2009 Mini Cooper Clubman

Following approximately 12 months of slow deterioration, the passenger-side airbag deployment system in this vehicle appears to have become continuously inoperative (red airbag failure annunciator continuously illuminated on instrument cluster in conjunction with continuous illumination of the amber "Passenger Airbag OFF" informational annunciator in the overhead console). Failure now occurs whether passenger seat is empty or occupied, although it previously only occurred when the seat was unoccupied and ambient temperatures were colder (below approximately 40 degrees F). I suspect that the passenger seat occupancy sensor mat is the failed system component due to the slow onset of the problem (continuous illumination of aforementioned annunciators was spurious at first, then intermittent, now continuous). Vehicle has not been submitted to a MINI dealer for diagnosis. However, MINI/BMW has already issued a recall on the passenger seat occupancy sensor mats in 2005-2008 model MINIs, setting the precedent that other model years could be similarly affected as well. Vehicle will not pass Texas state inspection with the airbag failure annunciator illuminated, and therefore cannot be registered. Recommend that MINI/BMW expand the sensor mat recall to include at least their 2009 model year vehicles as well.

THE PASSENGER SIDE AIRBAG SENSOR HAS BEEN GOING OFF INDICATING THAT THE AIRBAG WILL NOT DEPLOY EVEN WHEN SOMEONE OF NORMAL ADULT SIZE (160LBS) IS IN THE FRONT PASSENGER SEAT. I HAVE CONTACTED MINI AND THEY REFUSE TO FIX IT UNLESS I PAY FOR THE COSTLY REPAIR, EVEN THOUGH THEY HAVE BEEN SLOWLY RECALLING OTHER MODELS FOR THE SAME PROBLEM. THE IMPROPERLY FUNCTIONING MAT IN MY MINI COOPER CLUBMAN MAY CAUSE THE PASSENGER FRONTAL AIR BAG TO BE INACTIVE WHEN THE SEAT IS OCCUPIED, AND IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT DEPLOY, INCREASING THE PASSENGER'S RISK OF INJURY. THIS IS CLEARLY DUE TO A DESIGN, MANUFACTURING, INSTALLATION, AND/OR EXPOSURE ISSUES, THAT CAUSES THE FRONT PASSENGER SEAT OCCUPANT DETECTION MAT NOT TO FUNCTION PROPERLY AND, AS A RESULT, THE FRONT PASSENGER AIR BAG MAY NOT DEPLOY IN A CRASH. THIS NEEDS TO BE RESOLVED AND NOT WAIT UNTIL MORE PEOPLE ARE HURT BY BMW'S REFUSAL TO ADDRESS THE PROBLEM IN ALL VEHICLES THAT HAVE THIS PROBLEM. THEY ARE WAITING FOR MORE DEATHS, INJURIES AND/OR COMPLAINTS BEFORE THEY FINALLY RESOLVE THEIR PROBLEM AT THEIR COST IN ALL CARS. WHAT CHANGE HAVE THEY EMPLOYED AFTER 2008 TO THIS DESIGN, MANUFACTURING AND INSTALLATION PROCESS IN THEIR PASSENGER SIDE AIRBAG SENSORS THAT MAKES THEM ISOLATE ONLY SOME REPAIRS ON SOME MINIS? NONE! AT LEAST NONE THAT HAVE WORKED AS I HAVE A 2009 MINI COPPER CLUBMAN WITH THE IDENTICAL PROBLEM, SO CLEARLY THEY HAVEN'T RESOLVED IT AND SHOULD NOT LIMIT THEIR RECALL TO 2005-2006 MINI COOPERS AND COOPER S, NOR JUST CONVERTIBLE MINI COOPERS BETWEEN 2005-2008 MODELS. 2009 MINI COOPER CLUBMANS HAVE THIS SAME PROBLEM, YET BMW TELLS ITS CUTOMERS WITH WARRANTIES TO PAY FOR IT THEMSELVES! BAD BUSINESS. HOPE SOMEONE SUES THEM, BUT PROBABLY NOT UNTIL SOMEONE DIES. AT LEAST THIS PUTS THEM ON NOTICE SO THEY CAN BE SUED MORE EASILY. I HAVE CHILDREN...SHAME ON YOU BMW!