NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
40 reportsClear category filter180,000 miles · Nov 14, 2005
Service Brakes, HydraulicCrash
DT: THE CONTACT STATED WHILE DRIVING AT NIGHT THE CONSUMER STRUCK A DEER AND EXPERIENCED DIFFICULTY STOPPING WITH THE BRAKES. THERE WAS DAMAGE TO THE FRONT HOOD AND HEADLIGHTS. NO POLICE REPORT WAS TAKEN. HE DROVE THE VEHICLE HOME. UPON INSPECTION THERE WAS CORROSION ON BRAKE LINES. HE SUSPECTED THIS WAS DUE TO DISSIMILAR M…
Read full complaint
DT: THE CONTACT STATED WHILE DRIVING AT NIGHT THE CONSUMER STRUCK A DEER AND EXPERIENCED DIFFICULTY STOPPING WITH THE BRAKES. THERE WAS DAMAGE TO THE FRONT HOOD AND HEADLIGHTS. NO POLICE REPORT WAS TAKEN. HE DROVE THE VEHICLE HOME. UPON INSPECTION THERE WAS CORROSION ON BRAKE LINES. HE SUSPECTED THIS WAS DUE TO DISSIMILAR METAL CORROSION AND ROAD SALTS. THE VEHICLE HAS NOT BEEN REPAIRED AT THIS TIME. *AK UPDATED 12/27/05. *JB THE BRAKE LINE BURST.
NHTSA ODI #10142623
114,000 miles · Nov 18, 2003
Service Brakes, Hydraulic
WHEN BRAKING HARD, THE PEDAL WENT TO THE FLOOR RESULTING IN LOSS OF BRAKES. I HAD TO USE THE E-BRAKE AND PUMP THE REGULAR PEDAL TO STOP. BRAKE FLUID WAS LEAKING FROM LINE LOCATED IN ENGINE COMPARTMENT NEXT TO DRIVER SIDE FRONT WHEEL WELL. *LA
NHTSA ODI #10047094
Mileage unknown · Sep 2, 2000
Fuel System, GasolineService Brakes, Hydraulic
I HAVE HAD NUMEROUS ONGOING PROBLEMS WITH THIS CAR. THE CHECK ENGINE LITE STILL COMES ON INTERMITTENLY FOR NO OBVIOUS REASON AND I HAVE REPLACED THE CARS WHOLE PROCESSOR AND STILL HAVE PROBLEMS. NOW I HAVE A GRINDING NOISE AND A VIBRATION WHEN I GO TO APPLY MY BRAKES. PUT NEW BRAKE SHOES ON 1 WEEK AGO AND ROTORS WERE IN GOOD …
Read full complaint
I HAVE HAD NUMEROUS ONGOING PROBLEMS WITH THIS CAR. THE CHECK ENGINE LITE STILL COMES ON INTERMITTENLY FOR NO OBVIOUS REASON AND I HAVE REPLACED THE CARS WHOLE PROCESSOR AND STILL HAVE PROBLEMS. NOW I HAVE A GRINDING NOISE AND A VIBRATION WHEN I GO TO APPLY MY BRAKES. PUT NEW BRAKE SHOES ON 1 WEEK AGO AND ROTORS WERE IN GOOD SHAPE SO STILL HAVE NO IDEA WHAT THE PROBLEM IS NOW. I HAVE EXHAUST FUMES OR GAS FUMES INSIDE THE VEHICLE AT TIMES. PLEASE, PLEASE HELP ME. I CAN'T AFFORD MUCH MORE. I HAVE ALL THE BASIC OIL CHANGES DONE AT 3000 MILES AND HAVE EVERY THING FIXED RIGHT AWAY. VSS HAS BEEN REPLACED 3 TIMES NOW.
NHTSA ODI #729989
Mileage unknown · Aug 24, 1999
Power TrainService Brakes, Hydraulic
I BOUGHT THE CAR LESS THAN A YEAR AGO AND HAVE PAID OVER A $1,000 IN REPAIRS. THE DAY I LEFT THE CHECK ENGINE LIGHT CAME ON. THE DEALER RE-BUILT THE TRANSMISSION TWICE, BUT I'M STILL HAVING PROBLEMS. RECENTLY I HAD FULL FRONT & BACK BRAKE JOB. WHEN I BOUGHT THE CAR THE BRAKES WERE FINE. IN LESS THAN A YEAR I HAD ONLY 10% BR…
Read full complaint
I BOUGHT THE CAR LESS THAN A YEAR AGO AND HAVE PAID OVER A $1,000 IN REPAIRS. THE DAY I LEFT THE CHECK ENGINE LIGHT CAME ON. THE DEALER RE-BUILT THE TRANSMISSION TWICE, BUT I'M STILL HAVING PROBLEMS. RECENTLY I HAD FULL FRONT & BACK BRAKE JOB. WHEN I BOUGHT THE CAR THE BRAKES WERE FINE. IN LESS THAN A YEAR I HAD ONLY 10% BRAKES LEFT. THE DAY I LEFT I LOST ALL BACK BRAKES. A MONTH LATER IT HAPPENED AGAIN. NOW THEY ARE SAYING FORD HAS RECALLED THE ANTI LOCK SYSTEM AND MASTER CYLINDER. PLEASE HELP.
NHTSA ODI #710439
Mileage unknown · Apr 27, 1999
Exterior LightingService Brakes, HydraulicSteering
BRAKES HAVE CONTINUALLY EXPERIENCED PROBLEMS WITH NOISE AND VIBRATION, REPLACEMENT OF ROTORS AND PADS ON NUMEROUS OCCASIONS, HOWEVER CONTINUE TO FAIL. MJS
NHTSA ODI #545222
Mileage unknown · Mar 18, 1999
Service Brakes, Hydraulic
AT 42,000 MILES THE VEHICLE HAD WARPED BRAKE ROTORS REPLACED 6 TIMES WHICH CAUSED VIBRATION AND EXTENDED STOPPING DISTANCE. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #835955
Mileage unknown · Mar 10, 1999
Service Brakes, Hydraulic
ALL 4 BRAKE ROTORS CUT BY DISC BRAKE PADS, ALTHOUGH PAD LINING STILL EXCEEDS STATE INSPECION REQUIREMENTS. REPLACED ALL BRAKE PADS AND 1 ROTOR, RESURFACED OTHER 3 ROTORS. DEFECTS CAUSED STEERING AND HANDLING PROBLEMS DURING BRAKING.
NHTSA ODI #704267
Mileage unknown · Nov 17, 1998
Engine And Engine CoolingService Brakes, Hydraulic
WE HAVE HAD NUMEROUS AND EXTENDED REPAIRS ON THIS VEHICLE. THE DEALERTELLS US THAT THIS VEHICLE IS NOT LISTED UNDER THE RECALL NOTICES, HOWEVER, REPLACEMENTS HAVE BEEN MADE ON MOTOR MOUNTS, STRUTS, BRACKETS, AS WELL AS OTHER SITUATIONS. FORD CORP. WILL NOT ASSIST US. WE TAKE EXCELLENT CARE OF OUR VEHICLES AND PARTS JUST SEEM …
Read full complaint
WE HAVE HAD NUMEROUS AND EXTENDED REPAIRS ON THIS VEHICLE. THE DEALERTELLS US THAT THIS VEHICLE IS NOT LISTED UNDER THE RECALL NOTICES, HOWEVER, REPLACEMENTS HAVE BEEN MADE ON MOTOR MOUNTS, STRUTS, BRACKETS, AS WELL AS OTHER SITUATIONS. FORD CORP. WILL NOT ASSIST US. WE TAKE EXCELLENT CARE OF OUR VEHICLES AND PARTS JUST SEEM TO CORRODE AND FALL OFF. WE FEEL WE ARE ENTITLED TO SOME FORM OF COMPENSATION. $4,000 IN REPAIRS ALONE IN THE PAST 6 MONTHS. PRIOR WE HAVE HAD MAJOR BRAKE REPAIRS INCLUDING SEIZED CALIPERS ON BOTH SETS AND BRAKE BOOSTER CABLE, COOLING SYSTEM FAILURES, HEAD GASKET FAILURES, BALL JOINTS, SPRINGS/COILS, STRUTS, ETC. I DO NOT UNDERSTAND WHY THIS VEHICLE IS NOT UNDER RECALL NOTICES, WHEN ALL INDICATIONS POINT TO THE FACT THAT IT IS AND WE ARE HAVING DIFFICULTIES IN THOSE AREAS. PLEASE ASSIST US IN ANY WAY POSSIBLE. WE DID GO THROUGH A REVIEW PROCESS WITH FORD AND THEY ARE NOT WILLING TO ASSIST US. THE DEALER FELT THEY COULD HAVE GIVEN US SOMETHING TOWARDS A NEW PURCHASE. HE ALSO SAID OUR ONLY RECOURSE IS TO GO THROUGH THE LEGAL CHANNELS. WE ARE AT A POINT THAT WE HAVE PUT SO MUCH MONEY INTO THE VEHICLE THAT OUR RESOURCES ARE LIMITING IN THE PURCHASE OF ANOTHER CAR.
NHTSA ODI #700684
Mileage unknown · Jun 23, 1998
Service Brakes, Hydraulic
BRAKE CALIPERS ARE STICKING.
NHTSA ODI #537440
Mileage unknown · Feb 24, 1998
Engine And Engine CoolingEquipmentExterior Lighting
RADIATOR FAILED CAUSING LEAKAGE, SEVERAL TIMES.
NHTSA ODI #531201
Official recalls
4Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
May 11, 1992
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence & remedy
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
11EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE93065 · Underbody Fuel Line Fails
Opened Jul 15, 1993 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
Illustration