BACK IN 2007 NOTICED SMALL BUMPS IN PAINT ONLY ON THE ROOF,WENT TO FORD DEALER,THEY SAID NO PROBLEM WITH THE PAINT. TIME WENT ON, PAINT GOT WORSE,MORE BUBBLES AND CRACKS,.IN 2008 WROTE TO FORD ABOUT PROBLEM THEY SAID THEY HAD NO COMPLAINTS ABOUT ROOF PAINT. NOW THE ENTIRE ROOF IS BUMPY,CRACKED, WITH BARE RUSTED METAL SHOWING. CO…
Read full complaint
BACK IN 2007 NOTICED SMALL BUMPS IN PAINT ONLY ON THE ROOF,WENT TO FORD DEALER,THEY SAID NO PROBLEM WITH THE PAINT. TIME WENT ON, PAINT GOT WORSE,MORE BUBBLES AND CRACKS,.IN 2008 WROTE TO FORD ABOUT PROBLEM THEY SAID THEY HAD NO COMPLAINTS ABOUT ROOF PAINT. NOW THE ENTIRE ROOF IS BUMPY,CRACKED, WITH BARE RUSTED METAL SHOWING. COST TO FIX IS 1000.00. *TR
NHTSA ODI #10442074
36,000 miles · Apr 13, 2009
Structure
I HAVE A 2004 MERCURY MARAUDER AND HAVE HAD A PROBLEM WITH THE PAINT SPLITTING AND BLISTERING ON THE FRONT HOOD, ROOF AND REAR TRUNK. I CONTACTED BOTH MY LOCAL DEALERSHIP AND FORD AND THEY BOTH SAY I'M JUST OUTSIDE OF MY WARRANTY (WITHIN A YEAR) AND THEREFORE NOTHING THEY CAN DO. THE DEALERSHIP LOOKED AT THE ISSUE AND STATED IT …
Read full complaint
I HAVE A 2004 MERCURY MARAUDER AND HAVE HAD A PROBLEM WITH THE PAINT SPLITTING AND BLISTERING ON THE FRONT HOOD, ROOF AND REAR TRUNK. I CONTACTED BOTH MY LOCAL DEALERSHIP AND FORD AND THEY BOTH SAY I'M JUST OUTSIDE OF MY WARRANTY (WITHIN A YEAR) AND THEREFORE NOTHING THEY CAN DO. THE DEALERSHIP LOOKED AT THE ISSUE AND STATED IT WAS POSSIBLY MISSING SOME PROTECTIVE UNDERCOATING AND IS ONLY GOING TO GET WORSE. I DID FILE A COMPLAINT WITH FORD. *TR
NHTSA ODI #10265114
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE14021 · Steering Column Shaft Obstruction
Opened Jul 7, 2014 · Closed Nov 21, 2014
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System; Steering
On July 7, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation based on five complaints (VOQs) alleging incidents ofinterference between dislodged exhaust manifold heat shields and the lower steering shaft/knuckle, including one alleging the interference resulted in a crash on a highway entrance ramp. Since opening this investigation, ODI has received four additional owner complaints.One indicated that the shield was removed before binding could occur.The other three occurred at low speed and produced some momentary steering binding that was overcome by the driver when additional steering effort was applied.Once the shield was repaired or removed, the steering returned to normal.The single incident ODI identified as a possible crash (VOQ No. 10578715) related to this condition could not be verified and the description of the crash in the complaint was not supported by the police accident report.No additional crash allegations have been identified related to the alleged defect condition.Information provided by Ford in its September 10, 2014 response to ODI's information request letter identified 10 additional incidents resulting in a low rate of 1.6 incidents per 100,000 vehicles sold in vehicles ranging from 7 to 11 years in service.Six of these incidents were reported by a single source, a state police fleet that corrected the problems in March 2011 and has not reported any additional failures since.Ford also reported 5 warranty claims, but these incidents occurred at very low mileages and appeared to be caused by loose or missing heat shield attachment hardware rather than the corrosion condition that was the cause of the more recent incidents and the focus of this investigation.This investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.The following VOQs are associated with this investigation:10643753, 10615584, 10611362, 10610451, 10578715, 10479681, 10471833, 10317493.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System
On July 7, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation based on five complaints (VOQs) alleging incidents ofinterference between dislodged exhaust manifold heat shields and the lower steering shaft/knuckle, including one alleging the interference resulted in a crash on a highway entrance ramp. Since opening this investigation, ODI has received four additional owner complaints.One indicated that the shield was removed before binding could occur.The other three occurred at low speed and produced some momentary steering binding that was overcome by the driver when additional steering effort was applied.Once the shield was repaired or removed, the steering returned to normal.The single incident ODI identified as a possible crash (VOQ No. 10578715) related to this condition could not be verified and the description of the crash in the complaint was not supported by the police accident report.No additional crash allegations have been identified related to the alleged defect condition.Information provided by Ford in its September 10, 2014 response to ODI's information request letter identified 10 additional incidents resulting in a low rate of 1.6 incidents per 100,000 vehicles sold in vehicles ranging from 7 to 11 years in service.Six of these incidents were reported by a single source, a state police fleet that corrected the problems in March 2011 and has not reported any additional failures since.Ford also reported 5 warranty claims, but these incidents occurred at very low mileages and appeared to be caused by loose or missing heat shield attachment hardware rather than the corrosion condition that was the cause of the more recent incidents and the focus of this investigation.This investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.The following VOQs are associated with this investigation:10643753, 10615584, 10611362, 10610451, 10578715, 10479681, 10471833, 10317493.
Steering
On July 7, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation based on five complaints (VOQs) alleging incidents ofinterference between dislodged exhaust manifold heat shields and the lower steering shaft/knuckle, including one alleging the interference resulted in a crash on a highway entrance ramp. Since opening this investigation, ODI has received four additional owner complaints.One indicated that the shield was removed before binding could occur.The other three occurred at low speed and produced some momentary steering binding that was overcome by the driver when additional steering effort was applied.Once the shield was repaired or removed, the steering returned to normal.The single incident ODI identified as a possible crash (VOQ No. 10578715) related to this condition could not be verified and the description of the crash in the complaint was not supported by the police accident report.No additional crash allegations have been identified related to the alleged defect condition.Information provided by Ford in its September 10, 2014 response to ODI's information request letter identified 10 additional incidents resulting in a low rate of 1.6 incidents per 100,000 vehicles sold in vehicles ranging from 7 to 11 years in service.Six of these incidents were reported by a single source, a state police fleet that corrected the problems in March 2011 and has not reported any additional failures since.Ford also reported 5 warranty claims, but these incidents occurred at very low mileages and appeared to be caused by loose or missing heat shield attachment hardware rather than the corrosion condition that was the cause of the more recent incidents and the focus of this investigation.This investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.The following VOQs are associated with this investigation:10643753, 10615584, 10611362, 10610451, 10578715, 10479681, 10471833, 10317493.
2004 Mercury Marauder Problems, Complaints & Recalls | Skip That Year
Illustration