NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
28 reportsClear category filter68,000 miles · May 6, 2021
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT THE MUFFLER HAD BEEN REPLACED 3 TIMES DUE TO IT CRACKING AROUND THE HEADER. THE CONTACT STATED THAT THE MUFFLER DAMAGED WIRING HARNESS AND THE COMPUTER SYSTEM, WHICH CAUSED THE VEHICLE TO STALL. HUMMEL'S NISSAN (4770 MERLE HAY RD, DES MOINES, IA 50322) WAS MADE A…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT THE MUFFLER HAD BEEN REPLACED 3 TIMES DUE TO IT CRACKING AROUND THE HEADER. THE CONTACT STATED THAT THE MUFFLER DAMAGED WIRING HARNESS AND THE COMPUTER SYSTEM, WHICH CAUSED THE VEHICLE TO STALL. HUMMEL'S NISSAN (4770 MERLE HAY RD, DES MOINES, IA 50322) WAS MADE AWARE OF THE FAILURE. THE MUFFLER WAS REPLACED TWICE BY THE DEALER HOWEVER, THE MUFFLER FAILURE RECURRED. THE MUFFLER WAS REPLACED A THIRD TIME BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 68,000.
NHTSA ODI #11415418
120,000 miles · Sep 12, 2018
Air BagsEngine And Engine CoolingFuel System, Gasoline
THE FUEL SHOWS THAT I HAVE A QUARTER OF A TANK OR A BIT MORE LEFT AND THE NUMBER MILEAGE ON THE SCREEN SHOWS THE SAME. MY VEHICLE RANDOMLY STOPS WITHOUT WARNING. THIS HAS HAPPENED 3 TIMES. I HAD THE VEHICLE REPAIRED LAST YEAR FOR THE SAME REASON AND HERE I AM AGAIN. I SEE THERE IS A RECALL AND MY CAR WAS NOT INCLUDED. I CAL…
Read full complaint
THE FUEL SHOWS THAT I HAVE A QUARTER OF A TANK OR A BIT MORE LEFT AND THE NUMBER MILEAGE ON THE SCREEN SHOWS THE SAME. MY VEHICLE RANDOMLY STOPS WITHOUT WARNING. THIS HAS HAPPENED 3 TIMES. I HAD THE VEHICLE REPAIRED LAST YEAR FOR THE SAME REASON AND HERE I AM AGAIN. I SEE THERE IS A RECALL AND MY CAR WAS NOT INCLUDED. I CALLED NISSAN AND THE REPRESENTATIVE TOLD ME TOLD CONTACT NHTSA TO BE MORE EFFECTIVE.....HE ACKNOWLEDGED THE PROBLEM WITH THE TRUCKS. I FEEL AS THOUGH IT IS A DEFINITE SAFETY HAZARD. WE WERE LUCKY THIS TIME. MY AIR BAG LIGHT WILL NOT SHUT OFF EITHER AND HE MENTIONED THIS WAS ANOTHER RECALL.. WHY DID THIS VIN MISS THE RECALLS. IT CLEARLY HAS THOSE ISSUES. THEY WANT ME TO GO TO A DEALER AND I CANNOT AFFORD TO DO THAT. THE DEALERS ARE MORE EXPENSIVE. HOPEFULLY THERE IS ASSISTANCE. THERE IS A RATTLE WITH THE A/C FAN. I DON'T KNOW WHAT IS GOING ON WITH THAT HOWEVER I HAVE AN ODOR FROM IT AS WELL. AGAIN I AM BRINGING IT BACK TO THE MECHANIC HOWEVER THE TOW COMPANY GAVE ME THE RECALL INFO AND I DON'T UNDERSTAND HOW THIS TRUCK WAS MISSED. CAN YOU HELP WITH THE RECALL FOR US. RECALL #'S 10V51700,10V074000,10V349000. OUR THANKS *TR
NHTSA ODI #11129160
112,000 miles · Mar 22, 2017
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE MADE AN ABNORMAL NOISE AND THERE WAS AN EXHAUST ODOR IN THE VEHICLE. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. SEVERAL YEARS PRIOR TO THE FAILURE, BOTH EXHAUST MANIFOLDS WERE REPLACED ON THE VEHICLE. THE MA…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE MADE AN ABNORMAL NOISE AND THERE WAS AN EXHAUST ODOR IN THE VEHICLE. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. SEVERAL YEARS PRIOR TO THE FAILURE, BOTH EXHAUST MANIFOLDS WERE REPLACED ON THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 112,000 THE VIN WAS NOT PROVIDED. UPDATED 06/13/17*LJ *AS
NHTSA ODI #10967843
91,000 miles · Aug 1, 2013
Engine And Engine Cooling
I HAVE BEEN TO THE NISSAN DEALERSHIP MULTIPLE TIMES AND COMPLAINED ABOUT THE LOUD EXHAUST NOISE AND THEY SAID IT WAS NORMAL FOR THIS VEHICLE. THERE ARE THOUSANDS OF REPORTS OF THIS EXACT PROBLEM ONLINE. I HAVE JUST FAILED MY STATE SAFETY INSPECTION IN MISSOURI AND FOUND OUT THAT THE LOUD NOISE WAS BECAUSE OF A MANUFACTURER DEF…
Read full complaint
I HAVE BEEN TO THE NISSAN DEALERSHIP MULTIPLE TIMES AND COMPLAINED ABOUT THE LOUD EXHAUST NOISE AND THEY SAID IT WAS NORMAL FOR THIS VEHICLE. THERE ARE THOUSANDS OF REPORTS OF THIS EXACT PROBLEM ONLINE. I HAVE JUST FAILED MY STATE SAFETY INSPECTION IN MISSOURI AND FOUND OUT THAT THE LOUD NOISE WAS BECAUSE OF A MANUFACTURER DEFECT ON THE EXHAUST MANIFOLDS. BOTH ARE BROKEN IN THE SAME PLACE. NISSAN IS UNWILLING TO PROVIDE REPLACEMENT PARTS THAT HAVE BEEN DEFECTIVE FROM THE START.I BELIEVE IT IS UNETHICAL FOR NISSAN TO KNOWINGLY NOT OFFER REPLACEMENTS. MY FAMILY HAS BEEN AT RISK FOR YEARS AND NISSAN REFUSES TO TAKE RESPONSIBILITY. WHAT ARE MY OPTIONS TO TAKE ACTION? HOW MANY COMPLAINTS HAVE YOU SEEN? *TR
NHTSA ODI #10533085
55,000 miles · Jul 31, 2013
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, HE HEARD A LOUD NOISE FROM THE EXHAUST SYSTEM. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE EXHAUST MANIFOLD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. TH…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, HE HEARD A LOUD NOISE FROM THE EXHAUST SYSTEM. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE EXHAUST MANIFOLD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000.
NHTSA ODI #10532932
127,500 miles · Feb 7, 2013
Engine And Engine CoolingPower Train
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE TRANSMISSION FAILED TO SHIFT OUT OF THIRD GEAR. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTICS. THE DEALER NOTICED RADIATOR FLUID MIXING WITH TRANSMISSION FLUID WHICH CAUSED THE TRANSMISSION TO STALL. THE VEHICLE WAS NOT REPAIRED. THE…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE TRANSMISSION FAILED TO SHIFT OUT OF THIRD GEAR. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTICS. THE DEALER NOTICED RADIATOR FLUID MIXING WITH TRANSMISSION FLUID WHICH CAUSED THE TRANSMISSION TO STALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 127,500. UPDATED 04/30/13*LJ THE CONSUMER STATED HER HUSBAND NOTICED THE GEARS WERE NOT SHIFTING PROPERLY AND SOON THE CHECK ENGINE LIGHT ILLUMINATED. THE NEXT DAY, THE CONSUMER TOOK THE VEHICLE TO THE DEALER. THE INSPECTION REVEALED THE VALVE BODY WAS BAD AND THE RADIATOR WAS LEAKING FLUID INTO THE TRANSMISSION. UPDATED 05/08/13
NHTSA ODI #10496780
83,000 miles · Nov 28, 2011
Engine And Engine CoolingPower Train
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE PARKED THE CONTACT ATTEMPTED TO PLACE THE VEHICLE INTO DRIVE BUT THE GEAR SHIFTER WOULD NOT MOVE. THE VEHICLE WAS TOWED TO A TRANSMISSION SHOP. THE TECHNICIAN STATED THERE WERE PIECES OF METAL IN THE TRANSMISSION LINE. THE TECHNICIAN ATTEMPTED TO UN-CLOG THE TRANSMISSION LINE BUT …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE PARKED THE CONTACT ATTEMPTED TO PLACE THE VEHICLE INTO DRIVE BUT THE GEAR SHIFTER WOULD NOT MOVE. THE VEHICLE WAS TOWED TO A TRANSMISSION SHOP. THE TECHNICIAN STATED THERE WERE PIECES OF METAL IN THE TRANSMISSION LINE. THE TECHNICIAN ATTEMPTED TO UN-CLOG THE TRANSMISSION LINE BUT WAS UNABLE TO DO SO. THE TECHNICIAN STATED THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000. ....UPDATED 