IllustrationBRAKE BOOSTER RANDOMLY FAILING. BRAKE BOOSTER NOT WORKING RANDOMLY. ORIGINAL PART, NEVER REPLACED
2005 Nissan Armada
Owner reports · Recalls · Investigations
More warning signs than most Armada years
Owner complaints for the 2005 Nissan Armada are substantially higher than the model-year median of 23.
About this comparison →How this year compares
Owner complaints by model year
Compare all Armada years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
530–25K
4225–50K
6050–75K
5875–100K
93100–150K
31150K+
337 reports with mileage · 36 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 94 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports5 fire reports5 injury reports
Service Brakes complaints
109 reportsSTARTED HAVING A ISSUE WITH MY BRAKES ON MY NISSAN ARMADA. WHEN YOU PRESSED ON THE BRAKES, THEY WOULD GO TO THE FLOOR AND WOULD NOT WORK AND THE BRAKE LIGHT WOULD GO ON. AFTER PULLING OVER AND TURNING THE VEHICLE OFF AND BACK ON THE BRAKE LIGHT WOULD GO OFF AND THE BRAKES WOULD WORK AGAIN. I GOOGLED THE PROBLEM AND FOUND THAT…
Read full complaint
STARTED HAVING A ISSUE WITH MY BRAKES ON MY NISSAN ARMADA. WHEN YOU PRESSED ON THE BRAKES, THEY WOULD GO TO THE FLOOR AND WOULD NOT WORK AND THE BRAKE LIGHT WOULD GO ON. AFTER PULLING OVER AND TURNING THE VEHICLE OFF AND BACK ON THE BRAKE LIGHT WOULD GO OFF AND THE BRAKES WOULD WORK AGAIN. I GOOGLED THE PROBLEM AND FOUND THAT NISSAN KNEW ABOUT THIS ISSUE AND SETTLED A CLASS ACTION LAW SUIT REGARDING IT. I TOOK THE VEHICLE TO THE DEALERSHIP AND IT WAS THE DELTA STROKE SENSOR. NISSAN KNEW THERE WAS A PROBLEM BUT HAS NOT RECALLED THE VEHICLES. IN FACT THIS PROBLEM IS NOT LIMITED TO THE ARMADA. MY FAMILY AND I COULD HAVE BEEN KILLED BECAUSE OF THIS ISSUE INCLUDING OTHERS THAT WERE ON THE ROAD WHEN THE BRAKES WENT OUT. HTTPS://TOPCLASSACTIONS.COM/LAWSUIT-SETTLEMENTS/LAWSUIT-NEWS/45486-NISSAN-REACHES-BRAKE-DEFECT-CLASS-ACTION-SETTLEMENT/
THE ABS HYDRAULIC BRAKE SENORS HAVE NOW BEEN REPLACED TWICE ON MY ARMADA. THE BRAKES WILL DROP TO THE FLOOR AND MAKE ALL KIND OF NOISES WON'T STOP. THERE HAD BEEN A RECALL FOR ALL OTHER VINS THAN MINE. DEALERSHIP SAID THERE WAS NOTHING THEY COULD DO OTHER THAN START CHANGING OTHER PARTS ON MY DIME. NISSAN OF AMERICA HAS TOLD ME…
Read full complaint
THE ABS HYDRAULIC BRAKE SENORS HAVE NOW BEEN REPLACED TWICE ON MY ARMADA. THE BRAKES WILL DROP TO THE FLOOR AND MAKE ALL KIND OF NOISES WON'T STOP. THERE HAD BEEN A RECALL FOR ALL OTHER VINS THAN MINE. DEALERSHIP SAID THERE WAS NOTHING THEY COULD DO OTHER THAN START CHANGING OTHER PARTS ON MY DIME. NISSAN OF AMERICA HAS TOLD ME THE SAME THING. WE HAVE NEARLY BEEN IN SEVERAL WRECKS. I DO NOT WANT MY WIFE TO END UP IN ONE BECAUSE OF THIS TRUCK. JUST BOUGHT THE SECOND SET OF THESE YESTERDAY AND NEARLY HIT SOMEONE AGAIN TODAY. SINCE I KEEP A GOOD DISTANCE BETWEEN OTHER TRAFFIC AND MYSELF IS THE ONLY REASON WE HAVEN'T BEEN A WRECK YET.
