IllustrationFUEL SMELL COMING FROM LEFT REAR FUEL SENDING UNIT LEAKING
2003 Mercedes Benz E320
Owner reports · Recalls · Investigations
More warning signs than most E320 years
Owner complaints for the 2003 Mercedes Benz E320 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all E320 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
1125–50K
2450–75K
3375–100K
58100–150K
24150K+
162 reports with mileage · 52 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports1 fire reports8 injury reports
What owners actually said
214 reportsTHE AIR STRUT SUSPENSION HAS FAILED ON LEFT AND RIGHT FRONT
I PUSHED THE REMOTE BUTTON ON THE KEY FOB TO UNLOCK THE CAR AND THE LEFT REAR DOOR POPPED OPEN , NOW I CANNOT CLOSE THE DOOR. THE LOCK WILL NOT CATCH TO CLOSE THE DOOR. HAD TO TIE THE DOOR SHUT WITH THE SEATBELT TO DRIVE IT HOME. I'M BEING TOLD THAT THE DOOR LOCK JUST ALL OF A SUDDEN WENT BAD , IT COULD HAVE HAPPEN WHILE DRIVI…
Read full complaint
I PUSHED THE REMOTE BUTTON ON THE KEY FOB TO UNLOCK THE CAR AND THE LEFT REAR DOOR POPPED OPEN , NOW I CANNOT CLOSE THE DOOR. THE LOCK WILL NOT CATCH TO CLOSE THE DOOR. HAD TO TIE THE DOOR SHUT WITH THE SEATBELT TO DRIVE IT HOME. I'M BEING TOLD THAT THE DOOR LOCK JUST ALL OF A SUDDEN WENT BAD , IT COULD HAVE HAPPEN WHILE DRIVING. THE LOCK HAS TO BE REPLACED , COST ...OVER $500 IT SEEMS STRANGE TO ME THAT THIS PART IS SO OVERPRICED COMPARED TO OTHER MODELS. IT HAS TO BE A DEFECT THAT MERCEDES IS WELL AWARE OF. I'M GLAD I WASN'T IN MOTION WHEN IT HAPPEN . I FEEL THIS SHOULD BE A RECALL.
TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ E320. THE CONTACT STATED THAT A STRONG FUEL ODOR WAS PRESENT IN AND AROUND THE VEHICLE. THE CONTACT ALSO MENTIONED THAT THE FAILURE OCCURRED WHEN THE VEHICLE WAS FUELED. THE FAILURE WAS PERSISTENT. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (LOKEY MERCEDES-BENZ, 19820 US HWY 19 N, CLEARWATE…
Read full complaint
TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ E320. THE CONTACT STATED THAT A STRONG FUEL ODOR WAS PRESENT IN AND AROUND THE VEHICLE. THE CONTACT ALSO MENTIONED THAT THE FAILURE OCCURRED WHEN THE VEHICLE WAS FUELED. THE FAILURE WAS PERSISTENT. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (LOKEY MERCEDES-BENZ, 19820 US HWY 19 N, CLEARWATER, FL 33764) WHERE IT WAS DIAGNOSED THAT THE FUEL TANK, FUEL LINES, AND EXHAUST SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE FUEL TANK AND FUEL LINES WOULD BE COVERED UNDER AN EXTENDED WARRANTY. ANY ADDITIONAL PARTS OR LABOR WOULD BE AT THE CONTACT'S EXPENSE. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000.
I PURCHASED MY CURRENT VEHICLE 18 MONTHS AGO USED. THIS WEEKEND THE GIANT STOP LIGHT CAME ON ASKING ME TO TAKE THE CAR INTO THE DEALERSHIP DUE TO DEFECTIVE BRAKES. IT TURNS OUT IT'S THE SBC PUMP WHICH WAS RECALLED BY MERCEDES BENZ. EXCEPT, BENZ WILL NOT REPAIR IT AS IT'S A 2003 AND OUT OF THEIR 10 YEAR RULE. IT'S A $2100 I CANNO…
Read full complaint
I PURCHASED MY CURRENT VEHICLE 18 MONTHS AGO USED. THIS WEEKEND THE GIANT STOP LIGHT CAME ON ASKING ME TO TAKE THE CAR INTO THE DEALERSHIP DUE TO DEFECTIVE BRAKES. IT TURNS OUT IT'S THE SBC PUMP WHICH WAS RECALLED BY MERCEDES BENZ. EXCEPT, BENZ WILL NOT REPAIR IT AS IT'S A 2003 AND OUT OF THEIR 10 YEAR RULE. IT'S A $2100 I CANNOT AFFORD AND CANNOT SELL VEHICLE WITH THIS ISSUE AS I FEAR IT MAY CAUSE HARM TO OTHERS. A FRIEND SUGGESTED I ASK FOR NHTSA'S HELP AS BENZ IS UNWILLING TO STAND BY THE RECALL AND REPAIR THE SAFETY ISSUE.
