IllustrationSEAT BELT DOESN'T STAY LOCKED AND LATCH BROKE, AUTOMATIC HEAD LIGHTS DON'T WORK THE DIGITAL INSTRUMENT CLUSTER DON'T WORK AND AS SOON AS IS GETS SO HOT IT VAPER LOCKS A LOT
1990 Mercury Cougar
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cougar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 86 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports9 fire reports4 injury reports
Electrical System complaints
19 reportsAFTER STARTING VEHICLE FLICKERING ON OFF OF DASH LIGHTS,PANEL COMPLETELY OUT AND NOW WILL NOT COME BACK ON,CREATING AN ISSUE DRIVING,UNABLE TO SEE SPEED,MILAGE GAS USAGE,WHEN CHECKING UNDER HOOD I WAS GIVEN AN ELECTRICAL SHOCK,THE MOTOR WAS RUNNING,IMMEDIATELY TURNED OFF MOTOR
HEAVY TRAFFIC ON STATE HIGHWAY ENGINE OVERHEATING ALARM ACTIVATED,INCIDENT HAS OCCURED TWICE,IN TRAFFIC,EVERYTHING HAD TO BE TURNED OFF AND I HAD TO PULL OFF OF HIGHWAY, OTHER COMPLAINT DASH PANEL LIGHTS OUT WITH DEFINITELY ELECTRICAL ISSUE,ALMOST WILL NOT START,THIS OCCURED WHILE DRIVING AND NOW EILL NOT COME BACK ON AT ALL
TL* THE CONTACT OWNS A 1990 MERCURY COUGAR. THE CONTACT STATED SMOKE EMITTED FROM UNDERNEATH THE HOOD WHEN THE ENGINE WAS TURNED ON AND WITHIN SECONDS THE ENGINE WAS ON FIRE. THE FIRE DEPARTMENT ADVISED THE FIRE ORIGINATED AT A FUSE BOX LOCATED IN THE BATTERY AND ALTERNATOR AREA. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS N…
Read full complaint
TL* THE CONTACT OWNS A 1990 MERCURY COUGAR. THE CONTACT STATED SMOKE EMITTED FROM UNDERNEATH THE HOOD WHEN THE ENGINE WAS TURNED ON AND WITHIN SECONDS THE ENGINE WAS ON FIRE. THE FIRE DEPARTMENT ADVISED THE FIRE ORIGINATED AT A FUSE BOX LOCATED IN THE BATTERY AND ALTERNATOR AREA. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 89,000.
TWO YEARS AGO THE CONSUMER RECEIVED A RECALL LETTER NHTSA # 96V071000. DEALER REPLACED THE IGNITION SWITCH. ONE YEAR LATER THE RECALLED COMPONENT FAILED AND THIS TIME AN INDEPENDENT SHOP REPLACED THE IGNITION SWITCH. ONCE AGAIN THE IGNITION SWITCH NEEDS TO BE REPLACED. THE DEALER HAS BEEN NOTIFIED. *NM
THE VEHICLE'S IGNITION MODULE WAS REPLACED BECAUSE IT WAS DEFECTIVE. *YH
IGNITION WENT BAD. FORD NO LONGER MAKES THE PART. PLEASE PROVIDE DETAILS. *AK
NO SUMMARY
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
ALTERNATOR CAUGHT ON FIRE TWICE, COULD HAVE CAUSED INJURIES. CAUSE UNKNOWN. PLEASE PROVIDE FURTHER INFORMATION AND VIN#. *AK
Official recalls
396V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
91V076000 · Visibility:windshield Wiper/washer:motor
May 6, 1991
THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.
Consequence & remedy
Consequence: CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.
Remedy: APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.
90V026000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Feb 12, 1990
BATTERY TO STARTER CABLES ARE LONGER THAN SPECIFIED; EXCESSIVE CABLE LENGTH COULD CONTACT ENGINE DAMPER PULLEY.
Consequence & remedy
Consequence: CABLE PROTECTIVE COVERING AND INSULATION COULD WEAR THROUGH AND CAUSE A DIRECT SHORT TO GROUND, RESULTING IN OVERHEATING OF THE CABLE INSULATION AND POSSIBLY A UNDERHOOD FIRE.
Remedy: REPLACE BATTERY TO STARTER CABLE WITH CORRECT LENGTH CABLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE95019 · Faulty Seatbelt Buckles
Opened Mar 27, 1995 · Closed Jul 31, 1995
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available
EA93033 · Thrttl Vlv Linkage Bushing
Opened Dec 30, 1993 · Closed Dec 30, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93075 · Thrttl Vlv Linkage Bushing
Opened Aug 30, 1993 · Closed Dec 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA90034 · Hood Latches Fail
Opened Jun 26, 1990 · Closed Feb 25, 1992
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE90073 · Hood Latches Fail
Opened Apr 11, 1990 · Closed Jun 26, 1990
Status: closed (inferred from source dates) · Structure
There is no summary currently available