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING VARIOUS SPEEDS, THE REAR PASSENGER BRAKE WOULD ERRONEOUSLY ENGAGE. DURING THE FAILURE, THE BRAKE AND ABS WARNING INDICATORS WOULD ILLUMINATE. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING VARIOUS SPEEDS, THE REAR PASSENGER BRAKE WOULD ERRONEOUSLY ENGAGE. DURING THE FAILURE, THE BRAKE AND ABS WARNING INDICATORS WOULD ILLUMINATE. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 175,000.
TAKATA RECALL BRAKES NOT WORKING WHILE DRIVING AND PULSES AND FUEL GAGE NOT WORKING WHILE DRIVING AND PARKED.
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING VARIOUS SPEEDS, THE BRAKE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. WHILE DEPRESSING THE BRAKE PEDAL, AN ABNORMAL NOISE WAS DETECTED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, TURNED OFF THE ENGINE, WAITED A FEW MINUTES, RESTARTED THE VEHICLE, A…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING VARIOUS SPEEDS, THE BRAKE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. WHILE DEPRESSING THE BRAKE PEDAL, AN ABNORMAL NOISE WAS DETECTED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, TURNED OFF THE ENGINE, WAITED A FEW MINUTES, RESTARTED THE VEHICLE, AND THE BRAKE WARNING INDICATOR WAS NO LONGER ILLUMINATED. THE CONTACT RESUMED DRIVING. THE VEHICLE WAS TAKEN TO DREXEL NISSAN (5018 TOWNSHIP LINE RD, PHILADELPHIA, PA 19026, PHONE NUMBER: (610) 449-2800) WHERE IT WAS DIAGNOSED THAT THE BRAKES FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 106,000.
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH AND ATTEMPTING TO SLOW DOWN TO MAKE A TURN, THE BRAKE PEDAL WENT TO THE FLOORBOARD. THE CONTACT MANAGED TO CONTROL THE VEHICLE. A METAL-TO-METAL GRINDING NOISE WAS HEARD FROM THE BRAKES AND THE BRAKE WARNING LIGHT ILLUMINAT…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH AND ATTEMPTING TO SLOW DOWN TO MAKE A TURN, THE BRAKE PEDAL WENT TO THE FLOORBOARD. THE CONTACT MANAGED TO CONTROL THE VEHICLE. A METAL-TO-METAL GRINDING NOISE WAS HEARD FROM THE BRAKES AND THE BRAKE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE ROTORS AND THE WHEELS. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO THE DEALER AT: EDDEN PRAIRIE NISSAN, BLOOMINGTON, MN, WHERE THE TECHNICIAN DIAGNOSED AND REPLACED THE BRAKE BOOSTER. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT REMEDIED. THE FAILURE MILEAGE WAS APPROXITMATELY 50,000.
BREAK SYSTEM FAILURE HAS HAPPENED TO ME MORE THAN ONCE. FOR SOME REASON IT SOUNDS LIKE THEY'RE ARE ROCKS IN BETWEEN MY BRAKES AND THE ROTORS. I HAVE TO RESET THE SYSTEM BY SHUTTING THE CAR OFF AND TURNING IT BACK ON. I ALMOST HAD AN ACCIDENT ON THE FREEWAY BECAUSE OF IT AND NO INDICATION OTHER THAN THE NOISE THAT IT WAS HAPPENIN…
Read full complaint
BREAK SYSTEM FAILURE HAS HAPPENED TO ME MORE THAN ONCE. FOR SOME REASON IT SOUNDS LIKE THEY'RE ARE ROCKS IN BETWEEN MY BRAKES AND THE ROTORS. I HAVE TO RESET THE SYSTEM BY SHUTTING THE CAR OFF AND TURNING IT BACK ON. I ALMOST HAD AN ACCIDENT ON THE FREEWAY BECAUSE OF IT AND NO INDICATION OTHER THAN THE NOISE THAT IT WAS HAPPENING. ALSO, WHEN A PASSENGER IS IN THE SEAT THE AIRBAG LIGHT DOES NOT TURN OFF. I AND HASN'T FOR OVER 5 YEARS. THE DRIVER SIDE AND/OR PASSENGER SIDE SEAT BELTS ALSO DO NOT GET RECOGNIZED AS BEING USED SINCE THE FLASH INDICATOR ON THE DASH KEEPS FLASHING. WHEN I TOOK T IN TO THE DEALER THEY SAID THERE ARE NO RECALLS BUT IT'S A SAFETY ISSUE. THE VEHICLE HAS LESS THAN 110000 MILES ON IT AND HAD LESS THAN 80000 WHEN THESE ISSUES STARTED. I JUST WANT MY VEHICLE TO BE SAFE AND EVERYONE ELSE WHO HAS THE SAME ONE. BRAKE SYSTEM, DEALER CAN'T DIAGNOSE UNLESS I DRIVE IN THERE WITH THE PROBLEM WHICH ISN'T SAFE AND HAPPENS OCCASIONALLY. I MAY HAVE VIDEO OF THE NOISE FROM THE BRAKE SYSTEM WHICH I WILL LOOK FOR.
"TAKATA RECALL" I EXPERIENCE SURPRISE EXCELLERATION THREE TIMES, ONCE RESULTING IN A MINOR VEHICLE ACCIDENT WITH MINOR BODY DAMAGE. ALL THREE OCCURRED ON A CITY STREET WHILE IN STARTING MOTION GOING STRAIGHT AHEAD.
PURCHASED VEHICLE USED IN MAY 2015, MY TRUSTED MECHANIC CHECKED IT OUT SEPTEMBER 2015 AND REPORTED BACK IT WAS IN GOOD CONDITION WITH NO ISSUES. JULY 2016 EXPERIENCED BREAK FAILURE AT 15 MILES AN HOUR. AGAIN MY MECHANIC TROUBLESHOOTED THE ISSUES AND SAID THE POWER BREAK BOOSTER NEEDED TO BE REPLACED. HE THEN REFERRED ME TO NIS…
Read full complaint
PURCHASED VEHICLE USED IN MAY 2015, MY TRUSTED MECHANIC CHECKED IT OUT SEPTEMBER 2015 AND REPORTED BACK IT WAS IN GOOD CONDITION WITH NO ISSUES. JULY 2016 EXPERIENCED BREAK FAILURE AT 15 MILES AN HOUR. AGAIN MY MECHANIC TROUBLESHOOTED THE ISSUES AND SAID THE POWER BREAK BOOSTER NEEDED TO BE REPLACED. HE THEN REFERRED ME TO NISSAN FOR POSSIBLE REPLACEMENT SINCE IT IS A SAFETY ISSUE. I SPOKE WITH CORPORATE NISSAN WHO ADVISED ME TO TAKE IT TO OUR LOCAL NISSAN DEALERSHIP TO PROVE THE ISSUE EXISTED, FOR ANY POTENTIAL COMPENSATION. AFTER TAKING THE VEHICLE TO NISSAN THEY CONCLUDED REPROGRAMMING THE DELTA STROKE SENSOR WOULD RESOLVE THE PROBLEM; WHICH I HAD TO PAY $300 TO HAVE THIS DONE. ON OCTOBER 2016 INOPERABLE BREAK FAILURE OCCURRED AGAIN AT 65 MILES AN HOUR WHILE ON THE INTERSTATE, AS I WAS APPROACHING AN EXIT RAMP. THIS SAME ISSUE OCCURRED TWICE IN ONE DAY, JUST A WEEK LATER. ONCE AS I LEFT WORK GOING 40 MILES AN HOUR, MY DASHBOARD LIT UP WITH VDC AND SKID LIGHTS, IN ADDITION TO MY BREAK FAILURE LIGHT. THE SECOND TIME OCCURRED GOING DOWN A CITY STREET WHERE I HAD TO DO A ROLLING STOP THROUGH AN INTERSECTION, DODGING ONCOMING TRAFFIC, EVENTUALLY HITTING A CURB TO STOP. AFTER TAKING MY VEHICLE BACK TO NISSAN FOR THEM TO TEST DRIVE (RECREATE) THE PROBLEM, I WAS TOLD THAT I COULD NOT DRIVE MY VEHICLE OFF THE LOT DUE TO SAFETY HAZARDS. I HAVE SPENT HOURS ON THE PHONE WITH CORPORATE TO RESOLVE THIS SAFETY ISSUE; BUT YET NISSAN REFUSES TO FIX THE PROBLEM, OR REFUND ME MY MONEY FOR THE FAILED REPROGRAMMING. THIS VEHICLE IS GEARED TOWARDS FAMILIES WITH CHILDREN; AND BOTH MY CHILDREN WERE PRESENT IN THE VEHICLE DURING ALL FAILURES. AFTER SEARCHING THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION WEBSITE, I HAVE FOUND HUNDREDS OF DOCUMENTED CASES REVOLVING AROUND THE SAME SAFETY HAZARD. NISSAN REFUSES TO RECALL THIS PART OR NOTIFY OWNERS OF THE EXISTING ISSUE.
Official recalls
310V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.