NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
17 reportsClear category filter148,000 miles · Mar 24, 2026
Electrical System
The contact owns a 2009 Mercedes-Benz ML350. The contact stated that while driving 50 MPH on the parkway, the contact heard a noise and several warning lights illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic, where it was diagnosed, and determined that the Signal Acquisition Mo…
Read full complaint
The contact owns a 2009 Mercedes-Benz ML350. The contact stated that while driving 50 MPH on the parkway, the contact heard a noise and several warning lights illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic, where it was diagnosed, and determined that the Signal Acquisition Module (SAM) needed to be replaced. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 22V678000 (ELECTRICAL SYSTEM); however, the VIN was not included in the recall. The manufacturer was notified of the failure and informed the contact that the VIN was not associated with the recall. The failure mileage was 148,000.
NHTSA ODI #11726683
196,577 miles · Aug 14, 2025
Electrical System
Odometer Fraud. The contact purchased a 2009 Mercedes-Benz ML350. The contact stated that while an independent mechanic was servicing the vehicle, the mechanic informed the contact that there was a mileage discrepancy based on the Carfax history report. The vehicle was a dealer sale. At the time of purchase in October 2024, the …
Read full complaint
Odometer Fraud. The contact purchased a 2009 Mercedes-Benz ML350. The contact stated that while an independent mechanic was servicing the vehicle, the mechanic informed the contact that there was a mileage discrepancy based on the Carfax history report. The vehicle was a dealer sale. At the time of purchase in October 2024, the vehicle mileage was 146,743; however, the Carfax history report displayed that the mileage was 196,577 on July 15, 2024, while an Auction company was still in possession of the vehicle.
NHTSA ODI #11680606
140,000 miles · Jun 23, 2025
Electrical SystemFireInjury
The contact owns a 2009 Mercedes-Benz ML350. The contact stated that while driving at 45 MPH in heavy rain, she observed smoke emanating from the rear of the vehicle. The contact stated that there may have been unknown warning lights illuminated. The vehicle was steered to the side of the road and turned off. The contact stated…
Read full complaint
The contact owns a 2009 Mercedes-Benz ML350. The contact stated that while driving at 45 MPH in heavy rain, she observed smoke emanating from the rear of the vehicle. The contact stated that there may have been unknown warning lights illuminated. The vehicle was steered to the side of the road and turned off. The contact stated that when the vehicle was restarted, multiple unknown warning lights illuminated. The contact also stated that the key pad stopped working, and multiple electrical components stopped working, and that she experienced sinus issues thereafter. The vehicle was taken to a dealer where it was diagnosed that the SAM module got wet and there was an electrical fire because the wires were not covered and the SAM module needed to be replaced. The vehicle was not repaired. The vehicle was then taken to an independent mechanic, where it was not diagnosed, but the SAM module was replaced. The failure persisted. The vehicle was then towed to another independent mechanic, where it has yet to be diagnosed. The manufacturer was notified of the failure. The failure mileage was 140,000.
NHTSA ODI #11668575
Mileage unknown · Apr 14, 2025
Electrical SystemStructure
These models were recalled on March 9, 2009 NHTSA CAMPAIGN 09v076000. my vin number apparently did not fall within the selected vin numbers. However my auto even though it is the same year as the recall has this same exact defect and condition and is deemed to be a fire hazard. what are my options.
NHTSA ODI #11654619
140,000 miles · Dec 30, 2022
Electrical SystemFire
The contact owned a 2009 Mercedes-Benz ML350. The contact stated while driving 45-50 MPH with his wife in the front passenger seat and his children in the rear seats, his wife smelled a strong burning odor and saw smoke coming from underneath the front passenger seat. There was no warning light illuminated. The contact immediate…
Read full complaint
The contact owned a 2009 Mercedes-Benz ML350. The contact stated while driving 45-50 MPH with his wife in the front passenger seat and his children in the rear seats, his wife smelled a strong burning odor and saw smoke coming from underneath the front passenger seat. There was no warning light illuminated. The contact immediately veered to the side of the road. Both the contact and his family exited the vehicle and ran away from the vehicle. The contact stated that approximately 30 seconds after exiting the vehicle, the vehicle caught on fire and exploded several times, causing a nearby tree to catch on fire. The contact was able to extinguish the fire with the assistance of the fire department. A fire department report was filed. A police report was filed. There were no injuries sustained. The vehicle was towed to a tow yard where it was awaiting to be totaled. The dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 140,000.
