IllustrationI HAVE FOUND 3 RECALLS FOR MY CAR, THEY ARE ALL THE EXACT PROBLEMS I AM HAVING, BUT WHEN I SEARCHED FOR OPEN RECALLS IT SAID NONE ARE OPEN FOR MY CAR. I NEED MY CAR REPAIRED AND THE RECALLS COMPLETED.
2002 Mercury Cougar
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cougar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
1025–50K
2150–75K
1775–100K
13100–150K
4150K+
79 reports with mileage · 16 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports1 fire reports8 injury reports
Suspension complaints
3 reportsTL*THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE BEGAN TO LOSE POWER WHILE DRIVING, WHICH MADE IT DIFFICULT TO STEER THE VEHICLE. HE EXPERIENCED DIFFICULTLY PULLING THE VEHICLE TO THE SIDE OF THE ROAD. AFTER APPROXIMATELY 15 MINUTES, THE VEHICLE WAS ABLE TO BE RESTARTED AND OPERATED NORMALLY. HE…
Read full complaint
TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE BEGAN TO LOSE POWER WHILE DRIVING, WHICH MADE IT DIFFICULT TO STEER THE VEHICLE. HE EXPERIENCED DIFFICULTLY PULLING THE VEHICLE TO THE SIDE OF THE ROAD. AFTER APPROXIMATELY 15 MINUTES, THE VEHICLE WAS ABLE TO BE RESTARTED AND OPERATED NORMALLY. HE DROVE THE VEHICLE HOME AND LATER CALLED THE DEALER. THE DEALER ADVISED HIM TO BRING IN THE VEHICLE AND THEY MADE REPAIRS AT THE COST OF $697. THE FAILURE WAS IDENTIFIED AS BEING INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V421000 (FUEL SYSTEM, GASOLINE). THE FAILURE COULD CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED AND CAUSE THE ENGINE TO STALL. THE FAILURE MILEAGE WAS 84,000 AND CURRENT MILEAGE WAS 86,000. UPDATED 07/16/08*LJ THE BUSHINGS AND CLUTCH WERE WORN. THE FUEL PUMP AND FUEL SENDER WERE REPLACED. THE ENGINE LIGHT WAS ON. THE DEALER REPLACED A LEAKING INTAKE. UPDATED 07/16/08
THERE WAS A GRINDING NOISE COMING FROM THE FRONT OF THE VEHICLE WHEN GOING OVER BUMPS, THE FRONT SWAY BAR BUSHINGS HAD TO REPLACED, HOWEVER PRIOR TO THE THIRD REPLACEMENT, CONSUMER LOST CONTROL OF THE VEHICLE AND ENDED IN A DITCH. PH *JB
Official recalls
104V421000 · Fuel System, Gasoline
Aug 30, 2004
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. THE CAMPAIGN BEGAN ON APRIL 16, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.