NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
17 reportsClear category filter85,591 miles · Sep 4, 2008
SteeringStructureSuspension
TL*THE CONTACT OWNS A 1992 MERCURY SABLE. WHEN THE CONTACT TOOK HIS VEHICLE TO A LOCAL MECHANIC, CORROSION WAS DISCOVERED IN THE STEERING COLUMN. HE ALSO DISCOVERED THAT HE WAS EXPERIENCING THE SAME FAILURE LISTED IN NHTSA CAMPAIGN ID NUMBER 98V323000 (STRUCTURE:FRAME AND MEMBERS). THE MANUFACTURER WAS UNABLE TO PROVIDE ASSIS…
Read full complaint
TL*THE CONTACT OWNS A 1992 MERCURY SABLE. WHEN THE CONTACT TOOK HIS VEHICLE TO A LOCAL MECHANIC, CORROSION WAS DISCOVERED IN THE STEERING COLUMN. HE ALSO DISCOVERED THAT HE WAS EXPERIENCING THE SAME FAILURE LISTED IN NHTSA CAMPAIGN ID NUMBER 98V323000 (STRUCTURE:FRAME AND MEMBERS). THE MANUFACTURER WAS UNABLE TO PROVIDE ASSISTANCE; HOWEVER, THEY STATED THAT BECAUSE IT HAD EXCEEDED TEN YEARS, THE PARTS WERE UNAVAILABLE. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 85,591. UPDATED 10/16/08. *LJ THE VEHICLE WOULD PULL TO THE SIDE. UPDATED 10/17/08. *JB
NHTSA ODI #10240898
100,000 miles · Oct 4, 2007
Suspension
TL*THE CONTACT OWNS A 1992 MERCURY SABLE. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT HEARD A LOUD THUMPING NOISE. APPROXIMATELY THIRTY SECONDS LATER, THE VEHICLE SHUT OFF. HE PUSHED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED THAT THE FRONT FRAME FAILED. TWO DAYS LATER, THE VEHICLE WAS TOWED TO AAA. A LOCAL MECHANI…
Read full complaint
TL*THE CONTACT OWNS A 1992 MERCURY SABLE. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT HEARD A LOUD THUMPING NOISE. APPROXIMATELY THIRTY SECONDS LATER, THE VEHICLE SHUT OFF. HE PUSHED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED THAT THE FRONT FRAME FAILED. TWO DAYS LATER, THE VEHICLE WAS TOWED TO AAA. A LOCAL MECHANIC ARRIVED A WEEK LATER AND STATED THAT THERE WAS WEAR AND TEAR ON THE FRONT FRAME BUSHING SWAY BAR, WHICH CAUSED THE FRONT FRAME TO FAIL. HE NOTIFIED THE MANUFACTURER AND THEY STATED THAT THERE WAS A RECALL FOR THE REAR FRAME, BUT NOT THE FRONT. THE MANUFACTURER WOULD NOT PROVIDE ANY FINANCIAL ASSISTANCE WITH THE REPAIRS AND STATED THAT THE VEHICLE WAS NOT WORTH REPAIRING. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 100,000. UPDATED 11/06/07 *TR
NHTSA ODI #10204862
Mileage unknown · Oct 24, 2002
Suspension
BOTH COIL SPRINGS FAILED DUE TO CORROSION. PIECES OF SPRING ALMOST FELL OUT AND CONTACTED TIRE. COULD HAVE RESULTED IN PUNCTURE AT HIGH SPEED. DT
NHTSA ODI #768804
Mileage unknown · Jan 6, 2001
Electrical SystemEngine And Engine CoolingSuspension
FORD MOTOR CO. SHOULD RECALL THIS VEHICLE. NO SAFETY DEFECT MENTIONE DIN SUMMARY. *AK
NHTSA ODI #738884
Mileage unknown · Jun 9, 2000
SteeringSuspension
THE PROBLEM IS THAT THE SPEED SENSITIVE STEERING "OSCILATES" BETWEEN LOW-EFFORT & HIGH-EFFORT WHEN DRIVING THROUGH A CURVE. MAKES VEHICLE TRICKY TO CONTROL. ALSO EXHIBITS INTERMITTENT PULLING TO EITHER SIDE THAT HAS NOT BEEN ELIMINATED BY THOROUGH FRONT-END MAINTENANCE. OTHERS WITH LIKE VEHICLES REPORT SAME PROBLEMS.
NHTSA ODI #723784
Mileage unknown · Feb 7, 2000
SteeringSuspension
WHEN TURNING CAR TO THE LEFT OR RIGHT THERE IS A GRINDING NOISE PRESENT. VEHICLE DOES NOT FULLY TURN ALSO, DEALER HAS SEEN VEHICLE, AND SAID STEERING RACK WAS SENDING FLUID INTO THE POWER STEERING PUMP. *AK
NHTSA ODI #856406
Mileage unknown · Apr 30, 1999
Suspension
1. WHILE DRIVING AT 30 MPH AND GETTING READY TO MAKE A RIGHT TURN THE SWAY BAR BROKE DUE TO BOLTS BEING RUSTY, AND THERE IS NOISE COMING FORM THE VEHICLE. 2. ATTEMPTING TO AKE LEFT TURN ONTO HIGHWAY SWAY BAR BROKE. DRIVE RWAS AT COMPLETE STOP PRIOR TO MAKING TURN. IN BOTH CASE, BOLTS AND SCREWS WERE RUSTED/BROKE. *AK
NHTSA ODI #836345
Mileage unknown · Apr 27, 1999
Exterior LightingService Brakes, HydraulicSteering
BRAKES HAVE CONTINUALLY EXPERIENCED PROBLEMS WITH NOISE AND VIBRATION, REPLACEMENT OF ROTORS AND PADS ON NUMEROUS OCCASIONS, HOWEVER CONTINUE TO FAIL. MJS
NHTSA ODI #545222
Mileage unknown · Apr 12, 1999
Suspension
WHEN DRIVING IN LOW SPEED THERE IS A STRAINING NOISE COMING FROM THE VEHICLE. ALSO, WHEN MAKING A TURN THERE IS SOME KNOCKING NOISE COMING FROM THE VEHICLE. *AK
NHTSA ODI #835549
Mileage unknown · Apr 7, 1999
Suspension
RECALL CAMPAIGN 94E036000. DRIVER'S FRONT LEFT SPRING BROKE AND VEHICLE TOWED TO MECHANIC. REPLACED TWO FRONT SPRINGS AND TWO STRUTS. ALSO NEEDED SWAY BAR BRACKET AND REAR STRUTS. DEALER NOT AWARE OF THE PROBLEM. *AK
NHTSA ODI #834459
Official recalls
4Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
May 11, 1992
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence & remedy
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
11EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE93065 · Underbody Fuel Line Fails
Opened Jul 15, 1993 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
Illustration