NHTSA ODI #11499523
Mileage unknown · Sep 7, 2022
Electrical SystemUnknown Or Other
Driver side front door and driver side back door do not unlock or lock. You have to Manually unlock and lock.
NHTSA ODI #11483240
104,284 miles · Feb 14, 2022
Electrical System
The contact owns a 2009 Mercedes Benz ML350. The contact stated that while attempting to open the door with the key fob, the fob failed to open the vehicle. In addition, the contact noticed that the headlights failed and the gas gauge also failed to operate as needed. The vehicle was taken to an independent mechanic where it was…
Read full complaint
The contact owns a 2009 Mercedes Benz ML350. The contact stated that while attempting to open the door with the key fob, the fob failed to open the vehicle. In addition, the contact noticed that the headlights failed and the gas gauge also failed to operate as needed. The vehicle was taken to an independent mechanic where it was diagnosed that the rear Signal Acquisition Module (SAM) board was corroded, and the rear SAM module needed to be replaced. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 104,284.
NHTSA ODI #11451820
116,500 miles · Jul 15, 2019
Electrical System
FAILING/FAULTY EIS ELECTRONIC IGNITION SYSTEM. MY VEHICLE HAS 117,000 MILES AND HAS INTERMITTENT IGNITION ISSUES. I PLACE THE KEY IN THE IGNITION A MESSAGE ON THE DASH, "KEY DOES NOT BELONG TO VEHICLE", CAR WILL NOT TURN TO START, TAKES SEVERAL ATTEMPTS TO HAVE CAR START. THE MERCEDES DEALER IN MY AREA DIAGNOSED THE ISSUES AS NE…
Read full complaint
FAILING/FAULTY EIS ELECTRONIC IGNITION SYSTEM. MY VEHICLE HAS 117,000 MILES AND HAS INTERMITTENT IGNITION ISSUES. I PLACE THE KEY IN THE IGNITION A MESSAGE ON THE DASH, "KEY DOES NOT BELONG TO VEHICLE", CAR WILL NOT TURN TO START, TAKES SEVERAL ATTEMPTS TO HAVE CAR START. THE MERCEDES DEALER IN MY AREA DIAGNOSED THE ISSUES AS NEEDING TO REPLACE EIS, ELECTRONIC IGNITION SYSTEM, EST. COST OF $3,700.00. THE ISSUE HAS GONE TO INTERMITTENT TO EVERY TIME I TRY TO START THE VEHICLE. THIS CAR HAS LOW MILES AND HAS BEEN DEALER MAINTAINED. THIS SHOULD BE A RECALL AS DEFECTIVE PRODUCT
NHTSA ODI #11232097
102,000 miles · May 15, 2019
Electrical System
THE LIFTGATE ON MY CAR QUIT WORKING RECENTLY. I DISCOVERED THAT THE LIFTGATE MOTOR WAS IN A POOL OF WATER. THERE IS A RECALL 09V076000 THAT IS ALREADY ISSUED FOR THIS PROBLEM. I AM VERY CONCERNED THAT THIS COULD CAUSE A SHORT CIRCUIT WHICH COULD LEAD TO A FIRE. FOR SOME REASON MY CAR IS NOT ON THE RECALL LIST EVEN THOUGH IT …
Read full complaint
THE LIFTGATE ON MY CAR QUIT WORKING RECENTLY. I DISCOVERED THAT THE LIFTGATE MOTOR WAS IN A POOL OF WATER. THERE IS A RECALL 09V076000 THAT IS ALREADY ISSUED FOR THIS PROBLEM. I AM VERY CONCERNED THAT THIS COULD CAUSE A SHORT CIRCUIT WHICH COULD LEAD TO A FIRE. FOR SOME REASON MY CAR IS NOT ON THE RECALL LIST EVEN THOUGH IT IS THAT MODEL YEAR AND THE EXACT PROBLEM AS STATED IN THE RECALL. PLEASE ADVISE.
