THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER. THE DIAGNOSTIC TEST SHOWED THAT THE CATALYTIC CONVERT MALFUNCTIONED AND WOULD NEED TO BE REPLACED. THE DEALER REPLACED THE CATALYTIC CONVERT AND A MONTH LATER, THE CATALYTIC CONVERTER FAILURE RECURRED. THE CONTACT INQUIRED WITH THE MANUFACTURER IN REGARDS TO NHTSA CAMPAIGN ID NUMBER: 10V074000 (FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM) BUT WAS ADVISED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS INVESTIGATING WHETHER OR NOT THE VEHICLE SHOULD BE ADDED TO THE RECALL. THE FAILURE MILEAGE WAS 96,500.
NHTSA ODI #10369332
57,000 miles · Nov 26, 2010
Engine And Engine CoolingParking BrakeService Brakes, Hydraulic
11/10/10 WHILE DRIVING THE BRAKE LIGHT CAME ON AND THE TRUCK WAS NOT RESPONDING TO THE BRAKES I HEARD A GRINDING NOISE AND THE PROBLEM WENT AWAY AFTER I TURNED THE TRUCK OFF AND RESTARTED IT. IT HAS HAPPEN LIKE 4 TIMES TO MY WIFE WHILE DRIVING WITH MY KIDS SO IM VERY CONCERNED ABOUT THIS PROBLEM. I WENT TO THE DEALER AND ALL THE…
Read full complaint
11/10/10 WHILE DRIVING THE BRAKE LIGHT CAME ON AND THE TRUCK WAS NOT RESPONDING TO THE BRAKES I HEARD A GRINDING NOISE AND THE PROBLEM WENT AWAY AFTER I TURNED THE TRUCK OFF AND RESTARTED IT. IT HAS HAPPEN LIKE 4 TIMES TO MY WIFE WHILE DRIVING WITH MY KIDS SO IM VERY CONCERNED ABOUT THIS PROBLEM. I WENT TO THE DEALER AND ALL THEY COULD SAY WAS THAT THEY NEEDED TO GET THE CODE FOR THEM TO TRY TO FIND OUT WAS WRONG WITH IT. IF THERE'S SOMEONE OUT THERE THAT CAN HELP BEFORE ITS TOO LATE AND SOMETHING SERIOUS HAPPENS. *TR
NHTSA ODI #10367922
95,000 miles · Nov 18, 2010
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 35-40 MPH, THE ENGINE COMPLETELY STALLED WITHOUT WARNING. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD, AND THEN TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN WAS UNABLE TO LOCATE THE PROBLEM. THERE WAS A RECALL UNDER THE NHTS…
Read full complaint
TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 35-40 MPH, THE ENGINE COMPLETELY STALLED WITHOUT WARNING. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD, AND THEN TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN WAS UNABLE TO LOCATE THE PROBLEM. THERE WAS A RECALL UNDER THE NHTSA CAMPAIGN ID NUMBER 10V517000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED AND THEY WERE UNABLE TO DETERMINE IF THE VIN WAS INCLUDED IN THE RECALL DEFECT UNTIL DECEMBER OF 2010. THE CONTACT EXPERIENCED THE SIMILAR FAILURE AS MENTIONED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 95,000.
NHTSA ODI #10366696
71,400 miles · Nov 18, 2010
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING APPROXIMATELY 40 MPH THE VEHICLE STALLED. HE PULLED OVER TO THE SIDE OF THE ROAD, AND RESTARTED THE VEHICLE AFTER TWO ATTEMPTS. THE FAILURE HAD OCCURRED FOR THREE WEEKS, AND THE FAILURE WAS CONSTANT. THE FAILURE HAPPENED APPROXIMATELY 14-16 TIMES. THE VEHICLE WAS NOT TAK…
Read full complaint
TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING APPROXIMATELY 40 MPH THE VEHICLE STALLED. HE PULLED OVER TO THE SIDE OF THE ROAD, AND RESTARTED THE VEHICLE AFTER TWO ATTEMPTS. THE FAILURE HAD OCCURRED FOR THREE WEEKS, AND THE FAILURE WAS CONSTANT. THE FAILURE HAPPENED APPROXIMATELY 14-16 TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR THE FAILURE. THE CONTACT REFERENCED RECALL 10V517000, ENGINE AND ENGINE COOLING AND WAS ADVISED BY THE MANUFACTURER THAT THIS WAS A PREMATURE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 71,400 AND THE APPROXIMATE CURRENT MILEAGE WAS 71,745.
NHTSA ODI #10366678
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration