IllustrationVEHICLE HAD ENGINE FAILURE AND TRANSMISSION LOCKED UP DURING ACCELERATION. AFTER A DIAGNOSES IT WAS THE RESULT OF A DEFECTIVE THERMOSTAT HOUSING THAT RELEASED THE COOLANT ONTO THE TOP OF THE ENGINE. AT THE CURRENT TIME THE AUTOMOBILE HAS HAD 39 DIFFERENT PROBLEMS DIAGNOSED SINCE THE PURCHASE DATE IN 2004. *TR
2004 Land Rover Freelander
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Land Rover Freelander do not stand out strongly from the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Freelander years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
130–25K
725–50K
3250–75K
975–100K
1100–150K
0150K+
62 reports with mileage · 7 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports0 injury reports
Power Train complaints
9 reportsI BOUGHT THIS VEHICLE IN APRIL 2010 AND HAVE HAD NOTHING BUT PROBLEMS EVER SINCE. IT HAD 79,600 MILES ON IT WHEN I BOUGHT IT AND WAS TOLD BY THE DEALER THAT IT HAD JUST RECENTLY HAD A TRANSMISSION REPLACED. THEY DIDN'T EVEN KNOW HOW TO OPEN THE HOOD - PASSENGER SIDE. 2 MONTHS LATER AND IT DIES ON ME GOING DOWN THE STREET. I PULL…
Read full complaint
I BOUGHT THIS VEHICLE IN APRIL 2010 AND HAVE HAD NOTHING BUT PROBLEMS EVER SINCE. IT HAD 79,600 MILES ON IT WHEN I BOUGHT IT AND WAS TOLD BY THE DEALER THAT IT HAD JUST RECENTLY HAD A TRANSMISSION REPLACED. THEY DIDN'T EVEN KNOW HOW TO OPEN THE HOOD - PASSENGER SIDE. 2 MONTHS LATER AND IT DIES ON ME GOING DOWN THE STREET. I PULL OVER AND ANTIFREEZE IS RUNNING EVERYWHERE. THE THERMOSTAT HOUSING HAD SEPARATED IN TWO AND CAUSED THE CAR TO OVERHEAT. I CALLED THE CLOSEST LAND ROVER DEALER AND HE QUOTED ME $800 TO FIX IT. I SEARCHED ON THE INTERNET AND FOUND THE PARTS TO FIX IT FOR $80. I REPLACED THE THERMOSTAT AND HOUSING (1 PIECE) AND GOT IT RUNNING AGAIN. SINCE THEN, THE SUNROOF HAS QUIT, BOTH REAR WINDOWS HAVE QUIT AND THE REAR SLIDING WINDOW WON'T OPEN BY KEY. THE DRIVER SIDE WINDSHIELD DEFROSTER WILL NOT WORK (ONLY THE PASSENGER SIDE) AND I HAVE NEVER HAD AN OWNERS MANUAL. THE DRIVERS SIDE DOOR WILL NOT UNLOCK WITH THE KEYLESS ENTRY EITHER. NOW I GET TO THE ENGINE - IT STARTED RUNNING REAL ROUGH AND LOST ALOT OF POWER. I HAD A LOCAL MECHANIC RUN CODES ON IT AND THIS IS WHAT HE FOUND: P0303 - #3 CYLINDER MISFIRE; P1319 - MISFIRE EMISSION RELEVANT; P1471, 1472 - VIS MOTORS EVAP PURGE VALVE FLOW BLOCKED; P1475 - LEAK DETECTION PUMP LEAKAGE DIAGNOSTIC PUMP REED SWITCH DID NOT CLOSE; P 1775 - GEARBOX FAULT TRANSMISSION SYSTEM MIL FAULT. I ASKED HIS OPINION AND HE TOLD ME IT WAS PROBABLY NOT WORTH FIXING. HE DIDN'T EVEN KNOW WHAT ALL OF THIS MEANT. HE WAS JUST GOING TO START TEARING IT DOWN AND SEE WHAT HE COULD FIX. I CAN'T AFFORD THAT. I LIVE PAYCHECK TO PAYCHECK AND I REALLY THOUGHT THAT LAND ROVER HAD A GOOD NAME AND REPUTATION. I EMAILED AND CALLED THEM AND HAVE HAD NO LUCK TO THIS POINT. EVERYTHING I HAVE SEEN ON THIS MODEL PROVES THAT IT IS A VEHICLE THAT SHOULD BE PUT TO REST. I AM LOOKING FOR ANY HELP I CAN GET. *TR
