Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 221 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 101 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports9 fire reports5 injury reports
What owners actually said
221 reports
57,000 miles · Jul 11, 2008
Structure
I HIT A SMALL POTHOLE AND THE STEERING WHEEL SUDDENLY MOVED TO A ONE O'CLOCK POSITION WHILE THE WHEELS WERE POINTING STRAIGHT AHEAD. MY ALIGNMENT SHOP INSPECTED THE CAR AND FOUND THAT THE CAUSE WAS A FAILURE OF THE PASSENGER SIDE SUB-FRAME MOUNTING BOLT ANCHOR. THE LOCAL DEALER SAID MY CAR IS NOT INCLUDED IN THE RECALL (98S3…
Read full complaint
I HIT A SMALL POTHOLE AND THE STEERING WHEEL SUDDENLY MOVED TO A ONE O'CLOCK POSITION WHILE THE WHEELS WERE POINTING STRAIGHT AHEAD. MY ALIGNMENT SHOP INSPECTED THE CAR AND FOUND THAT THE CAUSE WAS A FAILURE OF THE PASSENGER SIDE SUB-FRAME MOUNTING BOLT ANCHOR. THE LOCAL DEALER SAID MY CAR IS NOT INCLUDED IN THE RECALL (98S36) I DEMAND AN ANSWER AS WHY MY CAR IS NOT INCLUDED. *TR
NHTSA ODI #10233972
80,000 miles · Sep 6, 2006
Vehicle Speed Control
DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON NORMAL ROAD CONDITIONS, THERE WAS A NOTICEABLE DELAY TO DISENGAGED THE SPEED CONTROL. THE BRAKE PEDAL HAD TO BE PUMPED SEVERAL TIMES UNTIL THE DRIVER REGAINED CONTROL OVER THE VEHICLE'S SPEED. THE CONTACT RECEIVED A RECALL LETTER # 97V025000 BUT MISPLACED IT. THE MANUFACTURER …
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON NORMAL ROAD CONDITIONS, THERE WAS A NOTICEABLE DELAY TO DISENGAGED THE SPEED CONTROL. THE BRAKE PEDAL HAD TO BE PUMPED SEVERAL TIMES UNTIL THE DRIVER REGAINED CONTROL OVER THE VEHICLE'S SPEED. THE CONTACT RECEIVED A RECALL LETTER # 97V025000 BUT MISPLACED IT. THE MANUFACTURER WAS CONTACTED WHO REFUSED TO PRODUCE A NEW LETTER BECAUSE THE RECALL WAS TOO OLD. THE CONTACT EXPRESSED CONCERN BECAUSE THE SPEED CONTROL MALFUNCTIONING ENTAILED A SERIOUS SAFETY RISK.
NHTSA ODI #10167502
100,000 miles · Apr 6, 2004
Exterior Lighting
WHILE DRIVING AT NIGHT THE VEHICLE'S HEADLIGHTS FAILED WITHOUT WARNING. THE DEALER STATES THE HEAD LAMP SENSOR SWITCH BURNED. A RECALL WAS ISSUED, HOWEVER THE VIN NUMBER IS OUTSIDE OF THE REMEDY SCOPE. *MR
NHTSA ODI #10066634
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingFuel System, GasolinePower Train
OTHER THAN THE REST OF MY PROBLEMS WITH THE ABOVE MY NEWEST COMPLAINT IS THAT I JUST FOUND OUT THAT DUE TO THE FACT FORD INSTALLED AN ALUMINIM PISTON WHERE THERE SHOULD HAVE BEEN A STEEL ONE WHICH IS THE ONLY ONE AVAILABLE NOW SINCE YOU DISCOVERED YOUR PROBLEMS. MY CAR IS IN THE SHOP RIGHT NOW AND I'M BEING TOLD IT WILL COST BE…
Read full complaint
OTHER THAN THE REST OF MY PROBLEMS WITH THE ABOVE MY NEWEST COMPLAINT IS THAT I JUST FOUND OUT THAT DUE TO THE FACT FORD INSTALLED AN ALUMINIM PISTON WHERE THERE SHOULD HAVE BEEN A STEEL ONE WHICH IS THE ONLY ONE AVAILABLE NOW SINCE YOU DISCOVERED YOUR PROBLEMS. MY CAR IS IN THE SHOP RIGHT NOW AND I'M BEING TOLD IT WILL COST BETWEEN $1200.00 - $1500.00 TO FIX DUE TO FORD'S POOR DESIGN. THIS IS NOT MY FIRST SABLE WAGON. THE FIRST ONE HAD ALL KINDS OF A/C PROBLEMS AND I'M GETTING TIRED OF PAYING FOR YOUR MISTAKES. MY A/C IS OUT NOW, I REPLACE BRAKE PADS ALL THE TIME.
NHTSA ODI #10070144
130,000 miles · Jul 17, 2003
Structure
NORTHPORT FORD IN COMMACK, NY FAILED TO PROPERLY PERFORM SAFETY RECALL 98S36 FOR THE SUBFRAME ON MY 1991 MERCURY SABLE. THE SUBFRAME SUBSEQUENTLY BROKE FREE CAUSING DAMAGE TO MY MOTOR MOUNTS, TRANSMISSION AND STEERING COMPONENTS. THE VEHICLE WAS TOWED TO THE CLOSEST FORD DEALER IN PATCHOGUE NY. FORD AGREED TO REINSTATE THE RECAL…
Read full complaint
NORTHPORT FORD IN COMMACK, NY FAILED TO PROPERLY PERFORM SAFETY RECALL 98S36 FOR THE SUBFRAME ON MY 1991 MERCURY SABLE. THE SUBFRAME SUBSEQUENTLY BROKE FREE CAUSING DAMAGE TO MY MOTOR MOUNTS, TRANSMISSION AND STEERING COMPONENTS. THE VEHICLE WAS TOWED TO THE CLOSEST FORD DEALER IN PATCHOGUE NY. FORD AGREED TO REINSTATE THE RECALL FOR THE DEALER TO REPAIR MY VEHICLE. THE DEALER CALLED FORD WITH THE PRICE OF THE SUBSEQUENT DAMAGE AND FORD WITHDREW THE OFFER TO REPAIR. THEY WANTED TO BUY THE VEHICLE BACK AT A PRICE THEY DECIDED ON. I AM ON DISABILITY WITH A WORK RELATED ACCIDENT. I CAN NOT AFFORD TO BE WITHOUT MY VEHICLE. I CAN NOT AFFORD TO BUY ANOTHER VEHICLE AT THE BUYOUT PRICE FORD WANTS TO GIVE ME. I FEEL THAT THIS ACCURED DUE TO A SAFETY RECALL THAT WAS NOT PERFORMED PROPERLY AND FORD SHOULD DEAL WITH THAT DEALERSHIP AND FIX MY VEHICLE AT NO CHARGE.*AK
NHTSA ODI #10028532
Mileage unknown · Jul 2, 2003
SteeringSuspension
CONSUMER STATES THAT THE VEHICLE BUSHINGS ARE MADE OF A VIBER MATERIAL THAT WEARS OUT, CAUSING THE VEHICLE TO STEER IMPROPERLY. *AK
NHTSA ODI #10026456
Mileage unknown · May 19, 2003
Steering
THE STEERING WHEEL LOCKED UP WHEN THE CONSUMER MADE LEFT TURNS. *NLM
NHTSA ODI #10020062
Mileage unknown · May 16, 2003
Structure
THE LEFT REAR SUB-FRAME MOUNT BROKE. THE RIGHT REAR SUB-FRAME MOUNT LOOKED LIKE IT WAS ABOUT TO BREAK. *NLM
NHTSA ODI #10020010
Mileage unknown · May 13, 2003
Structure
THE CONSUMER VEHICLE EXPERIENCED SYMPTOMS OF NHTSA RECALL # 98-V-323-000 WHICH WAS RELATED TO THE REAR LOWER SUBFRAME MOUNT PLATE NUT. THE CONSUMER VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *NLM
NHTSA ODI #10019777
Mileage unknown · Nov 20, 2002
Suspension
PLNHTS#6954-94-E-036-000: SWAY BAR BRACKET WHERE IT ATTACHES TO THE STRUT RESERVE TUBE DID NOT FUSE PROPERTY. CONSUMER STATES HAS THE SAME PROBLEM (MAKING SOME NOISE). DEALER HAS BEEN NOTIFED. PLEASE PROVIDE FURTHER INFORMATION. TS
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence & remedy
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.
Consequence & remedy
Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.
Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
11
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93070 · Failure Of Wheel Studs
Opened Jul 27, 1993 · Closed Nov 22, 1993
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93065 · Underbody Fuel Line Fails
Opened Jul 15, 1993 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
EA91042 · Storage Compar Suffocation
Opened Oct 28, 1991 · Closed May 21, 1992
Status: closed (inferred from source dates) · Structure
===
PE91108 · Storage Compar Suffocation
Opened Aug 1, 1991 · Closed Oct 28, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available
1991 Mercury Sable Problems, Complaints & Recalls | Skip That Year
Illustration