NHTSA ODI #11207940
130,000 miles · Apr 18, 2018
Electrical System
TL* THE CONTACT OWNS A 2009 MERCEDES-BENZ ML350. THE CONTACT STATED THAT WHEN THE KEY FOB WAS INSERTED IN THE IGNITION, THE VEHICLE WOULD NOT START AND THE 'KEY IS NOT FOR THIS CAR' MESSAGE APPEARED. THE CONTACT STATED THAT THE KEY HAD NOT BEEN REPLACED AND WAS THE SAME KEY THAT HE HAD ALWAYS USED TO OPERATE THE VEHICLE. THE CON…
Read full complaint
TL* THE CONTACT OWNS A 2009 MERCEDES-BENZ ML350. THE CONTACT STATED THAT WHEN THE KEY FOB WAS INSERTED IN THE IGNITION, THE VEHICLE WOULD NOT START AND THE 'KEY IS NOT FOR THIS CAR' MESSAGE APPEARED. THE CONTACT STATED THAT THE KEY HAD NOT BEEN REPLACED AND WAS THE SAME KEY THAT HE HAD ALWAYS USED TO OPERATE THE VEHICLE. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO THE DEALER (CONTEMPORARY MOTOR CARS INC., 100 OCEANPORT AVE, LITTLE SILVER, NJ) WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC IGNITION WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.
NHTSA ODI #11088888
Official recalls
3Apr 26, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2006-2012 ML, GL, and R-Class vehicles. Please refer to MBUSA's recall report for specific vehicle model details. Moisture may accumulate and cause corrosion in the brake booster housing unit, which can result in reduced brake performance or brake failure.
Consequence & remedy
Consequence: Reduced brake performance or brake failure can increase the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy has been performed. Dealers will remove the rubber sleeve, inspect the brake booster, and as necessary, replace the brake booster. All repairs will be performed free of charge. Owner notification letters were mailed on May 24, 2024. Owners may contact MBUSA customer service at 1-800-367-6372. MMUSA's number for this recall is 2024050001/2. This recall is an expansion of previous recall number 22V-315.
May 9, 2022
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2006-2012 ML-Class, GL-Class, and R-Class vehicles. Please refer to MBUSA's recall report for specific vehicle model details. Moisture may accumulate and cause corrosion in the brake booster housing unit, which can result in reduced brake performance or brake failure.
Consequence & remedy
Consequence: Reduced brake performance or brake failure can increase the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy has been performed. Dealers will remove the rubber sleeve, inspect the brake booster, and as necessary, replace the brake booster. All repairs will be performed free of charge. Owner notification letters were mailed June 30, 2022. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's numbers for this recall are 2022050014, 2022050015 2022090006, & 2022090007.
Feb 11, 2016
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain model year 2009-2010 ML320 BlueTec 4Matic, GL320 BlueTec 4Matic and R320 CDI 4Matic, 2011 E350 Cabriolet and E550 Cabriolet, 2009-2011 ML350, ML350 4Matic, ML550 4Matic, ML63 AMG, and C63 AMG, 2010-2011 ML450 4Matic Hybrid, E350 Coupe, E350 4Matic, E550 Coupe, E550 4Matic, and E63 AMG, 2011-2012 GL350 BlueTec 4Matic and R350 BlueTec 4Matic, 2009-2012 GL450 4Matic, GL550 4Matic and R350 4Matic, 2007-2008 SLK280, SLK350, and SLK55 AMG, 2011-2014 SLS AMG Coupe, 2012 SLS AMG Cabriolet, 2013-2014 SLS AMG GT and SLS AMG GT Cabriolet, 2005 C230 Kompressor and C320, 2006-2007 C230, 2006-2011 C350, 2008-2011 C300 and C300 4Matic, 2010-2012 GLK350 and GLK350 4Matic and 2007-2008 Chrysler Crossfire vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: MBUSA will their notify owners, and Fiat Chrysler will notify the affected Chrysler owners. Dealers for the respective brands will replace the driver's frontal air bag module, free of charge. This recall began November 2016. Mercedes-Benz owners may contact MBUSA customer service at 1-800-367-6372 and Chrysler owners may contact Fiat Chrysler customer service at 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration