2000 Nissan Altima

AT 46,000 MILES THE CAR BEGAN SHAKING AND STALLING AT LOW SPEEDS, THEN THE CHECK ENGINE LIGHT CAME ON. WE TOOK IT TO THE NISSAN DEALERSHIP AND WE WERE TOLD IT WAS THE INTAKE MANIFOLD GASKET & IT WAS REPAIRED. NOW 25,000 MILES LATER THE SAME PROBLEM IS OCCURRING AND AGAIN IT IS DUE TO THE INTAKE MANIFOLD GASKET FAILING. WE HAVE ESTIMATES TO REPAIR IT RANGING FROM $600-$1,000.00. THE NISSAN DEALERSHIP WHO RECENTLY REPAIRED IT WILL NOT STAND BEHIND THEIR PRODUCT. THIS IS A DEFECTIVE PART, THERE IS NO WAY THAT GASKET SHOULD FAIL IN 25,000 MILES. I HAVE TALKED TO A SERVICE MANAGER AT A LOCAL NISSAN DEALERSHIP(NOT THE ONE WHO REPAIRED IT THE FIRST TIME) AND HE SAID THERE IS NO WAY THAT PART SHOULD FAIL IN 25,000 MILES AND STATED IT SHOULD LAST AT LEAST 60,000 MILES. THIS WILL BE THE THIRD INTAKE MANIFOLD GASKET THAT HAS BEEN PUT ON THIS VEHICLE. THE SERVICE SHOP WHO GAVE US THE ESTIMATE SAID THE GASKET IS FALLING APART LIKE PIECES OF AN EGGSHELL. THIS SHOULD BE RECALLED BECAUSE I HAVE FOUND MANY DOCUMENTED CASES OF THIS EXACT SAME PROBLEM WITH THE NISSAN ALTIMA. *TR

THE INTAKE MANIFOLD GASKET AROUND CYLINDER #4 FAILED 2-3 YEARS AGO (~65,000 MILES), CAUSING ROUGH IDLE/STALLING AS WELL AS POOR GAS MILEAGE AND TRIGGERING FAULT CODE P0304. THE DEALER REPLACED THE GASKET FOR ~$650. WITHIN THE PAST COUPLE OF WEEKS (~85,000 MILES), THE SYMPTOMS HAVE RETURNED, ACCOMPANIED BY THE SAME FAULT CODE. SPRAYING CARB CLEANER AROUND THE GASKET AREA CAUSE A SMOOTHING OUT OF THE IDLE WHEN APPLIED NEAR CYLINDER #4, INDICATING A RECURRING FAILURE OF THE GASKET. SEARCHING THE INTERNET INDICATES THAT THIS IS A VERY COMMON ISSUE PARTICULAR TO THIS ENGINE MODEL, LEADING TO RECURRING EXPENSE TO OWNERS DUE TO POOR ENGINEERING. THE MOST LIKELY CAUSE OF THIS FAILURE SEEMS TO BE THE ROUTING OF THE EGR GAS LINES TOO CLOSE TO THE INTAKE MANIFOLD, CAUSING PREMATURE DEGRADATION OF THE SEAL. A LIKELY, AND COST EFFECTIVE FIX WOULD SEEM TO BE THE ADDITION OF A HEAT SHIELD IN THE AFFECTED AREA BETWEEN THE EGR GAS LINES AND THE MANIFOLD. THE HIGH INCIDENCE RATE OF THIS FAILURE AND THE CAUSE OF POOR ENGINEERING, WOULD SEEM TO INDICATE A RECALL ISSUE TO FIX THE POOR FUEL ECONOMY AND EXCESSIVE EMISSIONS IT CAUSES. *TR

HAVE A 2000 NISSAN ALTIMA GLE THAT IS RUNNING POORLY AT IDLE AND WILL STALL. SPENT 450 DOLLARS ON TUNE UP PARTS TO FIND OUT LATER THAT IT IS THE MANIFOLD GASKET. WAS TOLD ALL NISSAN ALTIMAS ARE EXPERIENCING ISSUES OF SAME NATURE IN THE 1999-2000 MODEL AND THAT THEY ARE PREMATURELY FAILING AND THAT NISSAN IS AWARE OF PROBLEM AND IS REFUSING TO RECALL THE VEHICLES T FIX THEM. ESTIMATED REPAIR 800.00-1000.00 DOLLARS. *TR

TL*THE CONTACT OWNS A 2000 NISSAN ALTIMA. THE CONTACT STATED THAT THE INTAKE MANIFOLD GASKET WAS REPLACED ONCE. THE MECHANIC RECOMMENDED THAT THE PART BE REPLACED AGAIN BECAUSE IT CAN BECOME A DANGER AND CAUSE THE VEHICLE TO STALL. THE VEHICLE HAS EXPERIENCED RECENT FAILURES. THE CONTACT WILL NOT HAVE THE COMPONENT REPLACED AT THIS TIME. THE MANUFACTURER STATED THAT THEY WERE AWARE OF THE DEFECT, BUT COULD NOT OFFER ANY ASSISTANCE. THE CURRENT MILEAGE IS 57,900 AND FAILURE MILEAGE WAS 32,223. UPDATED 02/15/08. *LJ THE CONSUMER STATED THE PROBLEM HAS RESURFACED AGAIN, BUT IT HAS NOT BEEN FIXED.

ON 6/11/05 THE INTAKE MANIFOLD GASKET FAILED AS EVIDENCED BY THE CHECK ENGINE LIGHT TURNING ON AND DIAGNOSIS BY A NISSAN DEALERSHIP IN SOUTHERN CALIFORNIA. THE FAILURE HAD NO CONSEQUENCES AS I HAD THE GASKET REPLACED IMMEDIATELY; HOWEVER, THE PART IS NOT AVAILABLE. THE SAME EXACT PROBLEM HAS RESURFACED AS OF 12/27/07 AND NISSAN CORPORATION IS NOT WILLING TO HELP FIX THIS PROBLEM IN ANY SHAPE OR FORM. AT THIS POINT, I HAVE DECIDED TO NOT FIX THE PROBLEM AND KEEP DRIVING THE VEHICLE UNTIL THE CONDITION DETERIORATES MUCH FURTHER. FROM I AM TOLD THIS COULD CAUSE THE ENGINE TO STALL, WHICH IS A DEFINITE SAFETY ISSUE SINCE I CAN BE REAR ENDED IN THE EVENT IT DOES. *TR

TL*THE CONTACT OWNS A 2000 NISSAN ALTIMA. THE CONTACT STATED THAT SHE PURCHASED TWO SETS AND RECEIVED ONE FREE SET OF COOPER LIFELINER TOURING SLE TIRES IN APRIL OF 2004. THE VEHICLE HAS BEEN TO THE DEALER FOR REGULARLY SCHEDULED MAINTENANCE AND SHE DOES NOT KNOW WHY THE TREAD ON THE TIRES HAS WORN SO QUICKLY AND UNEVENLY. THE SECOND SET OF TIRES WAS REPLACED ON JUNE 12, 2006 AND THE THIRD SET WAS REPLACED ON JANUARY 2, 2007. THE SECOND SET OF TIRES, WHICH WERE RECEIVED FOR FREE, WAS REPLACED AT LESS THAN 30,000 MILES. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 130,300. EQ-10204089-4200 ,12/19/07. THE CONSUMER STATED PURCHASED 4 TIRES ON 12/08/04, 06/12/06, AND 12/18/06. UPDATED 12/12/07 *TR

I OWN A 2000 NISSAN ALTIMA GXE, AND HAVE BEEN EXPERIENCING A FAILURE IN THE SPEEDOMETER, TACH, ODOMETER, AND TEMP GAUGE WHILE DRIVING. THE GAUGES WILL FREEZE UP AT ANY TIME AND STAY AT THEIR LAST POSITION, WHILE THE CAR CONTINUES TO OPERATE AS NORMAL. THE CRUISE CONTROL WILL ALSO KICK OFF IF IT IS BEING USED AT THE TIME. THIS LEADS TO A VEHICLE THAT IS ONLY DRIVABLE BY USING THE NAKED EYE AND JUDGING YOUR SPEED BY OTHER CARS, AND A FAILURE IN CORRECT REPORTING OF MILEAGE. A SOLUTION IS STILL UNDER INVESTIGATION, AND A DEALER HAS NOT BEEN ABLE TO DIAGNOSIS IT YET. I HAVE SEEN MANY OTHER REPORTS OF THIS SAME PROBLEM ON SEVERAL MODELS OF NISSANS OF THIS YEAR (FRONTIER, SENTRA, PATHFINDERS) POSTED AT VARIOUS ONLINE CAR FORUMS. OBVIOUSLY THIS IS A DANGEROUS ISSUE THAT HAS BEEN OVERLOOKED BY NISSAN USA. *TR