Power Train. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports0 fire reports1 injury reports

What owners actually said

33 reports

Mileage unknown · Aug 26, 2026

EnginePower TrainSuspension

Read full complaint

Hennessey Lincoln in Atlanta repaired my car in June 2026. My Torque converter needed to be replaced. My car was there over 20 days. Two weeks after getting it back from shop it started jerking and smoking. It needed another torque converter replacement. Two weeks after getting this car back it did the same thing again. I contacted Ford Warranty they did not help. Lincoln iin Michigan did not attempt to help. I couldn't even get the car in the shop for repair because of lack of employees that work on transmissions and no loaner cars.

NHTSA ODI #11759875

Mileage unknown · Jul 14, 2026

Power Train

I bought my 2020 Lincoln nautilus in February 2025 soon after I noticed a jerking from my lower gears,it has 80000 miles.i took it to the dealer I bought it from and they said the transmission is falling and will cost $10,188 to replace. They told me there was no recall and it wasn't covered under any warranty.

NHTSA ODI #11750212

Mileage unknown · Jul 14, 2026

Power Train

NHTSA ODI #11750211

Mileage unknown · Jul 6, 2026

EnginePower Train

My 2020 Lincoln Nautilus has an intermittent jerk during light acceleration with no diagnostic codes. This was confirmed when I had a professional mechanic drive it.

NHTSA ODI #11748671

Mileage unknown · Jun 30, 2026

EnginePower Train

While driving low speed between 1-55 mph my car feels like it’s stuttering, jerking or about to shut down.

NHTSA ODI #11747499

Mileage unknown · Apr 25, 2026

Unknown Or Other

REAR VIEW CAMERA REPLACEMENT IF REQUIRED AFTER DEALER EVALUATION

NHTSA ODI #11733790

Mileage unknown · Apr 16, 2026

Electrical SystemExterior Lighting

3rd brake light not working , they have had this issue over several years such as recall on 2025 (25C39) burnt diode in the LED Driver Modules and may cause other lighting failures

NHTSA ODI #11731491

Mileage unknown · Mar 16, 2026

WheelsCrashInjury

Read full complaint

1. Vehicle Purchase I purchased a 2020 Lincoln Nautilus Reserve from Carvana on February 2, 2026. The vehicle was delivered to me on February 8, 2026. The vehicle was represented as inspected and safe to drive. Within 20 days of ownership, the vehicle experienced a serious mechanical failure involving the wheel assembly. 2. Major Safety Failure While driving, the wheel assembly failed due to damaged or missing wheel studs, causing the wheel to detach/loosen from the vehicle. This created an extreme safety hazard and risk of serious injury or death. The vehicle became unsafe to operate. Evidence includes: Photographs of the wheel hub and broken/missing studs Mechanical inspection documentation 3. Inspection Findings A professional inspection revealed mechanical issues with the vehicle, including: Fuel filter failure Engine air filter failure Evidence of wheel stud damage Potential improper installation or pre-existing mechanical defect These issues indicate the vehicle was not properly inspected prior to sale, despite Carvana advertising a comprehensive inspection. 4. Warranty Claim Denied A claim was submitted to Carvana's warranty department. The claim was denied under the explanation of “outside influence.” However: The vehicle had only been in my possession 20 days There was no accident or outside event The failure appears to be due to pre-existing mechanical issues 5. Resulting Harm Because of this defect and Carvana's refusal to repair the vehicle: I am currently without reliable transportation I am still responsible for the loan payments on a defective vehicle I have experienced significant emotional distress and physical symptoms My physician has prescribed Parafon Forte (muscle relaxer) due to stress-related muscle pain. I have also experienced: Sleep disruption Anxiety about driving Financial hardship due to being unable to use the vehicle 6. Attempts to Resolve I have attempted to resolve this matter with Carvana by: Filing a warranty claim Contacting BBB

NHTSA ODI #11724795

Mileage unknown · Jan 12, 2026

Electrical SystemPower TrainService BrakesCrash

Read full complaint

MILEAGE: 487,615 27TAWD On [XXX] at [XXX]., the weather was wet from rain. I pushed the reverse button and the car accelerated quickly forward with engine revving. The car kept moving forward while the brake pedal was not responsive for at least 10 times as the car drove through my fence and damaged my neighbor’s garage. The car finally stopped when it hit the garage. Estimate for repairs on vehicle $1485.25. Estimate for damage to wooden fence $2560, neighbor's garage $8000. Engine code scan report on Oct 10, 2025 engine code U3003-16 Battery Voltage Below Threshold. EEC test at dealer on Oct 14, 2025: "no codes in any systems..." Vehicle damage noted. No indicated warning lamps INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11710373

Mileage unknown · Jan 6, 2026

Unknown Or Other

Read full complaint

Our 2020 Lincoln Nautilus with 60,000 miles will require replacement of the driver's door due to a crack in the door hinge area. This failure is similar to failures found in the Ford Edge and Lincoln Corsair of the same vintage. Online research proves this is a frequent failure due to inadequate door structural design in similar vehicles with as little as 30,000 miles usage. A 5 year old vehicle should not require door replacements due to a structural design especially when the design has proven to be faulty in other vehicles manufactured by Ford. Structural failure in this area can result in improper door closure and subsequent improper door opening resulting in possible occupant injuries.

NHTSA ODI #11709078

Official recalls

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

21V011000 · Power Train:driveline:driveshaft

Jan 15, 2021

Ford Motor Company (Ford) is recalling certain 2020-2021 Edge, 2020 Lincoln Nautilus and Ford Escape and 2021 Lincoln Corsair and Ford Bronco Sport vehicles. An inadequate amount of lubricant in the rear drive unit may cause seizure of the rear drive axle.

Consequence & remedy

Consequence: If the rear drive unit seizes, there may be a loss of drive and/or a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will check the rear drive unit lubricant level. Axles found to have lubricant at the minimum level will be filled to the full level. Axles found to be below the minimum lubricant fill level will be replaced, free of charge. This recall began March 12, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S02.

20V575000 · Back Over Prevention: Sensing System: Camera

Sep 23, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence & remedy

Consequence: Reduced rearward visibility can increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

20V550000 · Power Train:automatic Transmission

Sep 10, 2020

Ford Motor Company (Ford) is recalling certain 2019-2020 Edge, Transit Connect and Lincoln MKX and 2020 Escape and Lincoln Corsair vehicles. The start/stop accumulator endcap may have missing or loose bolts.

Consequence & remedy

Consequence: Missing or loose bolts on the start stop accumulator endcap could result in a transmission fluid leak and may progress to a loss of transmission function. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.

Remedy: Ford will notify owners, and dealers will replace the start/stop accumulator, free of charge. The recall began September 23, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S49.

20V414000 · Air Bags; Electrical System:wiring:interior/under Dash; Seats:front Assembly:power Adjust

Jul 17, 2020

Ford Motor Company, Inc. (Ford) is recalling certain 2016-2018 Lincoln MKX and 2019-2020 Nautilus vehicles equipped with 16-way electric tilt seats. The seat cushion frame edge may contact the wire harness when the seat occupant uses the tilt function of the seat, potentially damaging one or more wires within the harness, which can result in either inadvertent deployment of the air bag or nondeployment of the air bag in the event of a crash.

Consequence & remedy

Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.

Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.

Additional source detail variants (3)

Seats:front Assembly:power Adjust

Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.

Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.

Air Bags

Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.

Electrical System:wiring:interior/under Dash

Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ21002 · Rearview Camera Fmvss 111 Noncompliance

Opened Aug 3, 2021 · No close date supplied

Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera

On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.