Engine. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

3 crash reports0 fire reports1 injury reports

Power Train complaints

10 reports

Clear category filter

Mileage unknown · Oct 3, 2025

Power Train

Selector lever wrongly not locked in park. Put up a code for transmission (egs). I believe it falls under the transmission control unit recall on mini coopers 2 door hardtop.

NHTSA ODI #11691302

Mileage unknown · Sep 20, 2022

Fuel/propulsion SystemPower Train

Read full complaint

When refueling, nozzle kept shutting off, a gallon was pumped after nine attempts, also fuel erupted as the fill tube was filled with gas. reluctant to drive this car not knowing how much gas is in the tank. The needle shows less than 1/4 and miles remaining fluctuates between 80 and 110 miles. We are told that this problem exists in many mini automobiles, dealer has replacement gas tanks, but same problem exists Parking our Mini, indication of "roll back" is possible when car is parked. Shifter unit was replaced due to torsion spring.

NHTSA ODI #11485453

Mileage unknown · Aug 9, 2022

Power Train

On display I am getting warning " secure vehicle with parking brake when stationary" whereas my car is in park position with hand brake applied. The warning still shows up. The gearbox works fine the car drives fine. Its the warning that doesn't seem to go away. On diagnostics is shows code "420106" . DEFECTIVE GEAR SHIFT LEVER …

Read full complaint

NHTSA ODI #11478373

Mileage unknown · Jan 8, 2022

Power Train

Warning light to secure vehicle against rolling when placed in park. Alert of a danger situation.

NHTSA ODI #11446716

25,000 miles · Feb 2, 2021

Power Train

Read full complaint

TL* THE CONTACT OWNS A 2015 MINI COOPER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IN PARK, THE GEAR SHIFTER FAILED TO ENGAGE PROPERLY. SECURE GEAR ROLL- A-WAY WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE AND DETERMINED THAT THE GEAR BOX NEEDED TO BE REPLACED. MINI COOPER (8360 MIRAMAR PL STE A, SAN DIEGO, CA 92121, (858) 535-9999) WAS CONTACTED AND CONFIRMED THAT THE VIN WAS NOT UNDER RECALL. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 14V789000 (POWER TRAIN) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER HAD NOT BEEN NOTIFIED THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 25,000. THE VIN WAS NOT INCLUDED. ## VIN FAILED ## 2015 MINI COOPER ##

NHTSA ODI #11394256

37,499 miles · Jan 4, 2020

EnginePower Train

Read full complaint

12/19/19 I BROUGHT MY VEHICLE TO HAVE 2 FRONT TIRES REPLACED HAD THEM MOUNT AND BALANCED AND A FRONT ALIGNMENT DONE. THE DEALER ALSO COMPLETED MULTI POINT VEHICLE CHECK. I GET HOME. THE CAR SITS STILL SATURDAY. I START IT SATURDAY AT 1:30PM AND GET READY TO PULL OUT OF DRIVE WAY. WARNING LIGHT COMES ON DASH STATING BATTERY IS NOT CHARGING. STOP CAREFULLY. CONSULT NEAREST SERVICE CENTER. I CONTACTED SERVICE ADVISOR. HE STATED TO DRIVE IT BACK AND THEY WILL GIVE A LOANER. I SAID NO! THE VEHICLE ISN'T DRIVE ABLE AND I DON'T FEEL SAFE. HE STATED THEY CLOSE IN 30 MINUTES. I WANTED TO SPEAK TO UPPER MANAGEMENT. NO ONE WAS AVAILABLE HE STATED. I SAID I WOULD CALL BACK MONDAY DECEMBER23 2019. I SPOKE TO RECEPTIONIST WHO MAKES APPOINTMENTS. SHE HAD AVAILABLE SPOT ON THURSDAY DECEMBER26,2019. I TOLD HER I WILL HAVE IT TOWED THAT THURSDAY. I GET THERE TOLD THEM ABOUT THE MESSAGE THAT CAME ON DASH. I WAS GOING TO HAVE TO REPLACE BATTERY AND NEEDED A BRAKE FLUSH AND OH BY THE WAY LOOKS LIKE YOUR PULLEY WENT OUT. THE VEHICLE ONLY HAD 37,502 MILES. I HAVE NEVER HEARD OF A PULLEY BEING REPLACE AT THIS MILEAGE. I CONTACTED CUSTOMER RELATIONS FOR BMW MINI THAT FRIDAY. THEY SAID THEY WILL CONTACT IN 1 BUSINESS DAY. THEY DID SAY THERE IS AN OPEN CASE. THEY WILL CONTACT JAN 7. I WAS IN A LOANER FOR 6 DAYS. I SPOKE TO SERVICE MANAGER TUES 31,2019 WHICH WAS NEW YEAR'S EVE. SHE STATED THE DEALERSHIP WILL GIVE 20% DISCOUNT AND BMW MINI WILL STILL CONTACT ME IF THEY ARE GOING TO ASSIST. I MENTIONED TO THEM ABOUT THE DEFECTED PULLEYS ON 2002 THRU 2006 MODELS. THEY WILL LOOK INTO IT.

NHTSA ODI #11297064

34,500 miles · Mar 13, 2018

Power Train

Read full complaint

PREMATURE CLUTCH FAILURE 34,500 MILES, WHILE THE DEALER REPAIRED THE PROBLEM UNDER WARRANTY THEY INFORMED ME ABOUT THE CLUTCH BEING TOO SMALL TO DOWNSHIFT THE CAR TO SLOW DOWN. I DIDN'T SPEND NORTHWARDS OF 40K ON A SPORTS CAR ONLY TO BE TOLD ALL SLOWING DOWN SHOULD BE DONE WITH THE BRAKING SYSTEM. YOU BUY A STICK SHIFT CAR TO BE ABLE TO DO THESE THINGS NORMALLY. TO BE TOLD BY THE DEALERS SERVICE REPRESENTATIVE THE CLUTCH IS INADEQUATE FOR THIS NORMAL DRIVING PRACTICE WAS QUITE A SURPRISE HAD THE SALESPERSON TOLD ME THIS I WOULD NOT HAVE PURCHASED THE VEHICLE. I GUESS THE REAL SURPRISE WILL BE WHEN IT GOES OUT AGAIN AND I HAVE TO PAY TO HAVE A DESIGN FLAW REPAIRED AT MY OWN EXPENSE. THIS CLUTCH PROBLEM SEEMS TO BE PREVALENT IN THE ALL WHEEL DRIVE VERSION WHERE APPARENTLY THE FRICTION COEFFICIENT OF 4 WHEELS TO THE PAVEMENT EXCEEDS THAT OF THE CLUTCH.

NHTSA ODI #11079020

19,700 miles · Nov 15, 2017

Power Train

Read full complaint

WHILE IN BUMPER TO BUMPER TRAFFIC CAR LUNGED WHILE ACCELERATING. WAS AT A COMPLETE STOP THEN LIFTED OFF BRAKE AND BEGAN TO FEED IN GAS WHEN THE TRANSMISSION SHIFTED FROM FIRST TO SECOND (AUTOMATIC TRANSMISSION) THE CAR LUNGED OR JUMPED FORWARD. THE ACTION WAS SO SEVERE MY FIRST ACTION AFTER HITTING BRAKES WAS TO CHECK REAR VIEW MIRROR THINKING I HAD BEEN REAR ENDED. CAR HAS 19700 MILES AND WENT INTO OTTOS MINI FOR EVALUATION AND REPAIR OF OTHER ISSUES AND WAS TOLD TRANSMISSION IS IN NORMAL WORKING ORDER. HOWEVER MY SERVICE ADVISER TOLD ME THAT SHE PERSONALLY HAD EXPERIENCED THE SAME ISSUES AND THAT ITS DUE TO TOO MUCH TECHNOLOGY IN THE CARS.

NHTSA ODI #11046311

14,000 miles · Mar 14, 2017

Electrical SystemParking BrakePower TrainCrash

Read full complaint

TL* THE CONTACT OWNS A 2015 MINI COOPER. WHILE ATTEMPTING TO UNLOCK THE TRUNK WITH KEY FOB, THE TRUNK FAILED TO UNLOCK. THE CONTACT STARTED THE VEHICLE IN THE HOPE THAT IT WOULD UNLOCK THE TRUNK. WHEN THE CONTACT BEGAN TO WALK TOWARDS THE REAR OF THE VEHICLE, IT BEGAN TO ROLL DESPITE THE EMERGENCY BRAKE BEING ACTIVATED. THE VEHICLE CONTINUED TO ROLL OVER A LARGE CURB AND LANDED INTO THE FOUNDATION OF A NEIGHBORING HOME. THE VEHICLE RECEIVED DAMAGE TO THE REAR BUMPER AND UNDERCARRIAGE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE BACK HOME. THE CONTACT STATED THAT THE BRAKE AND DRIVE TRAIN WARNING INDICATORS WERE ILLUMINATED. THE CONTACT NOTIFIED THE INSURANCE COMPANY AND DEALER. THE DEALER WAS UNABLE TO IDENTIFY THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 14,000.

NHTSA ODI #10965860

Mileage unknown · Nov 13, 2015

Power TrainVehicle Speed Control

CPSC: MINI COOPER: CONSUMER STATED THE CRUISE CONTROL WOULD DISENGAGE. *SS THE CONSUMER STATED DISCOVERED WHEN USING THE CLUTCH AND DOWN SHIFTING THE CRUISE CONTROL DID NOT DISENGAGE. THE FIRST TIME HE TRIED THE CRUISE CONTROL, WHILE DOWN SHIFTING THE VEHICLE MAINTAINED SPEED AND SHOT FORWARD INSTEAD OF SLOWING DOWN. *JB

NHTSA ODI #10807019

Official recalls

15V739000 · Air Bags:sensor:occupant Classification; Seats

Nov 9, 2015

BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper Hardtop 2 door vehicles manufactured February 25, 2014, to May 16, 2015, 2014-2015 MINI Cooper S Hardtop 2 door vehicles manufactured March 28, 2014, to May 9, 2015, 2015 MINI Cooper Hardtop 4 door vehicles manufactured October 17, 2014, to June 2, 2015, and 2015 MINI Cooper S Hardtop 4 door vehicles manufactured November 24, 2014, to June 11, 2015. During a service appointment, the affected vehicles received replacement front passenger seat cushions (which contain integral Capacitive Interior Sensing (CIS) functions). The CIS functions may have been incorrectly calibrated, and if so, would cause impaired occupant classification and thus inappropriate air bag activation/deactivation.

Consequence & remedy

Consequence: Inappropriate air bag activation/deactivation can increase the risk of occupant injury in the event of a vehicle crash.

Remedy: MINI will notify owners, and dealers will inspect and, if necessary, replace the front passenger seat cushion, free of charge. The recall began on December 28, 2015. Owners may contact MINI customer service at 1-866-825-1525 .

Additional source detail variants (2)

Seats

Consequence: Inappropriate air bag activation/deactivation can increase the risk of occupant injury in the event of a vehicle crash.

Remedy: MINI will notify owners, and dealers will inspect and, if necessary, replace the front passenger seat cushion, free of charge. The recall began on December 28, 2015. Owners may contact MINI customer service at 1-866-825-1525 .

Air Bags:sensor:occupant Classification

Consequence: Inappropriate air bag activation/deactivation can increase the risk of occupant injury in the event of a vehicle crash.

15V628000 · Air Bags:frontal:passenger Side:inflator Module

Oct 7, 2015

BMW of North America, LLC (BMW) is recalling certain model year 2014-2016 MINI Cooper S and MINI Cooper two-door vehicles, 2015-2016 MINI John Cooper Works and MINI Cooper S and MINI Cooper four-door vehicles and 2014-2015 BMW i3 vehicles. Due to a manufacturing error, the passenger frontal air bag may not deploy properly in a low speed crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: In the event of a vehicle crash, an air bag that does not deploy properly increases the risk of injury to the front seat passenger.

Remedy: MINI and BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began on November 25, 2015. Owners may contact MINI customer service at 1-866-825-1525 and BMW customer service at 1-800-525-7417.

15V450000 · Structure:body

Jul 17, 2015

BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper and MINI Cooper S Hardtop 2 Door vehicles and 2015 MINI John Cooper Works Hardtop 2 Door vehicles. The affected vehicles do not meet the side impact performance requirements for the rear seat passengers. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 214, "Side Impact Protection."

Consequence & remedy

Consequence: If the side impact performance requirements are not met, rear seat passengers may be at a higher risk of injury during a crash.

Remedy: MINI will notify owners, and dealers will install additional energy absorption material between the rear interior side panels and the exterior vehicle body, free of charge. The recall began on September 4, 2015. Owners may contact MINI customer service at 1-866-825-1525. Note: this recall supersedes 14V-815.

15V034000 · Equipment:other:labels

Jan 26, 2015

BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper Hardtop two door vehicles manufactured December 1, 2013, to December 14, 2014. The affected vehicles may have been manufactured with an incorrect maximum capacity weight stated on the Tire Information Placard. Thus, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) No. 110, "Tire Selection and Rims and Motor Home/Recreation Vehicle Trailer Load Carrying Capacity Information for Motor Vehicles with a GVWR of 4,536 kilograms (10,000 pounds) or less."

Consequence & remedy

Consequence: The maximum weight listed on the label is incorrect (too low) and therefore does not comply with Federal Regulations.

Remedy: MINI will notify owners, and dealers will replace the incorrect labels with corrected labels, free of charge. Owners were mailed interim notification on March 18, 2015. The recall began on October 15, 2015. Owners may contact MINI customer service at 1-866-825-1525.

14V789000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Dec 15, 2014

BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper Hardtop 2 Door, and Cooper S Hardtop 2 Door vehicles manufactured January 6, 2014, to October 17, 2014. During service appointments, dealers may have inadvertently reprogrammed the transmission control unit with software that may allow drivers to exit the vehicle when the transmission is not in Park. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 114, "Theft Protection and Rollaway Prevention."

Consequence & remedy

Consequence: If the driver exits the vehicle without the transmission being in Park, the vehicle could roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Remedy: MINI will notify owners, and dealers will reprogram the transmission control module with the correct software, free of charge. The recall February 4, 2015. Owners can contact MINI customer service at 1-866-825-1525.

14V721000 · Seats

Nov 10, 2014

BMW of North America, LLC (BMW) is recalling certain model year 2015 MINI Cooper Hardtop 2 Door vehicles manufactured August 12, 2014, to September 2, 2014. In the affected vehicles, the driver and front passenger seatback adjustment mechanism may not be fully engaged.

Consequence & remedy

Consequence: If the seatback adjustment mechanism is not fully engaged, the seatback may fold during a rear impact collision, increasing the risk of injury to the seat occupant.

Remedy: MINI will notify owners, and dealers will re-align and re-tighten the seatback adjustment mechanisms, free of charge. The recall began December 29, 2014. Owners can contact MINI customer service at 1-866-825-1525.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ15004 · BMW Safety Act Violations

Opened Sep 24, 2015 · Closed Oct 2, 2017

Status: closed (inferred from source dates) · Structure

In a Consent Order executed on December 17, 2015, BMW of North America, LLC (BMW NA) admitted that it violated the Safety Act by: failing to conduct a timely recall for Recall No. 15V-450; failing to file certain quarterly recall reports in a timely manner; failing to timely notify vehicle owners of the existence of a defect or noncompliance; failing to promptly advise NHTSA of delays with the beginning or completion dates for mailing owner or dealer notifications; and failing to timely submit copies to NHTSA of communications relating to recalls.As part of the Consent Order, NHTSA imposed a total civil penalty of $40 million against BMW NA for its violations of the Safety Act.The civil penalty consists of a cash payment, monetary performance obligations, and stipulated penalties.BMW NA paid the $10 million cash penalty on February 12, 2016.Failure to comply with the terms of the Consent Order or the Safety Act will result in portions of the stipulated penalties coming due.The Consent Order required BMW NA to appoint an independent safety consultant to assist BMW NA in developing best practices for complying with the Safety Act and evaluating safety issues under consideration by BMW NA.BMW NA was also required to develop a program to train dealers on the importance of complying with the prohibition on selling unremedied vehicles under recall, improve dealers' access to information necessary to maximize completion of open recalls, and invest in a pilot program to determine whether BMW NA can use data analytics to detect emerging safety defect trends.The population listed in this closing resume is based on BMW NA's untimely recall and does not include other issues addressed by the Consent Order, which relate to BMW NA's safety processes.Based on the Consent Order, BMW NA's admissions that it violated the law, and its ongoing performance obligations, this audit query investigation, AQ15-004, is closed. Closure of this AQ has no bearing on the terms of the Consent Order, including BMW NA's ongoing performance obligations or legal obligations, and does not represent a determination by NHTSA as to BMW NA's performance under the Consent Order to date.

AQ15003 · International Autos, Inc. / Mini Recall

Opened Aug 18, 2015 · Closed Aug 23, 2016

Status: closed (inferred from source dates) · Equipment:other:labels

The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell and deliver a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ?? 30112(a), 30120(i)).NHTSA opened AQ15-003 to determine whether International Autos, Inc. of West Allis, Wisconsin complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C. Chapter 301 (Safety Act). NHTSA received information that International Autos sold and delivered at least one new model year (MY) 2015 Mini Cooper 2-door hardtop vehicle to a customer without having had all required safety recall repairs performed on that vehicle. NHTSA opened this investigation and then issued an information request (IR) to International Autos on August 20, 2015.A copy is of this request is in this investigation's file, together with a public copy of International Autos' response.A careful review of the information supplied confirm that International Autos sold and delivered at least eleven new vehicles with outstanding safety recalls on them. Under a Settlement Agreement dated April 26, 2016, International Autos committed to take concrete actions to improve its processes for verifying that prior to sale and delivery of any new vehicle International Autos has confirmed that the vehicle is not subject to an un-remedied recall. International Autos confirmed that it had engaged in these processes since June 25, 2015.International Autos also committed that it now also checks for open recalls on every customer vehicle brought in for service, and that it checks for open recalls on every used trade-in vehicle, regardless of make or model, and takes steps to have all used trade-in vehicles repaired prior to retail sale. International Autos admitted to violating the prohibition on sales of new vehicles with open recalls, and agreed to pay civil penalties in the amount of $40,000.This Audit Query is closed.