IllustrationAfter fueling up, a smell of gas occurs. Slight gas puddle forms under the car after every fuel up. Drops gas gauge down and after that no more smell of fuel but still slight puddle of gas after leaving the car parked. Noticed it about a month ago and it seems to get worse. Doesn't seem safe knowing the car is leaking fuel.
2003 Mercedes Benz E320
Owner reports · Recalls · Investigations
More warning signs than most E320 years
Owner complaints for the 2003 Mercedes Benz E320 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all E320 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
1125–50K
2450–75K
3375–100K
58100–150K
24150K+
162 reports with mileage · 52 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports1 fire reports8 injury reports
What owners actually said
214 reportsDEALERSHIP FAILED TO FIX AND INSPECT MY SBC PUMP WHICH LEAD TO MY VEHICLE BEING TOTALED AND LOSING ESP.
WHEN MY WINDOWS ARE DOWN AND IM DRIVING YOU CAN SMELL GASOLINE VERY STRONGLY IN THE CAR. EVEN WORSE IN THE BACK SEAT AREA. ESPECIALLY IF MY GAS TANK IS FILLED. IM CONSTANTLY GETTING A WARNING TO CHECK THE GAS CAP AND THE GAS LIGHT GOES OFF FLASHING THEN MY CHECK ENGINE LIGHT WILL GO ON.
TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ E320. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE CONTACT HIT A POT HOLE WHICH CAUSED THE PASSENGER'S SIDE FRONTAL AIR BAG TO DEPLOY WITHOUT WARNING. THE VEHICLE WAS DRIVEN TO THE RESIDENCE. THE CONTACT SPOKE WITH MERCEDES-BENZ OF ATLANTA SOUTH (3775 ROYAL S PKWY, ATLANTA, GA 30…
Read full complaint
TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ E320. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE CONTACT HIT A POT HOLE WHICH CAUSED THE PASSENGER'S SIDE FRONTAL AIR BAG TO DEPLOY WITHOUT WARNING. THE VEHICLE WAS DRIVEN TO THE RESIDENCE. THE CONTACT SPOKE WITH MERCEDES-BENZ OF ATLANTA SOUTH (3775 ROYAL S PKWY, ATLANTA, GA 30349) AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN AN AIR BAG RECALL. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE AND OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN. *BF CONSUMER STATED SINCE THE INCIDENT, MANUFACTURE SENT A LETTER STATING THERE WAS A RECALL WITH THE AIRBAGS.*JB
TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ E320. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE SUN ROOF GLASS DETACHED FROM THE VEHICLE. AN UNKNOWN DEALER WAS CONTACTED AND THE CONTACT WAS QUOTED A COST TO REPLACE THE GLASS PORTION OF THE SUN ROOF. THE SUN ROOF GLASS WAS REPLACED BY AN INDEPENDENT MECHANIC. T…
Read full complaint
TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ E320. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE SUN ROOF GLASS DETACHED FROM THE VEHICLE. AN UNKNOWN DEALER WAS CONTACTED AND THE CONTACT WAS QUOTED A COST TO REPLACE THE GLASS PORTION OF THE SUN ROOF. THE SUN ROOF GLASS WAS REPLACED BY AN INDEPENDENT MECHANIC. THE VEHICLE WAS REPAIRED HOWEVER, THE SUN ROOF WAS NO LONGER OPERABLE. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.
FUEL SMELL COMING FROM WITHIN CABIN FIRST NOTICED OCTOBER 2018 TOLD IT WAS PROBABLY WAS CHARCOAL FILTER NOT A BIG DEAL WHEN FILLING TANK WITH FUEL IT SOMETIMES HAPPENS, AND WAS RECENTLY NOTICED WHEN TIRES WHERE CHANGED THAT FUEL SMELL AND LOOKED LIKE LEAKAGE OF GAS. WAS TOLD THIS WAS A KNOWN DEFECT AND AS THE SECOND OWNER WAS NE…
Read full complaint
FUEL SMELL COMING FROM WITHIN CABIN FIRST NOTICED OCTOBER 2018 TOLD IT WAS PROBABLY WAS CHARCOAL FILTER NOT A BIG DEAL WHEN FILLING TANK WITH FUEL IT SOMETIMES HAPPENS, AND WAS RECENTLY NOTICED WHEN TIRES WHERE CHANGED THAT FUEL SMELL AND LOOKED LIKE LEAKAGE OF GAS. WAS TOLD THIS WAS A KNOWN DEFECT AND AS THE SECOND OWNER WAS NEVER INFORMED IN ANY CAPACITY. THIS IS A SAFETY CONCERN WHICH IN MY OPINION IF THEY KNEW, ALL OWNERS SHOULD HAVE BEEN NOTIFIED ASAP. I AM NOT SURE WHAT I CAN DO, OR CAN BE DONE, BUT THIS IS CERTAINLY NOT ACCEPTABLE IF IT IS A KNOWN DEFECT. THIS WAS NOTICED WHEN VEHICLE WAS NOT MOVING. I WANT THE AMERICAN PUBLIC TO KNOW, WE MAY HAVE OTHERS OUT THEIR WITH THE SAME PROBLEM NOT KNOWING THIS. WHAT A SHAME FOR MERCEDES IF THEY HAVE NOT CONTACTED PEOPLE. I STARTED REVIEWING WHAT I COULD FIND ON WEB SITES, ATTACHED IS A NHTSA DOCUMENT.
