NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
94 reportsClear category filter3,500 miles · Jan 25, 2006
Electronic Stability ControlService Brakes, HydraulicStructure
PURCHASED 2005 ARMADA IN MAY BY JUNE VEHICLE WENT INTO SERVICE BECAUSE A NOISE WAS COMING FROM THE REAR SIDE. 2 ATTEMPTS TO FIX AND PART WAS REPLACED. AUGUST 2005 TAKEN TO DEALER AGAIN BECAUSE OF SHAKING WHILE BRAKING, AND FRONT ROTORS /PADS WERE REPLACED, AND REAR ROTORS RESURFACED. JANUARY 2006 VEHICLE TAKEN BACK TO DEA…
Read full complaint
PURCHASED 2005 ARMADA IN MAY BY JUNE VEHICLE WENT INTO SERVICE BECAUSE A NOISE WAS COMING FROM THE REAR SIDE. 2 ATTEMPTS TO FIX AND PART WAS REPLACED. AUGUST 2005 TAKEN TO DEALER AGAIN BECAUSE OF SHAKING WHILE BRAKING, AND FRONT ROTORS /PADS WERE REPLACED, AND REAR ROTORS RESURFACED. JANUARY 2006 VEHICLE TAKEN BACK TO DEALER BECAUSE THERE WAS A GRINDING. APPARENTLY THE PROBLEM WERE THE TIRES THAT NEEDED BALANCING AND ROTATING. ANOTHER PROBLEM WAS THE LIFTGATE, IT DID NOT WANT TO OPEN AND CLOSE AUTOMATICALLY. MY CAR HAS BEEN IN THE SHOP FOR 3 DAYS AND THEY STILL DID NOT KNOW WHAT THE PROBLEM COULD BE. AS ANOTHER CONSUMER MENTIONED THE STABILITY OF THIS VEHICLE WAS VERY POOR, I HAVE SWIRVED SHARPLY TO THE LEFT WHEN BRAKING AT 50 MPH OR MORE. ACCORDING TO THE NISSAN SERVICE THEY HAVE NOT FOUND ANYTHING WRONG WITH THIS. *AK
NHTSA ODI #10148583
Mileage unknown · Nov 28, 2005
Service Brakes, Hydraulic
DISK ROTORS AND BRAKES, HAD THEM REPLACES A FEW MONTH AFTER LEASED THE VEHICLE, TWO MONTH LATER THE CAR IS IN THE SAME SHAPE, WHEN BRAKING THE CAR AND THE STEERING WHEEL FEELS LIKE IT IS COMING OFF THE CAR, FEELS VERY DANGEROUS TO DRIVE, DEALER DOES NOT HAVE BRAKE PADS OR ROTORS AND IS PUTTING EVERYONE WITH THE SAME COMPLAIN IN …
Read full complaint
DISK ROTORS AND BRAKES, HAD THEM REPLACES A FEW MONTH AFTER LEASED THE VEHICLE, TWO MONTH LATER THE CAR IS IN THE SAME SHAPE, WHEN BRAKING THE CAR AND THE STEERING WHEEL FEELS LIKE IT IS COMING OFF THE CAR, FEELS VERY DANGEROUS TO DRIVE, DEALER DOES NOT HAVE BRAKE PADS OR ROTORS AND IS PUTTING EVERYONE WITH THE SAME COMPLAIN IN A WAITING LIST. WHAT IS OUT OPTIONS WHEN SOMETHING LIKE THIS IS HAPPENING TO ALL THE 2005 NISSAN ARMADA? *JB
NHTSA ODI #10143754
7,058 miles · Nov 7, 2005
Service Brakes, Hydraulic
WHEN APPLYING BRAKES THERE IS VIBRATION IN STEERING. *TS ***NO ANSWER REQUIRED*** UPDATED 11/7/2005 - THE VEHICLE WAS TAKEN TO THE DEALER TWICE WITHIN 3 MONTHS FOR THIS PROBLEM. THE DEALER REPLACED THE ROTORS BUT THE PROBLEM RESURFACED. THE DEALER ALSO INSTALLED A NEW BRAKE KIT WITH BRAKE PADS PER SERVICE BULLETIN INFORMATI…
Read full complaint
