2018 Mazda CX-5

I purchased my CX-5 from Mazda dealership when new. The vehicle has been having coolant issues where the Electronically controlled thermostatic valve (ECTV) will open prematurely at 120°F instead of at higher temperatures. This all leads to higher fuel consumption, premature wear and tear on the engine, higher water condensation in the engine oil, poor engine and cabin air performance. I had it diagnosed at the Mazda dealership where I bought it from (Previously it was Sussman Mazda of Abington, now Fred Beans Mazda of Abington in PA) and they said the values are admissible by Mazda and not indicative of a problem. However, my vehicle cannot reach normal operating temperature of 198°F when driven for 50 miles at ambient 28°F for over an hour due to premature opening of the ECTV at lower temperatures. There are no codes showing up relating to the issue, therefore the dealership declined any repair works to be done.

We purchased our vehicle from Riley Mazda in September 2018. Shortly after reaching approximately 50,000 miles, we began to notice that the gauges would fluctuate, and there was a slight burning odor in the car cabin. We replaced the air filters for both the engine and cabin, as well as performed an engine oil change. In October, we had a brake flush done when we inquired about the burning smell coming from under the hood. Despite our concerns, the dealership was unable to identify any problems at that time. On a subsequent visit, we paid a diagnostic fee of $220.00. It was during this visit that the dealership discovered an issue with the engine. The newly identified problems will significantly impair the vehicle's performance and decrease its value. Additionally, we anticipate needing future repairs, which could pose serious safety hazards.

The cylinder head on my 2018 Mazda CX-5 developed cracks on the exhaust side, leading to significant oil leakage onto the exhaust manifold. This has caused engine damage and safety concerns. The vehicle is currently at a Mazda dealership, where the issue has been inspected and documented. The component is available for further inspection upon request. The oil leaking onto the exhaust manifold creates a serious fire hazard due to the high heat generated in this area. Additionally, the vehicle experienced burning smells and visible smoke coming through the air vents, which could impair visibility or cause distraction while driving. These conditions place the safety of myself, my passengers, and others on the road at risk. The issue has been confirmed by a Mazda dealership. They provided a video showing oil actively dripping from the cracked cylinder head and stated that the engine requires a full replacement. Mazda dealership video: [XXX] This video contains the engine inspection findings conducted at the dealership during my recent visit. It clearly shows the damage and highlights the issues identified. The vehicle has been inspected by the Mazda dealership service team, who identified the cracks in the cylinder head and documented the oil leakage and related engine damage. There were no warning lamps or messages on the dashboard prior to the failure. The symptoms began with a noticeable burning smell inside the cabin, followed by a slight mist coming out of the air vents and smoke from under the hood. Oil leakage was later observed on the ground, and the coolant level appeared empty. I’ve received a video inspection of my vehicle from the service center on March 7, 2024 with no concerns at that time, which you can view here: [XXX] . This link leads to TruVideo, a platform that many dealerships use to share service videos with customers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This car has a confirmed cracked cylinder head and is leaking oil. This is a known issue and there is a TSB out for it. It happened at $62500 miles and is just outside of the warranty. This has happened to several of these cars. Mazda is not doing "good will" to repair them and there is not yet a recall which there should be. The car suddenly started leaking oil and smoking/burning. It is unsafe and a defective cylinder head. Mazda should be taking responsibility for this

2018 mazda started smoking from under hood and noticed a burning oil smell. Took to mechanic and was told engine head gasket has a huge Crack. Car only has 22k on it and never been in any accident. All appropriate preventative services are up to date. There was no indication light no warning light nothing to identify why the car was leaking oil and smoking until it was looked at. This has multiple.complaints in regards to this specific year and model and needs to be addresses before someone's car catches fire or stalls in the middle of highway

Noticed a burning oil smell coming from the car along with leaking oil in the driveway. Vehicle has 53000 miles on it and was 3 months out of powertrain warranty but still under the 60000 mileage cap. Local Mazda dealership came back saying that it was a "SA-037/23 Oil leak at cylinder head, cylinder head replacement with parts kit" and quoted $5100 to repair. Dealership stated that the vehicle was unsafe to operate. There were no dash indicator lights or symptoms of overheating to indicate that there was a problem outside of the smell. After the diagnosis was made, we researched and found that this was a commonly reported problem for this model year

Noticed an oil smell when driving the vehicle, slightly premature to when it was due for an oil change. Engine was emitting light blue smoke when parked after driving for more than 20 minutes. Took the car to a Mazda dealership to get serviced two days after noticing the issue and was told that the cylinder head was cracked and needed to be replaced. There was oil leaking from the vehicle, which I had not noticed, and it had soaked a lot of the front undercarriage of the car. Research into the effects of an oil leak indicate that it can cause a serious malfunction of the engine and other components of the car, but I did not experience that in the time of noticing the problem and taking the vehicle to get serviced. The problem was diagnosed by the service department at a Mazda dealership and is being repaired there. The oil indicator came on a day after noticing the smell.