Fuel System, Gasoline. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports1 fire reports8 injury reports

Unknown Or Other complaints

2 reports

Clear category filter

153,000 miles · Oct 10, 2017

Unknown Or Other

MY CAR WAS STOLEN

NHTSA ODI #11032625

92,000 miles · Mar 15, 2017

Electrical SystemFuel/propulsion SystemUnknown Or Other

Read full complaint

NHTSA CAMPAIGN NUMBER:04V421000 MANUFACTURER FORD MOTOR COMPANY WAS DRIVING ON A MAIN CITY ST. MY AUTO STOPPED WITH NO POWER IN THE LEFT LANE OF BUSY 4 LANE ST. WOULD NOT START IN NEUTRAL OR PARK, MAN PUSHED IT INTO THE CTR. LANE OUT OF TRAFFIC AREA. POLICEMAN CAME AFTER I CALLED 911, AFTER A FEW MINUTES HE SUGGESTED TAKING KEY OUT STEPPING ON BRAKE THEN INSERTING KEY BACK IN IGNITION, DID THAT AND IT STARTED RIGHT UP, AND HE FOLLOWED ME TO MY ST. AND I GOT SAFELY HOME. PRIOR TO THIS SHUT DOWN INCIDENT IT HAD STALLED GOING DOWN A HILL HOWEVER PUT IT IN NEUTRAL AND IT STARTED UP AGAIN. THIS INCIDENT COULD HAVE CAUSED A SERIOUS ACCIDENT, PRIOR TO THIS INCIDENT IT HAD BEEN CUTTING OUT FOR A COUPLE OF MONTHS WHICH I THOUGHT WAS CHEAP GAS, SO CHANGED TO TECTRON. I HAVE CALLED FORD ON 3/15 TWICE AND THEY SAID THEY CAN NOT DO ANYTHING ABOUT IT, I THEN RESEARCHED THIS ONLINE AND FOUND THIS SITE AND WANT TO POST EXACTLY WHAT HAPPENED TO ME AS SHOWN BY THE NHTSA ON RECALL ETC. IT DOES SHOW IT IS FOR THE ORIG OWNER, I AM THE 2ND. OWNER HOWEVER THIS HAS OCCURRED WITHIN THE 15YR. LIMITATION YOU HAVE POSTED FOR COMPLAINTS EXPLAINED TO FORD THAT IT MAY HAVE TAKEN THIS LONG FOR THE FILTER TO REACT IN THIS MANNER.

NHTSA ODI #10966151

Official recalls

04V421000 · Fuel System, Gasoline

Aug 30, 2004

ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.

Consequence & remedy

Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.

Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. THE CAMPAIGN BEGAN ON APRIL 16, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.