WHEN APPLYING BRAKES THERE IS VIBRATION IN STEERING. *TS ***NO ANSWER REQUIRED*** UPDATED 11/7/2005 - THE VEHICLE WAS TAKEN TO THE DEALER TWICE WITHIN 3 MONTHS FOR THIS PROBLEM. THE DEALER REPLACED THE ROTORS BUT THE PROBLEM RESURFACED. THE DEALER ALSO INSTALLED A NEW BRAKE KIT WITH BRAKE PADS PER SERVICE BULLETIN INFORMATION. THE CONSUMER SENT A LETTER TO THE MANUFACTURER REQUESTING IMMEDAITE RESTITUTION BEACUSE THE DEALER FAILED TO CONFORM TO A SAFETY DEFECT WITHIN A REASONABLE NUMBER OF REPAIR ATTEMPTS. THE CONSUMER RECEIVED A RESPONSE STATING THAT NISSAN WAS AWARE OF THE SAFETY DEFECT AND HAD RESPONDED BY EXTENDING THE WARRANTY ON THE COMPONENT AND BY HAVING BOSCH, CO. DEVELOP A REPLACEMENT PART. *NM
NHTSA ODI #10142153
Mileage unknown · Oct 13, 2005
Engine And Engine CoolingFuel System, GasolineSeat Belts
DT: THE CONSUMER STATED THAT ON MARCH 5, 2005 THE DRIVER'S AND PASSENGER'S SEAT BELTS LOCKED WHEN APPLYING THE BRAKES, THE SEAT BELTS TIGHTENED LIKE THEY WERE CHOKING THE CONSUMER. THE MIDDLE ROW SEAT LOCKED, BUT DID NOT CATCH IN ORDER TO KEEP THE CONSUMER FROM GOING FORWARD. ALSO WHEN PRESSING ON THE BRAKES THE VEHICLE…
Read full complaint
DT: THE CONSUMER STATED THAT ON MARCH 5, 2005 THE DRIVER'S AND PASSENGER'S SEAT BELTS LOCKED WHEN APPLYING THE BRAKES, THE SEAT BELTS TIGHTENED LIKE THEY WERE CHOKING THE CONSUMER. THE MIDDLE ROW SEAT LOCKED, BUT DID NOT CATCH IN ORDER TO KEEP THE CONSUMER FROM GOING FORWARD. ALSO WHEN PRESSING ON THE BRAKES THE VEHICLE SHOOK SO VIOLENTLY THAT ONE COULD NOT HANG ONTO THE WHEEL. THE CONSUMER HAD TAKEN THE VEHICLE TO THE DEALER FOR THE BRAKES, AND THE DEALER SAID THAT THE VEHICLE NEEDED A NEW BRAKE SYSTEM. IN ADDITION, THE CHECK ENGINE LIGHT HAD COME ON. THE VEHICLE WAS TAKEN TO THE DEALERS ON OCTOBER 5, 2005 BECAUSE THE FUEL PUMP CRACKED. THE VEHICLE NEEDED A NEW EXHAUST MANIFOLD AND THE ENGINE BLEW OUT. THE VEHICLE NEEDED A NEW ENGINE. CURRENTLY THE VEHICLE HAD 12, 000 MILES ON IT. *AK UPDATED 11/29/2005 - *NM (12/05/05) THE CHILD SAFETY SEAT WAS REPLACED TWICE. THE REAR SECOND ROW SEAT SNAPPED AND PUSHED FORWARD WITH THE CHILD IN THE CAR SEAT. *SC
NHTSA ODI #10139541
7,058 miles · Sep 29, 2005
Service Brakes, Hydraulic
CONSUMER STEERING WHEEL VIBRATES WHEN APPLYING BRAKES. *TS ***NAR RECEIVED 9-29-05*** THE VEHICLE WAS TAKEN TO THE DEALER TWICE WITHIN 3 MONTHS FOR THIS PROBLEM. THE DEALER REPLACED THE ROTORS BUT THE PROBLEM RESURFACED. *NM
NHTSA ODI #10138866
5,000 miles · Sep 1, 2005
Service Brakes, Hydraulic
THE BRAKES ON MY 2005 ARMADA WARPED AT ABOUT 5,000 MILES. I TOOK IT TO THE DEALERSHIP AND WAS INFORMED THEY HAVE AN UPGRADE KIT TO FIX THE PROBLEM BECAUSE THE STOCK BRAKES ARE TOO SMALL FOR THE VEHICLE. WHEN I PICKED UP THE VEHICLE, I WAS INFORMED THAT THEY ONLY TURNED THE ROTORS BECAUSE THEY DIDN'T HAVE THE PARTS AND NOW CANN…
Read full complaint
THE BRAKES ON MY 2005 ARMADA WARPED AT ABOUT 5,000 MILES. I TOOK IT TO THE DEALERSHIP AND WAS INFORMED THEY HAVE AN UPGRADE KIT TO FIX THE PROBLEM BECAUSE THE STOCK BRAKES ARE TOO SMALL FOR THE VEHICLE. WHEN I PICKED UP THE VEHICLE, I WAS INFORMED THAT THEY ONLY TURNED THE ROTORS BECAUSE THEY DIDN'T HAVE THE PARTS AND NOW CANNOT GIVE ME THE UPGRADE BECAUSE THERE IS NO VISIBLE PROBLEM AND NISSAN WILL NOT AUTHORIZE THE WORK. I WAS NEVER ASKED IF I WANTED THE ROTORS TURNED. IT APPEARS THAT THEY ARE TRYING TO AVOID A RECALL BY MAKING IT LOOK LIKE THEY ARE FIXING THE PROBLEM, BUT THEN ONLY DOING WHAT COSTS THEM THE LEAST. *NM
NHTSA ODI #10135091
3,000 miles · Aug 18, 2005
Service Brakes, Hydraulic
I OWN A NISSAN ARMADA SUV (MODEL LE 5.6 V8). THE CAR WAS PURCHASED NEW IN 3/2005 AND NOW HAS SOME 3000 MILES. WE EXPERIENCED STRONG VIBRATION OF THE STEERING WHEEL WHILE BRAKING AND TOOK THE CAR TO THE SERVICE DEPT. AT THE RENO (NV) DEALERSHIP. YESTERDAY, THE DEALERSHIP TOLD US THAT NISSAN HAS A PROBLEM WITH ALL ARMADA & TITA…
Read full complaint
I OWN A NISSAN ARMADA SUV (MODEL LE 5.6 V8). THE CAR WAS PURCHASED NEW IN 3/2005 AND NOW HAS SOME 3000 MILES. WE EXPERIENCED STRONG VIBRATION OF THE STEERING WHEEL WHILE BRAKING AND TOOK THE CAR TO THE SERVICE DEPT. AT THE RENO (NV) DEALERSHIP. YESTERDAY, THE DEALERSHIP TOLD US THAT NISSAN HAS A PROBLEM WITH ALL ARMADA & TITAN MODELS OF 2004/2005 AND THE PROBLEM IS CAUSING ALL BRAKES TO VIBRATE AS THE BRAKE DISCS TOUCH THE BRAKE PADS. THIS IS APPARENTLY SOMETHING THAT NISSAN KNOWS FOR A WHILE BECAUSE ALL THE PARTS ARE ON "BACK ORDER" AND WILL NOT BE AVAILABLE FOR A FEW MONTHS AND INVOLVES > 100,000 VEHICLES. THE DEALER TOLD US THAT THE PROBLEM MAY COME BACK IN A FEW MONTHS / THOUSANDS OF MILES AND FOR THE MEANTIME THE "BRAKES WERE WARPED" WHICH IS A TEMPORARY FIX. WE ARE INTERESTED TO INVESTIGATE WHY (A) NISSAN HAS NOT DECLARED A FORMAL RECALL TO FIX THE PROBLEM AND MAKE CUSTOMERS AWARE THAT A PROBLEM EXISTS AND (B) TO FIND OUT IF THE PROBLEM IS HAZARDOUS TO LIFE AND IF OTHER PEOPLE COMPLAINED ABOUT THE SAME PROBLEM. THANK YOU. *NM
NHTSA ODI #10133346
3,000 miles · Aug 1, 2005
Service Brakes, Hydraulic
DT: CONSUMER STATED THAT THE BRAKING SYSTEM CAUSED THE STEERING WHEEL TO VIBRATE AND PULL TO THE RIGHT. HE WAS TOLD BY SOMEONE WHO DID NOT WORK FOR NISSAN BUT FOR ENTERPRISE RENTAL CAR THAT THE ROTORS WERE NOT SUFFICIENT FOR THE SIZE AND WEIGHT OF THE VEHICLE. HE TOOK THE VEHICLE TO A DEALERSHIP, AND HE WAS TOLD THAT NISSA…
Read full complaint
DT: CONSUMER STATED THAT THE BRAKING SYSTEM CAUSED THE STEERING WHEEL TO VIBRATE AND PULL TO THE RIGHT. HE WAS TOLD BY SOMEONE WHO DID NOT WORK FOR NISSAN BUT FOR ENTERPRISE RENTAL CAR THAT THE ROTORS WERE NOT SUFFICIENT FOR THE SIZE AND WEIGHT OF THE VEHICLE. HE TOOK THE VEHICLE TO A DEALERSHIP, AND HE WAS TOLD THAT NISSAN WAS SENDING OUT THE REPAIR KITS AND WILL HAVE THE VEHICLES FIXED. CONSUMER WAS CONCERNED THAT THERE WASN'T A RECALL ,BUT NISSAN WAS FIXING THE PROBLEM. CONSUMER TOOK VEHICLE TO THE SERVICE DEPARTMENT TWICE, AND WAS TOLD IT WILL BE A CONTINUING PROBLEM UNTIL THE KIT ARRIVED TO FIX THE PROBLEM PERMANENTLY. THE PROBLEM WAS BETTER WHEN THE VEHICLE WAS TAKEN I TO DEALER, BUT THE SAME THING HAPPENED AFTER A WEEK.*AK *NM
NHTSA ODI #10127295
4,000 miles · Jul 18, 2005
Service Brakes, HydraulicStructureVisibility
THERE ARE MULTIPLE ISSUES WITH THE NISSAN ARMADA 2005 VEHICLE. 1ST, THE BRAKES HAVE GONE OUT NUMEROUS TIMES AND HAVE HAD TO BE REPLACED. 2ND, NUMEROUS RATTLES THROUGHOUT THE VEHICLE HAVE GONE UNFIXED BY NISSAN SERVICE - SOME RATTLES ARE SERIOUS ENOUGH TO WHERE THE FRONT DRIVER'S SIDE DOOR OPENS A INCH OR SO OVER A LARGE BUMP I…
Read full complaint
THERE ARE MULTIPLE ISSUES WITH THE NISSAN ARMADA 2005 VEHICLE. 1ST, THE BRAKES HAVE GONE OUT NUMEROUS TIMES AND HAVE HAD TO BE REPLACED. 2ND, NUMEROUS RATTLES THROUGHOUT THE VEHICLE HAVE GONE UNFIXED BY NISSAN SERVICE - SOME RATTLES ARE SERIOUS ENOUGH TO WHERE THE FRONT DRIVER'S SIDE DOOR OPENS A INCH OR SO OVER A LARGE BUMP IN THE ROAD (SOMETHING COULD BE WRONG WITH THE LATCHING MECHANISM OR FORM FIT BETWEEN THE DOOR AND BODY). THE REAR CARGO DOOR HAS RATTLE AND VIBRATION ISSUES. 3RD) A SERIOUS VISIBILITY ISSUE THROUGH THE FRONT WINDSHIELD HAS BEEN IGNORED BY NISSAN SERVICE AND CUSTOMER SERVICE. THERE IS A SERIOUS VISIUAL PROBLEM THROUGH THE FRONT WINDSHIELD THAT CAUSES DOUBLE VISION (SOME SORT OF OPTICAL ISSUE WITH CARLEX GLASS) - NISSAN HAS REFUSED TO REPAIR DUE TO COMPARISON WITH OTHER ARMADAS HAVE THE SAME ISSUE.
NHTSA ODI #10129214
2,000 miles · Jul 18, 2005
Service Brakes, AirService Brakes, Hydraulic
BOUGHT NISSAN ARMADA JANUARY 2005. BY MARCH OF 2005 JUST A LITTLE OVER 2000 MILES THE STEERING WHEEL STARTED SHAKING WHEN BRAKING. BROUGHT CAR BACK TO DEALER AND WAS TOLD ROTORS TOO SMALL FOR THE CAR. ROTORS REPLACED. STEERING STARTED SHAKING AGAIN EARLY JUNE. CAR BROUGHT BACK AGAIN. TOLD IT WAS THE SAME PROBLEM AND THE PE…
Read full complaint
BOUGHT NISSAN ARMADA JANUARY 2005. BY MARCH OF 2005 JUST A LITTLE OVER 2000 MILES THE STEERING WHEEL STARTED SHAKING WHEN BRAKING. BROUGHT CAR BACK TO DEALER AND WAS TOLD ROTORS TOO SMALL FOR THE CAR. ROTORS REPLACED. STEERING STARTED SHAKING AGAIN EARLY JUNE. CAR BROUGHT BACK AGAIN. TOLD IT WAS THE SAME PROBLEM AND THE PERMENENT "FIX" WOULD BE AVAILABLE BY THE END OF JUNE. TOLD AT THE END OF JUNE THE "FIX" WOULD BE AVAILABLE BUY MID JULY. NOW MID JULY WITH NO "FIX" AVAILABLE. STEERING WHEEL SHAKES SO BADLY IT IS DIFFICULT TO DRIVE. CAR WILL BE BROUGHT IN FOR THE 3RD TIME ON 7/19/05 FOR THIRD VISIT AND 2ND SET OF ROTORS. STILL NO PERMENENT "FIX" AVAILABLE.
NHTSA ODI #10129083
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration