2011 Mini Cooper

Dear NHTSA, I am writing to express my concerns about the safety of the 2011 Mini Cooper, specifically regarding the Car Access System (CAS) module. There is a widespread issue with the CAS module failing, which can result in the vehicle not starting or even stalling while driving. This poses a serious safety risk to drivers and passengers, as a sudden stall or loss of power can lead to accidents, injuries, or death. Furthermore, there is currently a backorder of the part, and it is not clear if there are any parts available which do not have this single point of failure. This means that even if a vehicle owner experiences this issue, there is no clear resolution to the problem, and the vehicle remains unsafe to drive. This has been diagnosed by an automotive repair shop, and I have discussed this issue with the Mini Cooper dealer, Mini Cooper/BMW manufacturing, BMW/Mini Assistance, and the auto repair shop. Both the dealer and the auto shop have both reported over a dozen cars with the same issue that have all been rendered non-functional. Average time to allegedly fix the problem is anywhere between 4 months and 1 year, but there does not seem to be resolution. The Mini Cooper dealer said there likely will be a recall at some point, but given the company’s history of failing to address safety issues such as these and issuing recalls in a timely manner, we have taken reporting this issue into our own hands. I believe that this issue warrants an investigation by the NHTSA and that a recall may be necessary to ensure the safety of drivers and passengers of the 2011 Mini Cooper. I urge you to take action on this matter and investigate this issue further. Thank you for your attention to this matter. Sincerely, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2011 Mini Cooper. The contact stated while starting the vehicle, the air bag warning light illuminated. The vehicle was taken to the dealer and the dealer stated that the air bag mat sensor on the passenger’s side needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted or notified of the failure. The approximate failure mileage was 148,000.

The passenger seat occupancy detection module and program failed. The red airbag and seatbelt lights went on. According to the dealership, the default setting is that the airbag will not go off if the module is broken. A Google search suggests that this is a common problem; so much so that there is an electronic gadget you can buy and videos on YouTube on how to install it to do a "workaround" to get the light to go off without fixing the module.

Car shows signs of passenger seat occupancy sensor recall. Mini acknowledges the recall has not been performed. Mini expanded recall to 10 years from date of service but because previous owner didn't get recall done I cannot. This is a known issue with these cars and should not have an expiration date! Dealer I purchased car from used says that because recall isn't listed here then they aren't liable to fix it...

I had several repairs recently that I found that were part of a recall after the fact. This includes the Electric Auxilillary Water Pump and Timing Chair replacement and repair of damaged parts. They refused to reimburse me for the water pump repair that should have been covered. Secondly, when the timing chain fails as it did in my case can cause $2000- $5000+ in damages. My shop is stating this would be a very expensive repair. There is information that the timing chain warranty was extended because of a class action lawsuit and is now covered up to 100,000 miles. I am well within that range. My goal is to get compensation for the recall work and coverage for the timing chain.

During driving failure of the shift cable linkage was disconnected When investigated, the joint between the cable and the transmission shifter was disconnected due to a failure of the bushing on the cable side This caused a situation where the car was stuck in a single gear and not possible to be shifted into neutral or another gear

The lighting and small system computer or FRM module. This module controls any features including safety features on the car. Also known as the footwell module. After having AAA install a new battery within days the widows would not go down my turn signals, hazard lights, dash lights, courtesy lights, tail lights, horn, high beam headlights and possibly airbags don’t work. Mini will fix the problem if the car is ten years old or less, but any car that is older doesn’t qualify. Mini goes by Manufacturing date of the car. My but It was not sold into service until 2011. They refuse to fix it and the repair cost was $1828.24. I have had other problems as well. Mini needs to acknowledge this problem issue a recall and refund those of us that have been victimized by not making this a recall issue. Mini must be confronted by NHTSA put on notice, considering these are major safety issues that could result in injury or death. Part number= FP 61-35-6-827-072

The lighting and small system computer or FRM module. This module controls any features including safety features on the car. My turn signals, hazard lights, dash lights, courtesy lights, tail lights, windows, horn, high beam headlights and possibly airbags don’t work. Mini will fix the problem if the car is ten years old or less, but any car that is older doesn’t qualify. My car is a 2011 but I bought it new in 2012. They refuse to fix it and the repair cost is around $2000. I have had so many other problems with my car that have cost me several thousands of dollars and I feel like Mini should fix this problem considering these are safety features that could result in injury or death.