MY CAR HAVE A STRONG SMELL A GASOLINE ON THE BACK SEAT EVERY TIME IM REFUELING. SOME TIMES I HAVE TO OPEN ALL THE WINDOWS SO THE SMELL GOES AWAY. AND SOME TIMES A GET THE MESSAGE CHECK FILLER CAP BUT AL READY CHANGE THE FILLER CAP AND THE MESSAGE STILL SOME TIMES APPEAR.
SMELLS GASOLINE WHEN CAR IS PARKED IN GARAGE AND SOMETIMES WHEN DRIVING SMEELS GASOLINE IN CABIN..SRS RESTRAINTS MALFUNCTION LIGHTS KEEPS COMING ON.
BRAKES SEEEMED TO WORKING FINE AND OUT OF NO WHERE AT 65MPH A RED NOTIFICATION CAME ON THE DASH SAYING "REDUCED BRAKING EFFECT/LONGER STOPPING DISTANCE VISIT WORKSHOP". MERCEDES IS AWARE OF THIS BECAUSE THEY EXTENDED THE WARRANTY ON THE SBC UNIT THE IS NEEDED TO SAFELY OPERATE THE CAR BUT DIDN'T DO A RECALL AND EVENTUALLY STOPPE…
Read full complaint
BRAKES SEEEMED TO WORKING FINE AND OUT OF NO WHERE AT 65MPH A RED NOTIFICATION CAME ON THE DASH SAYING "REDUCED BRAKING EFFECT/LONGER STOPPING DISTANCE VISIT WORKSHOP". MERCEDES IS AWARE OF THIS BECAUSE THEY EXTENDED THE WARRANTY ON THE SBC UNIT THE IS NEEDED TO SAFELY OPERATE THE CAR BUT DIDN'T DO A RECALL AND EVENTUALLY STOPPED INSTALLING THIS PART IN THE MODELS. IF THE VEHICLE IS 10 YEARS OLD PLAN TO SHELL OUT THOUSANDS SINCE THE PART ISN'T COVERED AND IT IS UNSAFE TO DRIVE BECAUSE YOUR BRAKES MAY GO AT ANY TIME. I HAVE 96K ON MY VEHICLE AND BECAUSE IT IS OVER 10 YEARS OLD THE FAULTY PART THAT THE MANUFACTURER KNEW ABOUT IS NOT COVERED. THE PART IS DESIGNED TO MALFUNCTION AT 300,000 COMPRESSIONS AND THIS CAN HAPPEN AT ANY TIME. THIS IS UNSAFE AND SHOULD BE RECALLED! I HOPE SOMEONE DOESN'T HAVE TO DIE FOR BENZ TO DO SOMETHING ABOUT IT!
MERCEDES DEALER SAYS THAT MY VIN NUMBER IS NOT UNDER THIS RECALL. I BOUGHT THE CAR ON JULY 31,2009 AND THE RECALL FOR THE BRAKE PUMP CAME OUT IN OCTOBER 2009. I HAVE HAD THE CAR SERVICED AT THE SAME MERCEDES DEALER FOR 8 YEARS AND THEY HAVE NEVER TOLD ME ABOUT ANY RECALL. IS MY CAR COVERED UNDER THIS RECALL. I UNDERSTAND THERE I…
Read full complaint
MERCEDES DEALER SAYS THAT MY VIN NUMBER IS NOT UNDER THIS RECALL. I BOUGHT THE CAR ON JULY 31,2009 AND THE RECALL FOR THE BRAKE PUMP CAME OUT IN OCTOBER 2009. I HAVE HAD THE CAR SERVICED AT THE SAME MERCEDES DEALER FOR 8 YEARS AND THEY HAVE NEVER TOLD ME ABOUT ANY RECALL. IS MY CAR COVERED UNDER THIS RECALL. I UNDERSTAND THERE IS A 10 YEARS LIMIT ON THE RECALL AND MERCEDES HAS BEEN REGULARLY SERVICING MY CAR SINCE YEAR 6 TO YEAR 10 I.E. @009 TO 2013 AND THEY HAVE NEVER MENTIONED ANY RECALLS IN ANY OF THE TIMES I HAVE HAD THE CAR SERVICED SINCE JULY 31, 2009.
MY HUSBAND WAS DRIVING THE CAR WITH MY 10 YEAR OLD SON ON I276 AT 55MPH WHEN THE BRAKES FAILED. LUCKILY ENOUGH THERE WAS NO CAR IN FRONT OF THEM AND SINCE THEY WERE ON A HIGHWAY HE HAD TIME TO STOP WITHOUT CAUSING AN ACCIDENT OR CRUSHING. WE TOWED THE CAR TO THE MERCEDES DEALERSHIP AND WE WERE TOLD THAT SBC FAILED AND WE HAVE TO…
Read full complaint
MY HUSBAND WAS DRIVING THE CAR WITH MY 10 YEAR OLD SON ON I276 AT 55MPH WHEN THE BRAKES FAILED. LUCKILY ENOUGH THERE WAS NO CAR IN FRONT OF THEM AND SINCE THEY WERE ON A HIGHWAY HE HAD TIME TO STOP WITHOUT CAUSING AN ACCIDENT OR CRUSHING. WE TOWED THE CAR TO THE MERCEDES DEALERSHIP AND WE WERE TOLD THAT SBC FAILED AND WE HAVE TO PAY $2000. HAD THE CAR TOWED TO MERCEDES BENZ OF FORT WASHINGTON IN FORT WASHINGTON, PA. THE DEALER EXAMINED THE VEHICLE AND SAID THE SBC UNIT HAS TO BE REPLACED AND THE COST IS $2000. I DID SOME RESEARCH AND IT APPEARS THAT I WAS NOT THE ONLY CUSTOMER WITH THIS MAJOR SAFETY PROBLEM. THIS UNIT FAILED ON MANY CUSTOMERS AND APPARENTLY THERE WAS AN EXTENDED WARRANTY OFFERED UP TO 10 YEARS. I HAVE TO SAY THAT I WAS VERY DISAPPOINTED THAT MERCEDES NEVER NOTIFIED ITS CUSTOMERS OF THIS SITUATION. THE DEALER NEVER NOTIFIED ME OF THIS POTENTIAL PROBLEM AND THEY EXPECT ME TO PAY THE REPAIR COST FOR A SAFETY ISSUE THAT SHOULD HAVE BEEN ADDRESSED?? TO MAKE MATTERS WORSE, AFTER I REACHED OUT TO MERCEDES-BENZ USA, I WAS TOLD THAT THE PART WOULD HAVE BEEN COVERED UNDER THE 10 YEAR TERM ONLY IF IT FAILED WHICH IS AN APPALLING STATEMENT. SO I WOULD HAVE TO CRASH BEFORE THE PART IS REPLACED?? THIS IS THE ABSOLUTELY MOST RIDICULOUS THING I HAVE EVER HEARD FROM A CAR MANUFACTURER. I HAVE ASKED THE REPRESENTATIVE FOR HIS MANAGER'S CONTACT INFORMATION AND HE REFUSED TO PROVIDE IT. THE SBC UNIT SHOULD BE COVERED AT NO EXPENSE TO THE CONSUMER BECAUSE IT WAS KNOWN FAULTY SAFETY ISSUE. *TR
Official recalls
224V874000 · Visibility:sun/moon Roof Assembly
Nov 19, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
19V918000 · Visibility:sun/moon Roof Assembly
Dec 20, 2019
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA13003 · Fuel Leakage From The Fuel Tank
Opened Mar 15, 2013 · Closed Dec 19, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Additional source detail variants (6)
Fuel System, Gasoline:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un