NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
24 reportsClear category filter100,001 miles · Jun 4, 2013
Electrical SystemStructureFire
ON SATURDAY MORNING AT 845AM AT A LAUNDRY PLACE MY VEHICLE WAS PARKED. NEXT THING WE HEAR A LOUD NOISE COMING FROM OUTSIDE THE LAUNDRYMAT PLACE.. MY VEHICLE WAS SMOKING FROM THE HOOD TOWARD THE DASH BOARD AND THEN I COULD NOT EVEN OPEN THE DOOR WITH THE KEY OR THE ALARM BUTTON..SO A FRIEND BROKE THE DRIVER WINDOW AND THEN TRIED …
Read full complaint
ON SATURDAY MORNING AT 845AM AT A LAUNDRY PLACE MY VEHICLE WAS PARKED. NEXT THING WE HEAR A LOUD NOISE COMING FROM OUTSIDE THE LAUNDRYMAT PLACE.. MY VEHICLE WAS SMOKING FROM THE HOOD TOWARD THE DASH BOARD AND THEN I COULD NOT EVEN OPEN THE DOOR WITH THE KEY OR THE ALARM BUTTON..SO A FRIEND BROKE THE DRIVER WINDOW AND THEN TRIED TO STOP THE FIRE FROM SPREADING BUT WAS NOT SUCCESSFUL..I TRIED TO GET MY BELONGS BUT EITHER. MY VEHICLE HAS BEEN MAINTAIN IN GOOD SERVICE AT THE NISSAN DEALER. I ONLY HAD IT FOR APROX 1YR NOTHING WAS WRONG WITH MY CAR UNTIL THAT DAY FOR SOME REASON I DON'T KNOW IT CAUGHT ON FIRE.. I THINK THESE VEHICLE NEED TO BE CHECK OUT..CAUSE MAYBE IF MY KIDS WHERE INSIDE I BELIEVE THEY WOULD HAVE SOME BURN SCARS ON THEM ,BECAUSE THE STUPID DOOR COULD NOT BE OPEN WITH THE OR THE ALARM KEY...*TR
NHTSA ODI #10514995
124,775 miles · Mar 5, 2013
Electrical SystemElectronic Stability Control (esc)Service Brakes
THE INCIDENT HAS HAPPENED TWICE ALREADY ONCE WHILE DRIVING AND GOING ABOUT 35 MILES PER HOUR. THE 2ND WHILE SITTING IN A DRIVE THRU. WHILE SLOWING DOWN FOR THE LIGHT, IT FELT AS THE BRAKES GAVE OUT. THE BRAKE PEDAL DID NOT HAVE ANY PRESSURE IN THEM AND GAVE THIS LOUD CRUNCHING SOUND. ALSO SOUNDED LIKE A SPRING MOANING. IMMEDIATE…
Read full complaint
THE INCIDENT HAS HAPPENED TWICE ALREADY ONCE WHILE DRIVING AND GOING ABOUT 35 MILES PER HOUR. THE 2ND WHILE SITTING IN A DRIVE THRU. WHILE SLOWING DOWN FOR THE LIGHT, IT FELT AS THE BRAKES GAVE OUT. THE BRAKE PEDAL DID NOT HAVE ANY PRESSURE IN THEM AND GAVE THIS LOUD CRUNCHING SOUND. ALSO SOUNDED LIKE A SPRING MOANING. IMMEDIATELY THE BRAKE LIGHT CAME ON AS IF I HAD MY EMERGENCY BRAKES ON. I WAS IN A PANIC AND SWERVED TO THE SIDE OF THE ROAD NOT TO REAR END THE CAR IN FRONT OF ME. THIS CONTINUED UNTIL AFTER I COMPLETELY TURNED OFF THE CAR, LET IT SIT THEN TURNED IT BACK ON. THE LIGHT WENT OFF AND THE BRAKES WORKED AS NORMAL. THE 2ND TIME I WAS IN A DRIVE THRU MOVING FORWARD AND THE BRAKES SEEM TO GIVE OUT. CRUNCHING SOUND, BRAKE LIGHT AND ONLY WENT AWAY WHEN I TURNED THE ARMADA COMPLETELY OFF AND THEN ON AGAIN. AFTER RESEARCHING THE PROBLEM ONLINE IT APPEARS THAT MANY OTHER PEOPLE ARE EXPERIENCING THE SAME PROBLEM. THIS ARMADA, MY WIFE DRIVES TO WORK EVERY DAY BACK AND FORTH. WE CAN'T AFFORD ANOTHER CAR AND I FEAR FOR HER SAFETY AND THE CARS AROUND HER. HERE IS A LINK OF JUST SOME OF THE PEOPLE HAVING THE SAME ISSUE. HTTP://X.NISSANHELP.COM/FORUMS/ARMADA/1852-BRAKE-PROBLEMS-2.HTML. *TR
NHTSA ODI #10501416
143,000 miles · Jun 13, 2011
Electrical SystemService Brakes, Hydraulic
MY BRAKES LOCK UP ON MY 2005 NISSAN ARMADA COMPLETELY. THE VEHICLE RATTLES AND THE FRONT PART MAKES A NOISE AS IF IT IS BREAKING APART. THERE IS NO WARNING WHEN THIS IS GOING TO HAPPEN. THE BRAKE PEDAL LOCKS AND SPRINGS BACK. I TURN THE TRUCK OFF FOR A FEW MINUTES AND THE ISSUE GOES AWAY. OTHER OWNERS ARE HAVING THE SAME ISSUE W…
Read full complaint
MY BRAKES LOCK UP ON MY 2005 NISSAN ARMADA COMPLETELY. THE VEHICLE RATTLES AND THE FRONT PART MAKES A NOISE AS IF IT IS BREAKING APART. THERE IS NO WARNING WHEN THIS IS GOING TO HAPPEN. THE BRAKE PEDAL LOCKS AND SPRINGS BACK. I TURN THE TRUCK OFF FOR A FEW MINUTES AND THE ISSUE GOES AWAY. OTHER OWNERS ARE HAVING THE SAME ISSUE WITH THE BRAKES ELECTRICAL SYSTEM. *TR
NHTSA ODI #10406057
54,000 miles · Sep 1, 2010
Electrical System
OUR ARMADA WOULD INTERMITTENTLY NOT WANT TO START OR TAKE A LONG TIME TO START. THEN SEVERAL WEEKS LATER IT DIED RIGHT AFTER STARTING. ALSO THE LIGHTS ON THE SASH WHERE GOING CRAZY (FLASHING AND STAYING SOLID). TRIED TO START THE TRUCK SEVERAL TIMES WITH IN THE NEXT HOUR WITH OUT ANY LUCK. HAS THE TRUCK TOWED TO NISSAN DEALER, W…
Read full complaint
OUR ARMADA WOULD INTERMITTENTLY NOT WANT TO START OR TAKE A LONG TIME TO START. THEN SEVERAL WEEKS LATER IT DIED RIGHT AFTER STARTING. ALSO THE LIGHTS ON THE SASH WHERE GOING CRAZY (FLASHING AND STAYING SOLID). TRIED TO START THE TRUCK SEVERAL TIMES WITH IN THE NEXT HOUR WITH OUT ANY LUCK. HAS THE TRUCK TOWED TO NISSAN DEALER, WHERE THEY SAID IT WAS THE IPDM MODULE. HAD THEM REPLACE THE PART. *TR
NHTSA ODI #10353322
72,000 miles · Jul 13, 2010
Air BagsElectrical SystemSeat Belts
WE PURCHASED A 2005 ARMADA WITH 50,000 MILES ON IT IN 2009, AT THAT TIME THE DEALER SOLD IT TO US WITH THE AIRBAGS SYSTEM SHOWING THE WARNING LIGHT SOLID. THEY ASKED FOR US TO TAKE IT TO A NEARBY NISSAN DEALER AND GET THE PROBLEM LOOKED AT BECAUSE THEY WERE A SAAB DEALER. THE NISSAN DEALER FIXED THE PROBLEM WITHOUT NOTIFYING US…
Read full complaint
WE PURCHASED A 2005 ARMADA WITH 50,000 MILES ON IT IN 2009, AT THAT TIME THE DEALER SOLD IT TO US WITH THE AIRBAGS SYSTEM SHOWING THE WARNING LIGHT SOLID. THEY ASKED FOR US TO TAKE IT TO A NEARBY NISSAN DEALER AND GET THE PROBLEM LOOKED AT BECAUSE THEY WERE A SAAB DEALER. THE NISSAN DEALER FIXED THE PROBLEM WITHOUT NOTIFYING US OF A COST. THIS ACTION WAS A COST OF $330 WHICH I ASKED THEM TO TAKE THE PART OUT BECAUSE THEY DID NOT HAVE THE SAAB DEALERS AUTHORIZATION. THIS DEALERSHIP TOLD ME NISSAN HONORED THE WORK AND WARRANTY. WE DID NOT PAY A DIME. NOW THE SAME LIGHT IS NOW FLASHING ON THE DASH SINCE 72000 MILES. I STILL HAVE A GOLD WARRANTY ON THE VEHICLE BUT THIS RESTRAINT IS NOT COVERED. IF THIS IS A COMMON PROBLEM AND CAUSES SYSTEM FAILURE ON THE AIRBAGS WHY AREN'T THEY RECALLING IT? *TR
NHTSA ODI #10342826
90,700 miles · Feb 25, 2010
Electrical System
MY COMPLAINT IS WITH A NISSAN ARMADA-I WAS DRIVING ON THE INTERSTATE IN THE LEFT LANE GO ABOUT 70 MPH AND THEN MY CAR JUST TURN OFF WITHOUT ANY WARNING--I DID GET OFF TO THE SIDE OF THE ROAD OK THANKS GOD---THEN TWO DAYS LATER MY CAR WOULD NOT START SO I GOT IT TOWED TO NISSAN DEALERSHIP IN LITTLE ROCK ARKANSAS AND THEN HAD TO R…
Read full complaint
MY COMPLAINT IS WITH A NISSAN ARMADA-I WAS DRIVING ON THE INTERSTATE IN THE LEFT LANE GO ABOUT 70 MPH AND THEN MY CAR JUST TURN OFF WITHOUT ANY WARNING--I DID GET OFF TO THE SIDE OF THE ROAD OK THANKS GOD---THEN TWO DAYS LATER MY CAR WOULD NOT START SO I GOT IT TOWED TO NISSAN DEALERSHIP IN LITTLE ROCK ARKANSAS AND THEN HAD TO REPLACE IPDM(INTELLIGENT POWER DIST. MODULE) THANKS AND HAVE A GREAT DAY- *TR
NHTSA ODI #10314418
11,293 miles · Feb 12, 2009
Air BagsElectrical System
TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING APPROXIMATELY 35 MPH ON NORMAL ROAD CONDITIONS, THE BRAKE, VDC, SLIP, AIR BAG, AND TIRE PRESSURE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. SUDDENLY, A CHIME SOUNDED INSIDE THE PASSENGER COMPARTMENT AND AUTOMATICALLY STOPPED WITHOUT ASSISTANCE. IN ADDITION, …
Read full complaint
TL*THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING APPROXIMATELY 35 MPH ON NORMAL ROAD CONDITIONS, THE BRAKE, VDC, SLIP, AIR BAG, AND TIRE PRESSURE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. SUDDENLY, A CHIME SOUNDED INSIDE THE PASSENGER COMPARTMENT AND AUTOMATICALLY STOPPED WITHOUT ASSISTANCE. IN ADDITION, THE CONTACT SMELLED A BURNING ODOR INSIDE THE VEHICLE THE DAY BEFORE THE FAILURE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE FAILURE WAS RELATED TO THE AIR BAG HARNESS. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 11,293. UPDATED 10/21/10. *LJ THE CONSUMER STATED THE BRAKE, VDC, SLIP, AIR BAG AND TIRE PRESSURE WARNING LIGHTS ILLUMINATED AND HAVE DONE SO REPEATEDLY. UPDATED 10/26/10
NHTSA ODI #10258467
32,152 miles · Oct 8, 2008
Electrical SystemVisibility
VEHICLE'S HEATER/DEFROSTER FAILS TO OPERATE ON ANY GIVEN DAY. SINCE 10/7/2007 THIS VEHICLE HAS BEEN IN THE SHOP 8 TIMES FOR THE HEATER/DEFROSTER ISSUE. NISSAN HAVE REPLACED SEVERAL PARTS, BUT IT STILL DOES NOT OPERATE. THIS IS REFERENCE TO ODI#10212374 DATED 12/19/2007 WHICH I NEVER GOT A RESPONSE. AS OF TODAY 10/8/08, THIS…
Read full complaint
VEHICLE'S HEATER/DEFROSTER FAILS TO OPERATE ON ANY GIVEN DAY. SINCE 10/7/2007 THIS VEHICLE HAS BEEN IN THE SHOP 8 TIMES FOR THE HEATER/DEFROSTER ISSUE. NISSAN HAVE REPLACED SEVERAL PARTS, BUT IT STILL DOES NOT OPERATE. THIS IS REFERENCE TO ODI#10212374 DATED 12/19/2007 WHICH I NEVER GOT A RESPONSE. AS OF TODAY 10/8/08, THIS IS ISSUE IS STILL NOT FIXED! *TR
NHTSA ODI #10244693
56,400 miles · May 23, 2008
Air BagsElectrical SystemService Brakes, Electric
2005 NISSAN ARMADA LE, 56K MILES MULTIPLE ELECTRICAL ISSUES RESULTING IN LOSS OF CRITICAL FUNCTIONS: BRAKING SYSTEM, AIR BAGS, ELECTRICAL POWER ALL WHILE THE VEHICLE IS BEING DRIVEN. HAVE TAKEN TO DEALERSHIP 8 TIMES FOR REPAIRS RELATED TO ELECTRICAL PROBLEMS. MOST RECENTLY, LOSS OF BRAKES OCCURRED WHILE TRAVELING ON A MAJOR …
Read full complaint
2005 NISSAN ARMADA LE, 56K MILES MULTIPLE ELECTRICAL ISSUES RESULTING IN LOSS OF CRITICAL FUNCTIONS: BRAKING SYSTEM, AIR BAGS, ELECTRICAL POWER ALL WHILE THE VEHICLE IS BEING DRIVEN. HAVE TAKEN TO DEALERSHIP 8 TIMES FOR REPAIRS RELATED TO ELECTRICAL PROBLEMS. MOST RECENTLY, LOSS OF BRAKES OCCURRED WHILE TRAVELING ON A MAJOR ROAD @ 50 MPH; LOST BRAKE FUNCTION WHEN APPROACHED STOP LIGHT. THIS HAS HAPPENED MULTIPLE TIMES, I HAVE REPORTED IT TO THE DEALER 4 TIMES. EACH TIME THE CODE IS "CLEARED" BUT NOTHING IS DONE. THIS TIME THEY ARE REPLACING THE ABS BOOSTER, BUT FROM READING POSTS OF OTHER OWNERS, THE PROBLEM RECURS. DEALER REFUSES TO REPORT PROBLEM TO NISSAN. *TR
NHTSA ODI #10228716
27,000 miles · Apr 3, 2008
Electrical SystemFire
I WAS DRIVING MY '05 NISSAN ARMADA (27,000 MILES) WITH MY 2 YR OLD SON AND SMELLED A STRONG ODOR, THINKING IT WAS FROM A TRUCK DRIVING NEXT TO ME. I PICKED UP MY DAUGHTER, PUT BOTH CHILDREN IN THEIR CAR SEATS AND STARTED THE IGNITION. TWO PUFFS OF SMOKE CAME OUT ON EITHER SIDE OF THE ENGINE. I QUICKLY UNBUCKLED MY CHILDREN, RA…
Read full complaint
I WAS DRIVING MY '05 NISSAN ARMADA (27,000 MILES) WITH MY 2 YR OLD SON AND SMELLED A STRONG ODOR, THINKING IT WAS FROM A TRUCK DRIVING NEXT TO ME. I PICKED UP MY DAUGHTER, PUT BOTH CHILDREN IN THEIR CAR SEATS AND STARTED THE IGNITION. TWO PUFFS OF SMOKE CAME OUT ON EITHER SIDE OF THE ENGINE. I QUICKLY UNBUCKLED MY CHILDREN, RAN THEM INTO THE SCHOOL AND SMOKE STARTED BILLOWING OUT OF THE ENGINE. THE FIRE DEPT WAS CALLED & SCHOOL WAS EVACUATED. WITHIN 15 MIN, THE ENGINE AREA WAS ENGULFED IN FLAMES. THE VEHICLE WAS A TOTAL LOSS. I HAD MULTIPLE PROBLEMS WITH THE BATTERY. NISSAN HAS REFUSED TO ASSIST ME IN ANY WAY. *TR
NHTSA ODI #10223318
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration