2014 Mazda CX-5

WITHIN A MONTH OF PURCHASING THIS NEW VEHICLE, A FOOT-LONG VERTICAL CRACK IN THE WINDSHIELD DEVELOPED FROM THE SENSOR BOX DOWNWARDS. (AND SPREAD EXTRAORDINARILY QUICKLY FROM THERE.) I WAS DENIED REPLACEMENT BY THE DEALER BECAUSE THEY CLAIMED THERE WAS A CHIP IN THE WINDSHIELD CAUSED BY A SMALL ROCK, THOUGH I DON'T RECALL HITTING ONE. *TR

I HAVE OWNED MY 2014 CX-5 FOR LESS THAN FIVE MONTHS AND HAVE HAD TO REPLACE MY WINDSHIELD TWO TIMES ALREADY DUE TO "CHIPS" IN THE WINDSHIELD. I HAVE ALSO HAD TO HAVE A CHIP REPLACED AS WELL. THE FIST OCCURRENCE IS WHEN A LARGE CRACK APPEARED IN MY WINDSHIELD AFTER BEING PARKED IN MY PARENTS DRIVEWAY. THE CRACK STARTED FROM THE LEFT SIDE OF THE WINDSHIELD AND ACROSS MEASURING APPROXIMATELY 12 INCHES IN LENGTH. I IMMEDIATELY CALLED THE DEALERSHIP WHERE I PURCHASED THE CAR AND SCHEDULED AN APPOINTMENT. THE SERVICE MANAGER PERFORMED THE "PEN TEST" AND INFORMED ME THAT THE DAMAGE WAS DUE TO A CHIP FROM DEBRIS. I STATED THE CAR WAS PARKED IN A DRIVEWAY AND THERE TO THE NAKED EYE THERE WAS NO CHIP MARK WHATSOEVER. NEEDLESS TO SAY THEY DID NOT COVER IT AND I PROCEEDED WITH A CLAIM TO MY INSURANCE. THEN JUST LAST WEEK I HAD ANOTHER CHIP OCCUR IN THE WINDSHIELD WHICH WAS REPAIRED BY SAFELITE AUTO GLASS. NOW JUST THIS PAST SUNDAY I AM DRIVING ON THE FREEWAY AND HEAR A LOUD POP SOUND. NEXT THING I NOTICE IS A COMMA LIKE CRACK IN MY WINDSHIELD. IN LESS THAN ONE HOUR, THE CRACK HAD SPREAD UP AND ACROSS THE WINDSHIELD BEYOND YOUR TYPICAL CHIP REPAIR. SO AGAIN TODAY I JUST HAD MY SECOND WINDSHIELD INSTALLED IN LESS THAN FIVE MONTHS! MY CONCERN IS NOT ONLY THE QUALITY OF THE CX-5 WINDSHIELDS BUT THE SAFETY OF THE CAR FOR NOT ONLY MYSELF BUT MY FAMILY AT THIS POINT. WITH ALL THE OTHER COMPLAINTS LISTED ON THIS WEBSITE AND OTHER SITES, WHY ISN'T ANYTHING BEING DONE TO INVESTIGATE THIS SERIOUS ISSUE WITH MAZDA AND THEIR WINDSHIELDS? HOW MANY MORE COMPLAINTS WILL IT TAKE BEFORE AN INVESTIGATION IS STARTED? AS A FIRST TIME MAZDA OWNER I AM CONCERNED IF I WILL MAKE IT THROUGH THE FIRST YEAR WITHOUT ANOTHER WINDSHIELD REPLACEMENT. I AM ALSO EQUALLY CONCERNED HOW LONG MY INSURANCE COMPANY WILL CONTINUE TO PAY FOR THEM AS WELL. *TR

UPON ENTERING THE VEHICLE AND STARTING CAR IN THE MORNING, WE HEARD A "POP" AND SAW A CRACK SHOOT DOWN FROM THE TOP CENTER OF SEAL DOWN TO MIDDLE OF SMART BRAKING SYSTEM UNIT BEHIND REAR-VIEW MIRROR. THERE, IT STARTS AN S-LIKE SERPENTINE PATH THAT ENDS UP IN THE DRIVERS FIELD OF VIEW. THERE IS NO VISIBLE CHIP ALONG THE PATH OF THE CRACK.THE VEHICLE WAS NOT IN MOTION AND WE WITNESSED THE CRACK OCCUR. THE MAZDA SERVICE MGR SAYS IT'S DUE TO ROAD DEBRIS HIT, BUT THERE IS NO VISIBLE CHIP. HIS "PEN" TEST SIMPLY HIT A MINUTE FRAGMENT THAT WAS POPPED OUT DUE TO THE GLASS CRACKING ITSELF, NOT FROM A DEBRIS HIT. I HAD A SAFELITE TECHNICIAN INSPECT IT AND THEY CONCLUDE IT WAS NOT CAUSED BY A DEBRIS HIT. IMO, THIS IS CLEARLY A MANUFACTURER'S DEFECT THAT MAZDA SHOULD BE ADDRESSING CONSIDERING THERE ARE MANY OTHER COMPLAINTS WITH THE EXACT SAME PROBLEM BOTH HERE AND IN OTHER INTERNET FORUMS. *TR

DRIVING ON A GRAVEL ROAD AT LOW SPEED WHEN A PIECE OF DEBRIS KICKED UP FROM AN ONCOMING VEHICLE (ALSO ABOUT 25 MPH) CRACKED THE WINDSHIELD. A STARBURST APPEARED, APPROXIMATELY THE DIAMETER FOR A US PENNY. APPROXIMATELY TWO HOURS LATER, THE CRACK SUDDENLY BURST TO BEING 14-15" LONG AND DRAMATICALLY AFFECTING DRIVER VISIBILITY. I HAVE NEVER HAD A WINDSHIELD SUDDENLY POP LIKE THAT FROM A ROCK CHIP. *TR

LESS THAN A COUPLE OF MONTHS AGO I WAS DRIVING AND A ROCK OR SOMETHING HIT THE CORNER OF THE WINDSHIELD (SOUNDED LITTLE I MIGHT ADD ) A LINE THAT LOOKED LIKE MILK STARTED MOVING ACROSS MY LINE OF VIEW. IT CRACKED ABOUT A 1/2 OF A FOOT LATER IN THE DAY IT EXTENDED TO ABOUT A FOOT AND A HALF. . AGAIN JUST A FEW DAYS AGO (CAR IS 1YEAR 1 MO OLD) THE SAME THING HAPPENED! IT SOUNDED LIKE A SMALL PEBBLE THAT HIT THE WINDSHIELD AND YET IT MANAGED TO CRACK 1/2 FOOT ONLY THIS TIME ON THE OPPOSITE SIDE. I'VE BEEN DRIVING FOR OVER 30 YEARS AND I'VE NEVER HAD THIS HAPPEN ESPECIALLY TWO TIMES WITHIN ONE YEAR YOU WOULD THINK TO CRACK A WINDSHIELD LIKE THAT, IT WOULD TAKE A HARD-HIT. NOT ONLY THAT ..BUT THE FIRST THREE OF FOUR MONTHS I HAD THE CAR TWO CHIPS WERE NOTICED AT THE CAR WASH NEAR THE TOP. I HAD TO CHECK FOR MYSELF I DIDN'T BELIEVE IT. *TR

WITHIN THE FIRST 5 DAYS AFTER PURCHASING THIS VEHICLE A SMALL CRACK APPEARED IN THE LOWER LEFT (DRIVER) SIDE OF THE WINDSHIELD WHICH, BEFORE WE GOT HOME, HAD STRETCHED ACROSS THREE QUARTERS OF THE ENTIRE WIDTH OF THE GLASS. IN ORDER TO REGISTER THE VEHICLE WITH THE US DEPARTMENT OF DEFENSE TO ACCESS MILITARY INSTALLATIONS, WE HAD TO HAVE THE WINDSHIELD REPLACED TO COMPETITION WITH SAFETY STANDARDS. WITHIN FIVE DAYS OF REPLACING THE WINDSHIELD, ANOTHER CRACK FORMED IN THE SAME PLACE AND EXTENDED INTO THE FIELD OF VIEW OF THE DRIVER. *TR

ONE YEAR AND ONE MONTH AFTER PURCHASE OF MY CX-5, THE WINDSHIELD BEGAN TO CRACK DOWN THE DIRECT CENTER OF THE WINDSHIELD, IN LINE WITH THE RAIN SENSOR AND REAR VIEW MIRROR, TO THE CENTER OF THE WINDSHIELD. OVER THE NEXT WEEK, AS I DISCUSSED TERMS WITH INSURANCE AND MAZDA DEALERSHIP TO UNDERSTAND IF WINDSHIELD REPLACEMENT WAS UNDER WARRANTY, THE CRACK GREW IN A J RETREATING BACK TO THE TOP OF THE WINDSHIELD. IN LENGTH, THE CRACK EXTENDS BETWEEN 10 AND 20 INCHES AT THIS POINT IN TIME AND TECHNICIANS AT SAFELIGHT REPAIR HAVE ENCOURAGED ME TO CONTACT MAZDA REGARDING THIS STRESS FRACTURE THAT DID NOT OCCUR WHILE THE VEHICLE WAS MOVING. THE VALUE OF REPLACEMENT HAS BEEN ESTIMATED TO BE $800 BY TWO SALES REPRESENTATIVES, INDICATING A HEAVY PRICE TO PAY FOR A PART REPLACEMENT ON A LESS THAN 1 YEAR OLD VEHICLE. PLEASE HELP REDUCE THE COST OF THIS REPLACEMENT AND THE FUTURE REPLACEMENTS SHOULD THE STRESS FRACTURE HAPPEN AGAIN AS OTHER RESPONSES ON THE FORUM TESTIFY. THANK YOU. *TR

NOT EXACTLY SURE HOW THE WINDSHIELD CRACKED, BUT I WAS CLEANING UP THE CAR AND WENT INSIDE FOR A FEW MINUTES. WHEN I RETURNED I NOTICED TWO CRACKS COMING FROM THE TOP PART OF THE WINDSHIELD. THE CRACKS ARE ABOUT 12 INCHED LONG. IT WAS NOT A PARTICULARLY HOT DAY AND I HAD THE DOORS TO THE CAR OPEN MOST OF THE TIME. WE HAVE THE TOURING PACKAGE ON OUR CX-5 SO ITS A SPECIAL WINDSHIELD THAT NEEDS TO BE ORDERED, NOT A QUICK FIX. WE HAVE ABOUT 12,000 MILES ON THECAR. *TR