TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT THE VEHICLE SUDDENLY STALLED WHILE SHE WAS DRIVING APPROXIMATELY 60 MPH. IMMEDIATELY AFTER THE VEHICLE STALLED, THE POWER STEERING FAILED. SHE HAD TO WAIT 25 MINUTES IN ORDER TO RESTART THE VEHICLE. THE FAILURE OCCURRED ONCE EVERY TWO MONTHS BUT PROGRESSED AND WAS…
Read full complaint
TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT THE VEHICLE SUDDENLY STALLED WHILE SHE WAS DRIVING APPROXIMATELY 60 MPH. IMMEDIATELY AFTER THE VEHICLE STALLED, THE POWER STEERING FAILED. SHE HAD TO WAIT 25 MINUTES IN ORDER TO RESTART THE VEHICLE. THE FAILURE OCCURRED ONCE EVERY TWO MONTHS BUT PROGRESSED AND WAS NOW A WEEKLY OCCURRENCE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO PERFORMED A TUNE UP AND CHANGED THE OIL; HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO WAS PERFORMING A DIAGNOSTIC TEST WHEN THE COMPLAINT WAS FILED. THE CONTACT VIEWED INFORMATION ON THE INTERNET THAT INDICATED THAT THE INTEGRATED POWER DISTRIBUTION MODULE MIGHT HAVE CAUSED THE FAILURE TO OCCUR. THE CONTACT HAD NOT SPOKEN WITH THE MANUFACTURER. THE CURRENT MILEAGE WAS APPROXIMATELY 108,000. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.
NHTSA ODI #10342679
52,000 miles · Nov 8, 2009
Engine And Engine Cooling
2005 NISSAN ARMADA.. HAVE A HOLE IN RADIATOR THAT NEEDS REPLACEMENT. HAS HAPPENED TWICE WITHIN THE PAST TWO MONTHS. HAD IT REPLACED IN AUGUST WHILE ON VACATION THEN LAST WEEK SMELLED THE ANTIFREEZE AND I TOOK IT TO A DEALER AND THEY SAID THERE IS A WHOLE IN THE CENTER OF THE RADIATOR AND WE NEED A NEW RADIATOR. WE HAVE A GUARD O…
Read full complaint
2005 NISSAN ARMADA.. HAVE A HOLE IN RADIATOR THAT NEEDS REPLACEMENT. HAS HAPPENED TWICE WITHIN THE PAST TWO MONTHS. HAD IT REPLACED IN AUGUST WHILE ON VACATION THEN LAST WEEK SMELLED THE ANTIFREEZE AND I TOOK IT TO A DEALER AND THEY SAID THERE IS A WHOLE IN THE CENTER OF THE RADIATOR AND WE NEED A NEW RADIATOR. WE HAVE A GUARD ON BOTTOM OF TRUCK TO PREVENT THIS FROM HAPPENING AND DEALER SAYS THIS IS A RARE OCCURRENCE WITH THIS MODEL. PURCHASED THE EXTENDED WARRANTY AND IT IS CURRENTLY SITTING AT THE DEALER WAITING TO HAVE AN INSPECTOR COME AND SEE IT SO THE WARRANTY COMPANY CAN DECIDE IF IT WILL BE COVERED. IM STILL WAITING FOR A DECISION ON THE FIRST ONE WHICH WE PAID OUT OF POCKET. *TR
NHTSA ODI #10291403
22,000 miles · Sep 2, 2009
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT IF THE VEHICLE ACCELERATES PAST 35 MPH THE VEHICLE WILL STALL. AS A CONSEQUENCE HER RISK FOR VEHICLE CRASH WAS INCREASED. SHE TOOK THE VEHICLE TO THE DEALER AND HAD THE CATALYTIC CONVERTER REPLACED. THE REPAIR DID NOT REMEDY THE FAILURE. THE CURRENT MILEAGE WAS 7…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT IF THE VEHICLE ACCELERATES PAST 35 MPH THE VEHICLE WILL STALL. AS A CONSEQUENCE HER RISK FOR VEHICLE CRASH WAS INCREASED. SHE TOOK THE VEHICLE TO THE DEALER AND HAD THE CATALYTIC CONVERTER REPLACED. THE REPAIR DID NOT REMEDY THE FAILURE. THE CURRENT MILEAGE WAS 73000. THE FAILURE MILEAGE WAS 22000.
NHTSA ODI #10282679
90,000 miles · Nov 18, 2008
Engine And Engine Cooling
FOR THE PAST TWO MONTH WHEN STARTING MY VEHICLE GREY SMOKE COMES OUT OF THE BACK OF THE CAR. I ALSO HAVE TO REPLACE THE OIL IN THE CAR EVERY COUPLE OF DAYS. *TR
NHTSA ODI #10249167
27,700 miles · Aug 27, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING APPROXIMATELY 70 MPH, THE ENGINE COMPLETELY SHUT OFF. THE CONTACT WAS ABLE TO RESTART THE ENGINE ONE HOUR AFTER THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC TESTING. THE CONTACT WAS INFORMED THAT THE BATTERY AND ALTERNATOR WERE OPERATIN…
Read full complaint
TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING APPROXIMATELY 70 MPH, THE ENGINE COMPLETELY SHUT OFF. THE CONTACT WAS ABLE TO RESTART THE ENGINE ONE HOUR AFTER THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC TESTING. THE CONTACT WAS INFORMED THAT THE BATTERY AND ALTERNATOR WERE OPERATING NORMALLY; THEREFORE, HE SCHEDULED AN APPOINTMENT AT AN AUTHORIZED DEALER FOR THE VEHICLE TO BE REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 27,700 AND CURRENT MILEAGE WAS 27,900.
NHTSA ODI #10239964
15,000 miles · Jan 23, 2007
Engine And Engine Cooling
THE VEHICLE HAS A CONSISTENT, OVER-ACCENTUATED VIBRATION AND NOISE THAT EMANATES FROM THE ENGINE COMPARTMENT WHEN UNDER ACCELERATION, ESPECIALLY MINOR ACCELERATION IN HIGH GEAR. THE NOISE IS LOUD AND DISTRACTING, THE VIBRATION IS PRONOUNCED AND CAN BE FELT IN THE STEERING WHEEL, GAS & BRAKE PEDAL AND GEAR SHIFT. IT GIVES YOUR …
Read full complaint
THE VEHICLE HAS A CONSISTENT, OVER-ACCENTUATED VIBRATION AND NOISE THAT EMANATES FROM THE ENGINE COMPARTMENT WHEN UNDER ACCELERATION, ESPECIALLY MINOR ACCELERATION IN HIGH GEAR. THE NOISE IS LOUD AND DISTRACTING, THE VIBRATION IS PRONOUNCED AND CAN BE FELT IN THE STEERING WHEEL, GAS & BRAKE PEDAL AND GEAR SHIFT. IT GIVES YOUR FEET AND HANDS A "BUZZY" VIBRATION WHICH IS UNCOMFORTABLE AND DISTRACTING. IT FEELS AND SOUNDS AS IF A MOTOR MOUNT OR SOME TYPE OF VIBRATION DAMPING PART HAS FAILED AND IS SENDING THE VIBRATION INTO THE PASSENGER COMPARTMENT. LOCAL NISSAN DEALER SERVICE DEPT. CLAIMS "IT'S SUPPOSED TO BE THAT WAY BECAUSE ITS GOT A BIG ENGINE IN IT." I THINK NOT. *NM
NHTSA ODI #10179451
14,000 miles · May 30, 2006
Engine And Engine Cooling
DT*: THE CONTACT STATED THAT WHILE DRIVING 70 MPH ON THE FREEWAY, THE VEHICLE STALLED. THE ENGINE WAS POWERLESS, BUT THE ELECTRICAL SYSTEM REMAINED OPERATIONAL. THERE WAS SUFFICIENT MOMENTUM TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO A SERVICE DEALER. DUE TO THE HOLIDAY, THERE HAS BEEN NO COM…
Read full complaint
DT*: THE CONTACT STATED THAT WHILE DRIVING 70 MPH ON THE FREEWAY, THE VEHICLE STALLED. THE ENGINE WAS POWERLESS, BUT THE ELECTRICAL SYSTEM REMAINED OPERATIONAL. THERE WAS SUFFICIENT MOMENTUM TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO A SERVICE DEALER. DUE TO THE HOLIDAY, THERE HAS BEEN NO COMMUNICATION WITH THE SERVICE DEALER.
NHTSA ODI #10158537
Mileage unknown · Oct 13, 2005
Engine And Engine CoolingFuel System, GasolineSeat Belts
DT: THE CONSUMER STATED THAT ON MARCH 5, 2005 THE DRIVER'S AND PASSENGER'S SEAT BELTS LOCKED WHEN APPLYING THE BRAKES, THE SEAT BELTS TIGHTENED LIKE THEY WERE CHOKING THE CONSUMER. THE MIDDLE ROW SEAT LOCKED, BUT DID NOT CATCH IN ORDER TO KEEP THE CONSUMER FROM GOING FORWARD. ALSO WHEN PRESSING ON THE BRAKES THE VEHICLE…
Read full complaint
DT: THE CONSUMER STATED THAT ON MARCH 5, 2005 THE DRIVER'S AND PASSENGER'S SEAT BELTS LOCKED WHEN APPLYING THE BRAKES, THE SEAT BELTS TIGHTENED LIKE THEY WERE CHOKING THE CONSUMER. THE MIDDLE ROW SEAT LOCKED, BUT DID NOT CATCH IN ORDER TO KEEP THE CONSUMER FROM GOING FORWARD. ALSO WHEN PRESSING ON THE BRAKES THE VEHICLE SHOOK SO VIOLENTLY THAT ONE COULD NOT HANG ONTO THE WHEEL. THE CONSUMER HAD TAKEN THE VEHICLE TO THE DEALER FOR THE BRAKES, AND THE DEALER SAID THAT THE VEHICLE NEEDED A NEW BRAKE SYSTEM. IN ADDITION, THE CHECK ENGINE LIGHT HAD COME ON. THE VEHICLE WAS TAKEN TO THE DEALERS ON OCTOBER 5, 2005 BECAUSE THE FUEL PUMP CRACKED. THE VEHICLE NEEDED A NEW EXHAUST MANIFOLD AND THE ENGINE BLEW OUT. THE VEHICLE NEEDED A NEW ENGINE. CURRENTLY THE VEHICLE HAD 12, 000 MILES ON IT. *AK UPDATED 11/29/2005 - *NM (12/05/05) THE CHILD SAFETY SEAT WAS REPLACED TWICE. THE REAR SECOND ROW SEAT SNAPPED AND PUSHED FORWARD WITH THE CHILD IN THE CAR SEAT. *SC
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
2005 Nissan Armada Problems, Complaints & Recalls | Skip That Year
Illustration