WHEN FILLING FUEL TANK VERY STRONG SMELL OF GAS INSIDE OF CAR AND OUTSIDE. WHEN TO MERCEDES DEALERSHIP AND EXPLAINED THE FAULT AND THEY WANTED $5000 TO CORRECT ISSUE.FOUND OUT THERE WAS A SAFETY RECALL ON THIS ISSUE, AND THEY REFUSED TO EXPEDITE AS THEY SAID IT WAS FOR 15 YEARS AND THAT HAD EXPIRED. NO RECALL NOTICES HAD BEEN SE…
Read full complaint
WHEN FILLING FUEL TANK VERY STRONG SMELL OF GAS INSIDE OF CAR AND OUTSIDE. WHEN TO MERCEDES DEALERSHIP AND EXPLAINED THE FAULT AND THEY WANTED $5000 TO CORRECT ISSUE.FOUND OUT THERE WAS A SAFETY RECALL ON THIS ISSUE, AND THEY REFUSED TO EXPEDITE AS THEY SAID IT WAS FOR 15 YEARS AND THAT HAD EXPIRED. NO RECALL NOTICES HAD BEEN SENT TO ME OR THE PREVIOUS OWNER.I HAVE HAD CAR FOR 4 YEARS, PREVIOS OWNER HAD IT FOR 6.CONTACTED HEAD OFFICE IN ATLANTA STILL WOULD NOT COVER THE ISSUE
TL* THE CONTACT OWNS A 2003 MERCEDES BENZ E-320. THE CONTACT STATED THE BRAKES AND SPC WARNING LIGHT WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE BRAKES AND SENSORS WERE REPLACED HOWEVER, THE FAILURE RECURRED. WHILE DRIVING AT 35 MPH THE BRAKE PEDAL WAS DEPRESSED HOWEVER BUT FAILED TO SLOW AND STO…
Read full complaint
TL* THE CONTACT OWNS A 2003 MERCEDES BENZ E-320. THE CONTACT STATED THE BRAKES AND SPC WARNING LIGHT WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE BRAKES AND SENSORS WERE REPLACED HOWEVER, THE FAILURE RECURRED. WHILE DRIVING AT 35 MPH THE BRAKE PEDAL WAS DEPRESSED HOWEVER BUT FAILED TO SLOW AND STOP THE VEHICLE AS DESIGNED. THE CONTACT USED THE PARKING BRAKE TO STOP THE VEHICLE. ADDITIONALLY, THE BRAKE PEDAL FLUCTUATED. THE VEHICLE WAS TAKEN TO W.I. SIMONSON MERCEDES-BENZ (1626 WILSHIRE BLVD, SANTA MONICA, CA 90403 (855) 677-2690), WHERE IT WAS DIAGNOSED THAT THE SPC RESERVOIR WAS DEFECTIVE, AND HYDRAULIC UNIT ALSO NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED NOR INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 216,722.
I HAVE A 2003 E320 MERCEDES BENZ WITH SBC BRAKE SYSTEM. THE COMPANY HAS ADMITTED HAVING ISSUES WITH THE SYSTEM AND HAS EXTENDED THE WARRANTY TO 25 YEARS ON THE SBC PUMP. MY CAR HAS ON ABOUT 4 OR 5 INCIDENTS GAVE ME A RED WARNING ON MY DASH TO STOP THE VEHICLE AND SEE WORKSHOP. EACH TIME THIS HAPPENS MY BRAKING ABILITY IS SIGNIFI…
Read full complaint
I HAVE A 2003 E320 MERCEDES BENZ WITH SBC BRAKE SYSTEM. THE COMPANY HAS ADMITTED HAVING ISSUES WITH THE SYSTEM AND HAS EXTENDED THE WARRANTY TO 25 YEARS ON THE SBC PUMP. MY CAR HAS ON ABOUT 4 OR 5 INCIDENTS GAVE ME A RED WARNING ON MY DASH TO STOP THE VEHICLE AND SEE WORKSHOP. EACH TIME THIS HAPPENS MY BRAKING ABILITY IS SIGNIFICANTLY REDUCED TO THE POINT OF NEEDING A LOT OF DISTANCE TO STOP. I HAVE HAD THE BRAKE SYSTEM FLUSHED, THAT WORKED FOR A WHILE. AROUND JANUARY OF 2018 THE DEALER UPDATED SOME KIND OF SOFTWARE PACKAGE. JANUARY 2020 THE BRAKE ISSUE HAPPEN AGAIN. I AM BEING TOLD THAT UNLESS A CERTAIN DEFAULT CODE IS INDICATED THEY CANNOT REPLACE THE PUMP. I TOLD MERCEDES CUSTOMER SERVICE THAT HOW WILL I KNOW THAT THE NEXT TIME MY BRAKING IS REDUCED WILL BE MY LAST TIME THAT WILL CAUSE DEATH OR PROPERTY DAMAGE TO OTHER DRIVERS OR MY SELF BEFORE THIS DEFAULT CODE COMES UP, A CODE NO ONE WILL TELL ME WHAT IT IS. I WAS TOLD THAT THEY UNDERSTOOD MY CONCERN BUT UNTIL THIS DEFAULT CODE COMES UP THEY CANNOT REPLACE THE SBC . I FIND THAT STATEMENT TO BE NOT CONSIDER OF LIFE AND PROPERTY DAMAGE ON OUR NATIONAL HIGHWAYS
DEALER CLAIMS MB HAS NO RECALL ON THIS CAR EVEN THOUGH NHTSA HAS A RECALL NUMBER: 19V918 FOR GLASS PANEL DETACHING FROM VEHICLE. PLEASE ADVISE ME OF NEXT STEPS TO GET DEALER COMPLIANCE.
Official recalls
224V874000 · Visibility:sun/moon Roof Assembly
Nov 19, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
19V918000 · Visibility:sun/moon Roof Assembly
Dec 20, 2019
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA13003 · Fuel Leakage From The Fuel Tank
Opened Mar 15, 2013 · Closed Dec 19, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Additional source detail variants (6)
Fuel System, Gasoline:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un