NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
109 reportsClear category filter170,000 miles · Jul 6, 2015
Service Brakes
I HAVE A 2005 NISSAN ARMADA AND HAVE HAD IT FOR ALMOST A YEAR. FOR THE PAST SEVERAL MONTHS MY BRAKES HAVE BEEN ACTING UP. WHEN I AM DRIVING MY BRAKE LIGHT STARTS FLASHING AND I GO TO STOP AND THE I CAN'T STOP. I HAVE TO STOP MY VEHICLE WHERE EVER I AM DRIVING WHETHER IT IS A HIGHWAY OR MAIN ROAD AND STOP THE CAR AS SOON AS POSSI…
Read full complaint
I HAVE A 2005 NISSAN ARMADA AND HAVE HAD IT FOR ALMOST A YEAR. FOR THE PAST SEVERAL MONTHS MY BRAKES HAVE BEEN ACTING UP. WHEN I AM DRIVING MY BRAKE LIGHT STARTS FLASHING AND I GO TO STOP AND THE I CAN'T STOP. I HAVE TO STOP MY VEHICLE WHERE EVER I AM DRIVING WHETHER IT IS A HIGHWAY OR MAIN ROAD AND STOP THE CAR AS SOON AS POSSIBLE. I HAVE TO PUT IT IN PARK, SHUT THE CAR OFF AND THEN PUSH THE VDC LIGHT BUTTON AFTER A FEW SECONDS AND THEN RESTART MY CAR. THIS HAPPENS SEVERAL TIMES A WEEK TO ME AND EVEN UP TO 4 OR 5 TIMES A DAY THIS HAS HAPPENED. THIS IS NOT SAFE AND IS AN ACCIDENT WAITING TO HAPPEN WHEN YOU CAN'T STOP YOUR CAR. THIS REALLY SHOULD BE A RECALL TO THE VEHICLE BECAUSE THIS IS NOT NORMAL AND DEFINITELY IS A SAFETY ISSUE.
NHTSA ODI #10732327
132,385 miles · Jun 24, 2015
Service Brakes
I WAS GOING DOWN 4 LANE HWY AND STARTED TO SLOW DOWN APPROACHING INTERSECTION. THE BRAKES WENT ALL THE WAY TO THE FLOOR AND STARTED SHAKING VIOLENTLY. IT FELT LIKE THE VEHICLE WAS GOING TO SHAKE OFF THE AXEL. I JUST KNEW I WAS GOING TO HIT THE CAR NEXT TO ME. I HAD TO DRIVE HOME 15 MPH BECAUSE EVERY TIME I TOUCHED THE BRAKES …
Read full complaint
I WAS GOING DOWN 4 LANE HWY AND STARTED TO SLOW DOWN APPROACHING INTERSECTION. THE BRAKES WENT ALL THE WAY TO THE FLOOR AND STARTED SHAKING VIOLENTLY. IT FELT LIKE THE VEHICLE WAS GOING TO SHAKE OFF THE AXEL. I JUST KNEW I WAS GOING TO HIT THE CAR NEXT TO ME. I HAD TO DRIVE HOME 15 MPH BECAUSE EVERY TIME I TOUCHED THE BRAKES THE CAR WOULD VIOLENTLY SHAKE TO THE POINT OF PULLING ME OFF OF THE ROAD. WHEN I SHUT THE CAR OFF AND RESTARTED IT, IT MUST HAVE FIXED THE PROBLEM TEMPORARILY. IT HAS HAPPENED 2 MORE TIMES. I RECENTLY STARTED LOOKING ONLINE FOR ANY INFO ON THE MATTER AND FOUND THAT IT IS HAPPENING PRETTY REGULAR TO PEOPLE WITH THE SAME MODEL AND MAKE AS MINE AND ALSO IN A PRETTY CLOSE TIME FRAME. IT DOESN'T TAKE A GENIUS TO FIGURE OUT THAT THIS IS A DEFECT. A VERY DANGEROUS DEFECT THAT SHOULD BE FIXED BY NISSAN BEFORE SOMEONE GETS KILLED.
NHTSA ODI #10726996
99,809 miles · Jun 8, 2015
Service Brakes
THE BRAKE, SLIP AND VDC OFF LIGHT COME ON AT ONCE. LOSE BRAKE PEDAL PRESSURE. PEDAL GOES ALMOST TO FLOOR WITH NOISE LIKE THE ABS IS ON. SLOWLY CAN GET TRUCK TO STOP. TURN OFF AND TURN ON VEHICLE, ISSUE GOES AWAY FOR ANYWHERE FROM A DAY TO A FEW WEEK THEN HAPPENS AGAIN. IT HAS HAPPENED ON MOSTLY DRY SMOOTH PAVEMENT.
NHTSA ODI #10724129
112,000 miles · Apr 20, 2015
Service Brakes
THE BRAKES ONLY BARELY STOPPED THE VEHICLE AFTER DEPRESSING TO PEDAL ALL THE WAY TO THE FLOOR. NOW SOME WARNING LIGHTS COME ON VDC, SLIP, BRAKE AND WON'T GO OFF. THE BRAKES DON'T SEEM TO BE WORKING PROPERLY AND THE PEDAL WHEN DEPRESSED SLOWLY GOES TO THE FLOOR. I HAVE NEW BRAKES, ROTORS, ETC (10,000 MILES AND THE BRAKE FLUID …
Read full complaint
THE BRAKES ONLY BARELY STOPPED THE VEHICLE AFTER DEPRESSING TO PEDAL ALL THE WAY TO THE FLOOR. NOW SOME WARNING LIGHTS COME ON VDC, SLIP, BRAKE AND WON'T GO OFF. THE BRAKES DON'T SEEM TO BE WORKING PROPERLY AND THE PEDAL WHEN DEPRESSED SLOWLY GOES TO THE FLOOR. I HAVE NEW BRAKES, ROTORS, ETC (10,000 MILES AND THE BRAKE FLUID IS AT THE PROPER LEVEL. I HAVE READ ABOUT THIS SAME PROBLEM FROM MANY MANY PEOPLE NO THE WEB. THIS IS NOT AM ISOLATED PROBLEM AND SHOULD BE HANDLED BY NISSAN AND PUT INTO A RECALL. PEOPLE ON THE WEB WERE REFERENCING A CLASS ACTION LAW SUIT. PLEASE LOOK INTO IT. *TR
NHTSA ODI #10706656
Mileage unknown · Apr 13, 2015
Seat BeltsService Brakes
WHILE DRIVING OR EVEN JUST PUTTING IT IN REVERSE, WHEN I TRY TO BRAKE IT FEELS LIKE A SPONGY/STRINGY PEDAL THAT GOES TO THE GROUND AND MAKES A LOUD GRIND NOISE. YOU HAVE TO TURN OFF THE VEHICLE AND IT IS FINE, I HAVE TOOK IT IN THE SHOP AND NOTHING WRONG, I AM LIKE REALLY... I CAN'T BE TURNING THE VEHICLE OFF EVERY TIME IT DOES…
Read full complaint
WHILE DRIVING OR EVEN JUST PUTTING IT IN REVERSE, WHEN I TRY TO BRAKE IT FEELS LIKE A SPONGY/STRINGY PEDAL THAT GOES TO THE GROUND AND MAKES A LOUD GRIND NOISE. YOU HAVE TO TURN OFF THE VEHICLE AND IT IS FINE, I HAVE TOOK IT IN THE SHOP AND NOTHING WRONG, I AM LIKE REALLY... I CAN'T BE TURNING THE VEHICLE OFF EVERY TIME IT DOES THIS, THAT IS A SAFETY ISSUE OR A DEFINITE RECALL..NOW THIS HAPPENS SEVERAL TIMES AND WITH FAMILY IN THE VEHICLE IS A DANGER I THINK. HOPE THERE IS A RECALL FOR THIS ISSUE. ALSO SEAT BELTS DO NOT RETRACT BACK AFTER THE RECALL THAT WAS DONE. *TR
NHTSA ODI #10705502
117,040 miles · Mar 27, 2015
Service Brakes
I WAS DRIVING IN LIGHT TRAFFIC, PUSHED ON THE BRAKE PEDAL, THE BRAKE LIGHT (NOT ABS) ILLUMINATED ON THE INSTRUMENT PANEL, I HEARD A GRINDING SOUND AND ALMOST PUSHED THE PEDAL TO THE FLOOR. I PULLED OVER, TURNED THE TRUCK OFF, AND RESTARTED IT. THE BRAKE LIGHT REMAINED ILLUMINATED, BUT I WAS ABLE TO BRAKE. AFTER TURNING IT OFF AN…
Read full complaint
I WAS DRIVING IN LIGHT TRAFFIC, PUSHED ON THE BRAKE PEDAL, THE BRAKE LIGHT (NOT ABS) ILLUMINATED ON THE INSTRUMENT PANEL, I HEARD A GRINDING SOUND AND ALMOST PUSHED THE PEDAL TO THE FLOOR. I PULLED OVER, TURNED THE TRUCK OFF, AND RESTARTED IT. THE BRAKE LIGHT REMAINED ILLUMINATED, BUT I WAS ABLE TO BRAKE. AFTER TURNING IT OFF AND LETTING IT SIT FOR ABOUT 30 MINUTES, I TURNED IT ON AGAIN. THE BRAKE LIGHT WAS NO LONGER ON AND THE BRAKES ENGAGED. I TOOK IT TO A BRAKE SHOP ON 3/27/15 AND WAS TOLD THAT MY PADS ARE FINE. THEY ALSO CHECKED THE FLUID AND THE LEVEL WAS OK. I CONTACTED A LOCAL NISSAN DEALER AND WAS TOLD THAT THERE AREN'T ANY RECALLS. THEY HAVE NOT RECEIVED ANY REPORTS FROM CONSUMERS ABOUT THIS TYPE OF ISSUE OCCURRING, BUT COULD NOT PROVIDE AN EXPLANATION AS TO WHY THIS HAPPENED AND COULD BE RESET BY TURNING THE VEHICLE OFF. THIS ALSO HAPPENED PREVIOUSLY, BUT I DON'T RECALL EXACTLY WHEN. *TR
NHTSA ODI #10702126
142,700 miles · Mar 21, 2015
Service Brakes
AS I PRESSED ON BRAKES TO SLOW THE TRUCK DOWN AT INTERSECTION TWO DAYS AGO, THE BRAKE LIGHT CAME ON AND THEN A LOUD METAL GRINDING NOISE CAME FROM THE FRONT! THE TRUCK NOW HAD DIFFICULTY STOPPING; I HAD TO FLOOR IT IN ORDER FOR VEHICLE TO COME TO A COMPLETE STOP. I NEARLY REAR ENDED THE VAN THAT WAS IN FRONT OF ME! I WAS IN THE…
Read full complaint
AS I PRESSED ON BRAKES TO SLOW THE TRUCK DOWN AT INTERSECTION TWO DAYS AGO, THE BRAKE LIGHT CAME ON AND THEN A LOUD METAL GRINDING NOISE CAME FROM THE FRONT! THE TRUCK NOW HAD DIFFICULTY STOPPING; I HAD TO FLOOR IT IN ORDER FOR VEHICLE TO COME TO A COMPLETE STOP. I NEARLY REAR ENDED THE VAN THAT WAS IN FRONT OF ME! I WAS IN THE BACK ROADS SO THERE WERE SEVERAL STOP SIGNS/ INTERSECTIONS ON MY WAY HOME. AS I CONTINUED DRIVING AND BRAKING TO SLOW DOWN/ STOP, THE GRINDING NOISE WAS VERY LOUD AND THE TRUCK RARELY HAD ANY BRAKE POWER! I WAS TERRIFIED AND FINALLY WAS ABLE TO SLOW DOWN ENOUGH TO PULL OVER ON TO THE SIDE TO BREATHE AND CALM MY NERVES DOWN. I PUT THE TRUCK IN PARK AND CHECKED TO MAKE SURE I RELEASED THE BRAKE PEDAL, ETC. I THEN CONTINUED HOME WHERE I TURNED TRUCK OFF AND ASKED NEIGHBOR MECHANIC TO CHECK IT FOR ME. HE TURNED TRUCK BACK ON AND WE DROVE IT TO TEST BRAKES. EVERYTHING WAS NOW WORKING FINE! IT DID NOT SIT RIGHT WITH ME. I RESEARCHED ONLINE LAST NIGHT AND JUST LIKE THE FUEL GAUGE ISSUE THAT HAPPENED A WEEK PRIOR, THERE ARE THOUSANDS OF PEOPLE AFFECTED BY THIS BRAKE FAILURE! WHEN A REP FROM NISSAN CONSUMER SVCS CALLED EARLIER TODAY TO FOLLOW UP REGARDING MY TRUCK'S FUEL GAUGE ISSUE, I REPORTED THE BRAKE ISSUE. SHE JUST SAID "YES I'M SORRY BUT YOU WILL HAVE TO PAY FOR DEALERSHIP TO VERIFY ISSUE FIRST IN ORDER FOR NISSAN TO TAKE SOME KIND OF ACTION." UNBELIEVABLE. ESPECIALLY WHEN THERE ARE REPORTED INCIDENTS OUT THERE OF THIS DEFECT. UNFORTUNATELY, CONSUMERS ALSO REPORT THAT THIS BRAKE ISSUE HAPPENS INTERMITTENTLY SO IT'S HARD TO PROVE/ DIAGNOSE. WITH A FUEL GAUGE ISSUE AND NOW, BRAKE ISSUE, I'M MORE AFRAID TO DRIVE MY TRUCK ESPECIALLY WITH MY CHILDREN IN IT! I PRAY NISSAN WILL STEP UP AND DO THE RIGHT THING IN TAKING RESPONSIBILITY OF REPLACING/ REPAIRING THESE DEFECTS. PLEASE DON'T WAIT TILL THERE ARE FATALITIES BEFORE DOING SOMETHING ABOUT IT. *TR
NHTSA ODI #10700799
68,000 miles · Nov 18, 2014
Service Brakes
THE INCIDENT HAPPENED ON NOVEMBER 15, 2014 WHILE ACCELERATING FROM A STOP LIGHT GOING NORTH BEFORE THE INTERSECTION (OVERPASS) OF CARMENITA STREET, NORWALK, CA AND I-5 FREEWAY AT APPROXIMATELY 10 MPH. THE BRAKE LIGHT CAME ON AND THE BRAKES LOST POWER ALONG WITH GIVING A SPRING SOUND. I BROUGHT THE VEHICLE TO MY LOCAL MECHANIC .…
Read full complaint
THE INCIDENT HAPPENED ON NOVEMBER 15, 2014 WHILE ACCELERATING FROM A STOP LIGHT GOING NORTH BEFORE THE INTERSECTION (OVERPASS) OF CARMENITA STREET, NORWALK, CA AND I-5 FREEWAY AT APPROXIMATELY 10 MPH. THE BRAKE LIGHT CAME ON AND THE BRAKES LOST POWER ALONG WITH GIVING A SPRING SOUND. I BROUGHT THE VEHICLE TO MY LOCAL MECHANIC . NO PROBLEM WAS FOUND AND CANNOT DUPLICATE THE PROBLEM AS STATED AND BECAUSE OF THIS MECHANIC WAS NOT ABLE TO RESOLVE THE ISSUE/PROBLEM. ONCE THE VEHICLE IS TURNED OFF AND RESTARTED BRAKING POWER RETURNS TO NORMAL AND THE BRAKE LIGHT GOES OFF. THIS IS THE FIRST INCIDENT THAT IT HAPPENED BUT I WAS SCARED AND LOST CONFIDENCE IN THE DRIVING THE VEHICLE ESPECIALLY ON FREEWAYS WITH MY FAMILY AS PASSENGERS AND PUTTING THEM, MYSELF AS WELL AS OTHER PEOPLE IN DANGER. IT SEEMS THAT I AM NOT ALONE WHO EXPERIENCED THIS PROBLEM ON THIS VEHICLE AFTER DOING A RESEARCH OVER THE INTERNET. *TR
NHTSA ODI #10658954
120,000 miles · Nov 5, 2014
Service Brakes
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE STABILITY CONTROL AND ABS WARNING LIGHTS ILLUMINATED. THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN DEPRESSED AND THE VEHICLE FAILED TO STOP UNTIL AFTER SEVERAL ATTEMPTS. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE W…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE STABILITY CONTROL AND ABS WARNING LIGHTS ILLUMINATED. THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN DEPRESSED AND THE VEHICLE FAILED TO STOP UNTIL AFTER SEVERAL ATTEMPTS. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10652729
50,245 miles · Oct 30, 2014
Electronic Stability Control (esc)Service Brakes
SINCE 2006 THE BRAKE LIGHT COMES ON WHILE DRIVING I HAVE TO PULL TO SIDE BECAUSE I LOST MY BRAKES AND I HAVE TAKEN TO NISSAN DEALER AND THEY HAVE ADJUSTED THE DELTA STROKE SENSOR. I HAVE BEEN DOING THIS FOR MANY YEARS INTO MY WARRANTY EXPIRE. AND KNOW THE WANT TO REPLACE THE POWER BOOSTER. KNOW THEY ARE SAID DELTA STROKE SENSOR …
Read full complaint
SINCE 2006 THE BRAKE LIGHT COMES ON WHILE DRIVING I HAVE TO PULL TO SIDE BECAUSE I LOST MY BRAKES AND I HAVE TAKEN TO NISSAN DEALER AND THEY HAVE ADJUSTED THE DELTA STROKE SENSOR. I HAVE BEEN DOING THIS FOR MANY YEARS INTO MY WARRANTY EXPIRE. AND KNOW THE WANT TO REPLACE THE POWER BOOSTER. KNOW THEY ARE SAID DELTA STROKE SENSOR ON THE BRAKE POWER BOOSTER IS NOT GETTING PROPER VOLTAGE. THEY ARE MANY NISSAN ARMADA WITH THE SAME PROBLEM. I AM ONES OF THE LUCKY PERSONA HAVE GOT ON AN ACCIDENT. I BELIEVE NISSAN ARE RESPONSIBLE FOR THE PROBLEM. I BELIEVE NISSAN IS RESPONSIBLE TO RECALL ALL ARMADA FROM 2005 TO PRESENT. *TR
NHTSA ODI #10651416
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration