MY VEHICLE HAS 2 DEFECTS WHICH I HAVE NOTICED ON NUMEROUS OTHER CARS LIKE MINE, EVEN LATER MODEL YEARS. THE HEADLIGHTS BECOME VERY DULL AND YELLOWED AFTER 3-4 YEARS, TO THE POINT THAT YOU HAVE TO DRIVE WITH HIGHBEAMS ON ALL THE TIME JUST TO BE ABLE TO SEE THE ROAD. I HAVE SEEN THIS AS THE #1 COMPLAINT ABOUT THIS MODEL CAR ON N…
Read full complaint
MY VEHICLE HAS 2 DEFECTS WHICH I HAVE NOTICED ON NUMEROUS OTHER CARS LIKE MINE, EVEN LATER MODEL YEARS. THE HEADLIGHTS BECOME VERY DULL AND YELLOWED AFTER 3-4 YEARS, TO THE POINT THAT YOU HAVE TO DRIVE WITH HIGHBEAMS ON ALL THE TIME JUST TO BE ABLE TO SEE THE ROAD. I HAVE SEEN THIS AS THE #1 COMPLAINT ABOUT THIS MODEL CAR ON NUMEROUS BLOGS. THE 2ND PROBLEM IS WITH THE SEAL AROUND THE BACK WINDSHIELD. IT WARPS AFTER A FEW YEARS. VIRTUALLY EVERY MARK VIII THAT I SEE HAS THIS SAME PROBLEM, AND IT IS VERY EXPENSIVE TO REPAIR BECAUSE THE WHOLE WINDSHIELD HAS TO BE REMOVED, AND THE BACK WINDSHIELD IS MUCH MORE COMPLICATED THAN THE FRONT. *TR
NHTSA ODI #10265456
Mileage unknown · Jun 5, 1998
Structure
WHEN TRYING TO OPEN THE VEHICLE DOOR USING THE REMOTE, THE HANDLE BROKE OFF IN DRIVER'S HAND. THE DOOR HAS BEEN INOPERABLE,. THE ONLY ENTRY IS FROM THE PASSENGERS SIDE ONLY. THE PART HAS BEEN ON BACK ORDER FOR THREE MONTHS, REASON BEING THAT THERE HAS BEEN NUMEROUS COMPLAINTS AND MANUFACTURER STOPPED MAKING THEM. THERE IS A …
Read full complaint
WHEN TRYING TO OPEN THE VEHICLE DOOR USING THE REMOTE, THE HANDLE BROKE OFF IN DRIVER'S HAND. THE DOOR HAS BEEN INOPERABLE,. THE ONLY ENTRY IS FROM THE PASSENGERS SIDE ONLY. THE PART HAS BEEN ON BACK ORDER FOR THREE MONTHS, REASON BEING THAT THERE HAS BEEN NUMEROUS COMPLAINTS AND MANUFACTURER STOPPED MAKING THEM. THERE IS A NATIONWIDE BACKLOG ON PARTS. *AK
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
1994 Lincoln Mark Viii Problems, Complaints & Recalls | Skip That Year
Illustration