IllustrationSEAT BELT DOESN'T STAY LOCKED AND LATCH BROKE, AUTOMATIC HEAD LIGHTS DON'T WORK THE DIGITAL INSTRUMENT CLUSTER DON'T WORK AND AS SOON AS IS GETS SO HOT IT VAPER LOCKS A LOT
1990 Mercury Cougar
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cougar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 86 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports9 fire reports4 injury reports
Exterior Lighting complaints
5 reportsTHE HEADLIGHTS FLICKERED ON A FEW OCCASSION AND THEN LATER THEY WENT OFF AND ON. THIS WAS VERY DANGEROUS BECAUSE YOU COULDN'T DRIVE THE CAR FOR FEAR THE LIGHTS WOULD GO OUT AND YOU WOULD CREATE OR BE IN AN ACCIDENT. THE PROBLEM WENT AWAY FOR A FEW MONTHS UNTIL MY BROTHER BORROWED THE CAR FOR A WEEK AND THE PROBLEM RETURNED .…
Read full complaint
THE HEADLIGHTS FLICKERED ON A FEW OCCASSION AND THEN LATER THEY WENT OFF AND ON. THIS WAS VERY DANGEROUS BECAUSE YOU COULDN'T DRIVE THE CAR FOR FEAR THE LIGHTS WOULD GO OUT AND YOU WOULD CREATE OR BE IN AN ACCIDENT. THE PROBLEM WENT AWAY FOR A FEW MONTHS UNTIL MY BROTHER BORROWED THE CAR FOR A WEEK AND THE PROBLEM RETURNED . IT WAS VERY BAD THAT WEEK. THE LIGHTS WENT OUT AT LEAST ONCE EVERYDAY. I CHANGED THE HEADLIGHT BULB AND CHECKED THE GROUNDS, THE WIRING SYSTEM FOR LOOSE WIRE. I COULDN'T FIND ANYTHING. I WENT TO THE PART STORE TO INQUIRE IF THEY HAD ANY IDEA WHAT COULD BE WRONG AND THEY SAID "IS IT A FORD PRODUCT". I SAID YES AND THEY SAID FORD HAD A PROBLEM WITH THE LIGHT SWITCHES. I COULDN'T IMAGINE ANYTHING AS SERIOUS AS THIS PROBLEM WHICH THEY CLASSIFIED AS A KNOW PROBLEM AND NO CORRECTIVE ACTION WAS TAKEN. I CHANGED THE LIGHT SWITCH AND THE PROBLEM WAS CORRECTED. I CAN'T IMAGINE A DEFECT MORE DANGEROUS THAN HAVING YOUR HEADLIGHTS GO OUT WHILE DRIVING AT NIGHT. *AK
HUSBAND IS A MECHANIC AND SAID NUMEROUS COUGARS HAVE COME IN WITH SAME PROBLEM. I FEEL YOUR HEADLIGHTS FLASHING WHILE DRIVING COULD CAUSE AN ACCIDENT. CONFUSING OTHERS DRIVERS, ALONG THE DRIVER HIM/HERSELF NOT BEING ABLE TO SEE. *AK
CONSUMER COMPLAINED THAT THE LENSES ON HEADLIGHTS ARE BADLY DISCOLORED, WHICH CAUSES POOR VISIBILITY AT NIGHT WHILE DRIVING. CONSUMER COMPLAINED THAT THE DEALER WOULD NOT SELL THE LENSES UNLESS THE CONSUMER WOULD BUY THE WHOLE LIGHTING KIT; COSTING APPROXIMATELY 355.00 DOLLARS. *AK *SLC
THE PLASTIC LENSES IN THE HEADLIGHTS HAVE DETERIORATED TO A CLOUDY LIGHT YELLOW CONDITION. THE LIGHT HAS GRADUALLY LESSONED TO THE POINT THAT AT NIGHT, HIGH BEAMS ARE NECESSARY IN ORDER TO SEE THE ROAD. *AK
Official recalls
396V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
91V076000 · Visibility:windshield Wiper/washer:motor
May 6, 1991
THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.
Consequence & remedy
Consequence: CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.
Remedy: APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.
90V026000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Feb 12, 1990
BATTERY TO STARTER CABLES ARE LONGER THAN SPECIFIED; EXCESSIVE CABLE LENGTH COULD CONTACT ENGINE DAMPER PULLEY.
Consequence & remedy
Consequence: CABLE PROTECTIVE COVERING AND INSULATION COULD WEAR THROUGH AND CAUSE A DIRECT SHORT TO GROUND, RESULTING IN OVERHEATING OF THE CABLE INSULATION AND POSSIBLY A UNDERHOOD FIRE.
Remedy: REPLACE BATTERY TO STARTER CABLE WITH CORRECT LENGTH CABLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE95019 · Faulty Seatbelt Buckles
Opened Mar 27, 1995 · Closed Jul 31, 1995
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available
EA93033 · Thrttl Vlv Linkage Bushing
Opened Dec 30, 1993 · Closed Dec 30, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93075 · Thrttl Vlv Linkage Bushing
Opened Aug 30, 1993 · Closed Dec 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA90034 · Hood Latches Fail
Opened Jun 26, 1990 · Closed Feb 25, 1992
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE90073 · Hood Latches Fail
Opened Apr 11, 1990 · Closed Jun 26, 1990
Status: closed (inferred from source dates) · Structure
There is no summary currently available