12/03/12 *BF THE CONSUME STATED WHEN SHE MADE A TURN, THE VEHICLE FELT AS THOUGH IT WAS GOING TO STOP. WHEN SHE STOPPED AND LOOKED UNDER THE VEHICLE, SHE SAW A REDDISH COLOR FLUID LEAKING FROM THE VEHICLE, THE CONSUMER WENT TO THE NEAREST REPAIR SHOP WHERE SHE WAS INFORMED THREE WAS A TRANSMISSION PROBLEM. THE VEHICLE WAS THEN TOWED TO A TRANSMISSION SHOP WHERE THEY REPLACED THE RADIATOR LINE WHICH WAS LEAKING. WHEN THEY ATTEMPTED TO REPLACE THE TRANSMISSION FLUID, THEY NOTICED SEVERAL HOLES BETWEEN THE RADIATOR AND TRANSMISSION WERE CLOGGED. UPDATED 01/10/12
NHTSA ODI #10437516
75,000 miles · Oct 17, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED WHILE DRIVING 60 MPH UP HILL, THE VEHICLE STOPPED ACCELERATING. THE CONTACT RELEASED PRESSURE FROM THE ACCELERATOR PEDAL AND WHEN PRESSURE WAS REAPPLIED, THE VEHICLE RESPONDED AS NORMAL. THE FAILURE RECURRED VERY FREQUENTLY AND THE VEHICLE STALLED ON ONE OCCASION. THE…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED WHILE DRIVING 60 MPH UP HILL, THE VEHICLE STOPPED ACCELERATING. THE CONTACT RELEASED PRESSURE FROM THE ACCELERATOR PEDAL AND WHEN PRESSURE WAS REAPPLIED, THE VEHICLE RESPONDED AS NORMAL. THE FAILURE RECURRED VERY FREQUENTLY AND THE VEHICLE STALLED ON ONE OCCASION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE ENGINE CONTROL MODULE FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 75,000. UPDATED 11/04/11*LJ THE CONSUMER STATED THE VEHICLE CONTINUES TO STALL ON THE SLIGHTEST INCLINE. UPDATD 11/14/11
NHTSA ODI #10430482
133,862 miles · Sep 18, 2011
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
DRIVING FINE THEN AFTER STOPPING AT A STOP SIGN, CAR WOULD NOT ACCELERATE, LIKE IT IS IN A HIGHER GEAR. AFTER REACHING 10MPH IT DRIVES PERFECTLY FINE. IF AFTER STOPPING YOU CUT THE ENGINE AND RESTART, IT IS FINE. REVERSE WORKS FINE. CODE P1757 COMES UP ON TEST. A BAD VALVE BODY. I'VE SEEN THIS ALL OVER THE INTERNET MOSTLY ON NIS…
Read full complaint
DRIVING FINE THEN AFTER STOPPING AT A STOP SIGN, CAR WOULD NOT ACCELERATE, LIKE IT IS IN A HIGHER GEAR. AFTER REACHING 10MPH IT DRIVES PERFECTLY FINE. IF AFTER STOPPING YOU CUT THE ENGINE AND RESTART, IT IS FINE. REVERSE WORKS FINE. CODE P1757 COMES UP ON TEST. A BAD VALVE BODY. I'VE SEEN THIS ALL OVER THE INTERNET MOSTLY ON NISSAN '05 MODELS, MAYBE SOME '06. VERY FRUSTRATING, NISSAN SAYS I NEED A WHOLE NEW TRANSMISSION. I'M THINKING A RECALL SHOULD BE LOOKED INTO. IT DOESN'T SEEM TO HAPPEN ON OTHER YEAR MODELS AS MUCH. *TT
NHTSA ODI #10425943
106,100 miles · Sep 8, 2011
Engine And Engine CoolingFuel System, Gasoline
CHECK ENGINE LIGHT REMAINED ON DUE TO CATALYTIC CONVERTER FAILURE. RECEIVED WARRANTY NOTICE FROM NISSAN OF PROBLEM WITH CATALYTIC FAILURE, HOWEVER, MY MILEAGE PREVENTED FREE REPLACEMENT. MY STATE REQUIRE EMISSION TESTING EACH YEAR, THEREFORE, WITHOUT REPLACEMENT I WOULD BE UNABLE TO REGISTER MY TRUCK. MY TRUCK WAS PURCHASED NEW …
Read full complaint
CHECK ENGINE LIGHT REMAINED ON DUE TO CATALYTIC CONVERTER FAILURE. RECEIVED WARRANTY NOTICE FROM NISSAN OF PROBLEM WITH CATALYTIC FAILURE, HOWEVER, MY MILEAGE PREVENTED FREE REPLACEMENT. MY STATE REQUIRE EMISSION TESTING EACH YEAR, THEREFORE, WITHOUT REPLACEMENT I WOULD BE UNABLE TO REGISTER MY TRUCK. MY TRUCK WAS PURCHASED NEW AND IS SERVICE ON A REGULAR BASIS. PAID FOR REPLACEMENT. *TR
NHTSA ODI #10424386
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration