NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
151 reportsClear category filter47,000 miles · Jan 10, 2006
Engine And Engine Cooling
DT*: THE CONTACT STATED WHILE DRIVING AT LOW SPEEDS DOWN A HILL AND TRYING TO STOP THE VEHICLE STALLED. ALL THE LIGHTS ON THE DASHBOARD ILLUMINATED PRIOR TO THE VEHICLE STALLING. THE BRAKES DID NOT WORK WHEN THIS OCCURRED. THE PARKING BRAKE MUST BE USED TO STOP THE VEHICLE. AN INDEPENDENT REPAIR SHOP HAS BEEN UNABLE TO DUP…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING AT LOW SPEEDS DOWN A HILL AND TRYING TO STOP THE VEHICLE STALLED. ALL THE LIGHTS ON THE DASHBOARD ILLUMINATED PRIOR TO THE VEHICLE STALLING. THE BRAKES DID NOT WORK WHEN THIS OCCURRED. THE PARKING BRAKE MUST BE USED TO STOP THE VEHICLE. AN INDEPENDENT REPAIR SHOP HAS BEEN UNABLE TO DUPLICATE THE PROBLEM.*AK UPDATED 1/25/2006 - THE MANUFACTURER INDICATED THERE WERE NOT RECALLS RELATED TO THE FAILURE. *NM
NHTSA ODI #10147352
Mileage unknown · Jan 21, 2004
Engine And Engine Cooling
MY HEAD GASKETS KEEP BLOWING .. I REALIZE THIS IS A OLDER MODEL CAR HOWEVER JUST B/C IM A SINGLE FEMALE WHO DIDNT EVEN KNOW WHAT A RECALL WAS/IS DOESNT MEAN THAT I SHOULDNT BE ENTITLED TO PERHAPS A REEMBURSMENT OR TO HAVE MY CAR FIXED PROPERLY I HAVE BEEN OUT SO MUCH MONEY ON THIS CAR AND THE MOTOR AND I ALWAYS ALWAYS DO AS D…
Read full complaint
MY HEAD GASKETS KEEP BLOWING .. I REALIZE THIS IS A OLDER MODEL CAR HOWEVER JUST B/C IM A SINGLE FEMALE WHO DIDNT EVEN KNOW WHAT A RECALL WAS/IS DOESNT MEAN THAT I SHOULDNT BE ENTITLED TO PERHAPS A REEMBURSMENT OR TO HAVE MY CAR FIXED PROPERLY I HAVE BEEN OUT SO MUCH MONEY ON THIS CAR AND THE MOTOR AND I ALWAYS ALWAYS DO AS DIRECTED WITH OIL CHANGES AND WATER CHECKINGS I JUST DONT UNDERSTAND WHY I WASNT EVER NOTIFIED OF THE DANGERS OF MY COOLING SYSTEMS AND MY MOTOR. I AM A WIDOW WITH 3 CHILDREN AND I CANT AFFORD TO KEEP HAVING MY HEADS DONE OR MY MOTOR WORKED ON PLEASE GUIDE ME IN THE DIRECTION OF SOMEONE THAT COULD PERHAPS FIX THIS PROBLEM ONCE AND FOR ALL. *AK
NHTSA ODI #10054584
93,000 miles · Jan 15, 2004
Engine And Engine Cooling
THE CAR IS A 1992 MERCURY SABLE 3.8L V-6 ENGINE WITH 93,000 MILES. THE HEAD GASKETS NEED TO BE REPLACED. I HAVE BEEN QUOTED AN ESTIMATE OF $1,000 TO FIX THE PROBLEM. I AM THE SECOND OWNER OF THE AUTOMOBILE AND IT HAS BEEN WELL MAINTAINED. THE CAR BROKE DOWN ON JUNE 25, 2003 AND IS CURRENTLY PARKED AT THE MECHANIC'S SHOP.
NHTSA ODI #10070531
22,161 miles · Jan 15, 2004
Engine And Engine Cooling
1ST ONE REMOVE & REPLACE TIMING COVER/PUMP, HOUSING, REPLACE STUDS, WATER PUMP, RENEW COOLANT. COST $1,079.60 2ND R&R HEADGASKETS/ $1,304.10. I WOULD LIKE FOR SOMEONE TO LET ME KNOW IF I COULD GET SOME OF MY MONEY BACK BECAUSE THIS WAS A RECALL A BAD PART WHICH I HAD NO KNOWLEDGE OF. UNTIL I HAD TO HAVE IT REPAIRED. FORD SAI…
Read full complaint
1ST ONE REMOVE & REPLACE TIMING COVER/PUMP, HOUSING, REPLACE STUDS, WATER PUMP, RENEW COOLANT. COST $1,079.60 2ND R&R HEADGASKETS/ $1,304.10. I WOULD LIKE FOR SOMEONE TO LET ME KNOW IF I COULD GET SOME OF MY MONEY BACK BECAUSE THIS WAS A RECALL A BAD PART WHICH I HAD NO KNOWLEDGE OF. UNTIL I HAD TO HAVE IT REPAIRED. FORD SAID THAT I WAS 9 MONTHS TO LATE UNDER WARRANTY. I AM THE SECOND OWNER OF THIS CAR HOW WOULD I HAVE KNOWN THAT FORD HAD A PROBLM WITH THIS KIND OF CAR. ANY TYPE OF HELP WOULD BE APPRECIATED. I'M A SINGLE MOM AND I CAN'T AFFORD TO HAVE THIS KIND OF CAR REPAIR. I HAD TO USE MY RENT MONEY INORDER TO GET MY CAR OUT OF THE SHOP. I JUST WANT SOMEKIND OF REPAYMENT A HEAD GASKET IS SUPPOSE TO LAST THE LIFE OF THE CAR. IT WILL BE JUST THREE YEARS THIS OCTOBER FOR ME THAT I HAVE HAD THE CAR. IT'S NOT MY PROBLEM THAT THEY PUT IN BAD PARTS AND KNEW THAT THEY NEEDED TO BE TAKEN CARE OF. BUT NO ONE WANTED TO PAY THE COST SO A LOT OF CUSTOMERS DIDN'T GET RECALL LETTERS INORDER TO TAKE CARE OF THE PROBLEM. I'M SURE THAT IF ANYONE THAT OWNED THIS CAR WOULD HAVE HAD THE REPAIRS DONE AT THE COST OF THE COMPANY. WHY WOULD THERE BE A TIME LIMIT SET ON MAJOR PART LIKE THAT. SO PEOPLE DON'T EXPERIENCE THE PROBLEM UNTIL YEARS AND THAT'S WHAT HAPPENED TO ME. I JUST WANT SOME KIND OF RESPONSE TOWARD THIS PROBLEM. THANK YOU MS. PATRICIA REESE P.O. BOX 59 SHIRLEY, NY 11967-0059
NHTSA ODI #10070057
Mileage unknown · Dec 17, 2002
Engine And Engine Cooling
WHILE DRIVING, VEHICLE STARTED RUNNING HOT, OVERHEATING. CONSUMER HAD VEHICLE TOWED TO DEALERSHIP, WHO INDICATED THAT THE CAUSE OF THE PROBLEM WAS THE WATER PUMP. DEALERSHIP REPLACED THE PUMP, BUT THE PROBLEM RECURRED 3 TIMES WITHIN A SMALL PERIOD OF TIME. PLEASE PROVIDE MORE DETAILS. TS
NHTSA ODI #10001051
Mileage unknown · Oct 7, 2002
Engine And Engine Cooling
THE MOTOR MOUNTS WERE REPLACED IN 1999 WHICH HAS FAILED AGAIN. WHILE DRIVING 45 MPH THE OWNER HEARD SOMETHING DROP/BREAK. *MR
NHTSA ODI #8020320
Mileage unknown · Jul 9, 2002
Engine And Engine Cooling
WHILE DRIVING IN A VERY HIGH TEMPERATURE, VEHICLE WILL STALL OUT.*AK
NHTSA ODI #8013560
Mileage unknown · Mar 12, 2002
Engine And Engine Cooling
VEHICLE WAS LOSING COOLANT AND OVE HEATING WHILE DRIVING. VEHICLE TAKEN TO DEALER, AND INFORMED DEALER OF A BLOWN HEAD GASKET. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8005443
Mileage unknown · Feb 15, 2002
Engine And Engine Cooling
VEHICLE STALLED THREE TIME IN HOT WEATHER AND HEAVY TRAFFIC.
NHTSA ODI #9005867
Mileage unknown · Feb 12, 2002
Engine And Engine Cooling
CAR WAS RUNNING FINE ALL OF A SUDDEN I HAD NO HEAT THOUGHT NEEDED A THERMOSTAT BUT DEALER SAID I NEEDED A HEAD GASKET THAT THIS HAS BEEN A WELL KNOWN PROBLEM ON FORD 3.8 V6 CARS. THIS CAR HAS BEEN MAINTAINED BY ME AND THE PREVIOUS OWNER WHO IS MY FATHER A RETIRED FORD EMPLOYEE. THE CAR WAS ALWAYS TAKEN CARE OF AT A DEALER. I CAL…
Read full complaint
CAR WAS RUNNING FINE ALL OF A SUDDEN I HAD NO HEAT THOUGHT NEEDED A THERMOSTAT BUT DEALER SAID I NEEDED A HEAD GASKET THAT THIS HAS BEEN A WELL KNOWN PROBLEM ON FORD 3.8 V6 CARS. THIS CAR HAS BEEN MAINTAINED BY ME AND THE PREVIOUS OWNER WHO IS MY FATHER A RETIRED FORD EMPLOYEE. THE CAR WAS ALWAYS TAKEN CARE OF AT A DEALER. I CALLED FORD AND WAS TOLD SORRY CAN'T HELP SO NOW I HAVE A$1600.00 BILL TO PAY. I AM IN THE PROCESS OF WRITING A LETTER TOFORD. THANK YOU. *AK
NHTSA ODI #758137
Official recalls
4Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
May 11, 1992
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence & remedy
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
11EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE93065 · Underbody Fuel Line Fails
Opened Jul 15, 1993 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
Illustration