IllustrationWHEN THE FUEL TANK IS FULL OR NEAR FULL, A STRONG GASOLINE ODOR IS PRESENT. APPEARS TO BE THE SAME AS ODI ID-807696 EXCEPT WE DON'T SEE ANY FUEL LEAKAGE. WHAT RECOURSE DO WE HAVE WITH THIS?
1990 Mercury Cougar
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cougar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 86 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports9 fire reports4 injury reports
Fuel System, Gasoline complaints
4 reportsFUEL LINE AND TANK LEAK GAS, CAUSING FIRE.
FUMES HAVE A STRONG SMELL AT ALL TIMES SINCE THE BEGINNING OF DECEMBER 97. CONSUMER ALSO SEES GAS ON GROUND OF PASSENGER'S SIDE DUE TO A LEAKAGE OF GASOLINE FROM A FRACTURED FUEL FILLER PIPE AND LEAKING FUEL PUMP/SENDER. CONSUMER WOULD HAVE TO DRIVE WITH WINDOWS OPEN IF OPERATING THIS VEHICLE. THERE IS A RECALL FOR THIS PROBLE…
Read full complaint
FUMES HAVE A STRONG SMELL AT ALL TIMES SINCE THE BEGINNING OF DECEMBER 97. CONSUMER ALSO SEES GAS ON GROUND OF PASSENGER'S SIDE DUE TO A LEAKAGE OF GASOLINE FROM A FRACTURED FUEL FILLER PIPE AND LEAKING FUEL PUMP/SENDER. CONSUMER WOULD HAVE TO DRIVE WITH WINDOWS OPEN IF OPERATING THIS VEHICLE. THERE IS A RECALL FOR THIS PROBLEM ON THE 92'S AND 93'S. CONSUMER WILL BE TAKING VEHICLE IN FOR CHECK AND SERVICE BETWEEN 1-5-98 AND 1-10-98.*AK
WHEN FUEL TANK IS FULL, TOP OF GAS TANK LEAKS FUEL AND MAKES INTERIOR OF VEHICLE SMELL. *AK
Official recalls
396V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
91V076000 · Visibility:windshield Wiper/washer:motor
May 6, 1991
THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.
Consequence & remedy
Consequence: CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.
Remedy: APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.
90V026000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Feb 12, 1990
BATTERY TO STARTER CABLES ARE LONGER THAN SPECIFIED; EXCESSIVE CABLE LENGTH COULD CONTACT ENGINE DAMPER PULLEY.
Consequence & remedy
Consequence: CABLE PROTECTIVE COVERING AND INSULATION COULD WEAR THROUGH AND CAUSE A DIRECT SHORT TO GROUND, RESULTING IN OVERHEATING OF THE CABLE INSULATION AND POSSIBLY A UNDERHOOD FIRE.
Remedy: REPLACE BATTERY TO STARTER CABLE WITH CORRECT LENGTH CABLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE95019 · Faulty Seatbelt Buckles
Opened Mar 27, 1995 · Closed Jul 31, 1995
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available
EA93033 · Thrttl Vlv Linkage Bushing
Opened Dec 30, 1993 · Closed Dec 30, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93075 · Thrttl Vlv Linkage Bushing
Opened Aug 30, 1993 · Closed Dec 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA90034 · Hood Latches Fail
Opened Jun 26, 1990 · Closed Feb 25, 1992
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE90073 · Hood Latches Fail
Opened Apr 11, 1990 · Closed Jun 26, 1990
Status: closed (inferred from source dates) · Structure
There is no summary currently available