TRANSMISSION BEGAN TO HAVE A ROUGH 2ND TO 3RD SHIFT AROUND 60,000 MI. COMPLETE 3RD GEAR FAILURE BY 69,000. CAR WILL ACCELERATE TO ABOUT 25 MPH AND THEN SHIFT INTO 3RD AND ITS LIKE BEING IN N CAR WILL COAST AND ENGINE WILL REV. HAVE TO INSTALL NEW TRANSMISSION. SHOP SAID IT WAS CLEAR FROM THE CONDITION OF THE CAR THAT IT HAD NOT …
Read full complaint
TRANSMISSION BEGAN TO HAVE A ROUGH 2ND TO 3RD SHIFT AROUND 60,000 MI. COMPLETE 3RD GEAR FAILURE BY 69,000. CAR WILL ACCELERATE TO ABOUT 25 MPH AND THEN SHIFT INTO 3RD AND ITS LIKE BEING IN N CAR WILL COAST AND ENGINE WILL REV. HAVE TO INSTALL NEW TRANSMISSION. SHOP SAID IT WAS CLEAR FROM THE CONDITION OF THE CAR THAT IT HAD NOT BEEN ABUSED, AND THAT A TRANSMISSION SHOULD LAST TO ABOUT 150,000 MILES. *TR
DURING HIGH SPEEDS (55-70 MPH) CAR WOULD DOWN SHIFT INTO LOW GEAR FOR NO REASON. CHECK ENGINE LIGHT WOULD COME ON SHORTLY AFTER AND CAR RAN ROUGH. ON ONE OCCASION WHILE PULLING OUT ONTO A HIGHWAY THE CAR WOULD NOT ACCELERATE. BRAKES REPLACED AT APPROX. 11K MILES. ALL RECOMMENDED SERVICE WAS DONE ON TIME ACCORDING TO THE PASSP…
Read full complaint
DURING HIGH SPEEDS (55-70 MPH) CAR WOULD DOWN SHIFT INTO LOW GEAR FOR NO REASON. CHECK ENGINE LIGHT WOULD COME ON SHORTLY AFTER AND CAR RAN ROUGH. ON ONE OCCASION WHILE PULLING OUT ONTO A HIGHWAY THE CAR WOULD NOT ACCELERATE. BRAKES REPLACED AT APPROX. 11K MILES. ALL RECOMMENDED SERVICE WAS DONE ON TIME ACCORDING TO THE PASSPORT SCHEDULE. STOPPED TO GET GAS AND CAR WOULD NOT START. HAD TO GET CAR TOWED 40 MILES AND TAKE A TAXI HOME. I WENT TO ARBITRATION WITH LRNA AND I GOT A 2005 REPLACEMENT. SEE MY 2ND POST ABOUT THIS TRUCK - ENGINE IS SHOT- HEAD GASKET BROKEN, THERMOSTAT SHOT, BREAKS AT 25K MILES, CRACKED MANIFOLD, CRACKED ENGINE HOSES. *TR
IM AN OWNER OF A '04 FREELANDER LAND ROVER HSE. THE CAR IS PROPERLY MAINTAINED, HAS 63K IN THE ODOMETER. I BOUGHT THE CAR LAST OCT 07 WITH 49K ON IT. A FEW WEEKS AFTER THE 50K WARRANTY RAN OUT, THE FRONT AXLE BROKE DOWN WITH OUT ANY REASON AT ALL. THE CAR WAS 3 YR OLD, NEVER DRIVEN OFF ROAD, ALL HIGHWAY MILES ON FLORIDA FLAT TE…
Read full complaint
IM AN OWNER OF A '04 FREELANDER LAND ROVER HSE. THE CAR IS PROPERLY MAINTAINED, HAS 63K IN THE ODOMETER. I BOUGHT THE CAR LAST OCT 07 WITH 49K ON IT. A FEW WEEKS AFTER THE 50K WARRANTY RAN OUT, THE FRONT AXLE BROKE DOWN WITH OUT ANY REASON AT ALL. THE CAR WAS 3 YR OLD, NEVER DRIVEN OFF ROAD, ALL HIGHWAY MILES ON FLORIDA FLAT TERRAIN. THEN A TWO WEEK AGO, THE CAR JUST SUDDENLY STOPPED WITH AN F4 WARNING ON THE DASH. BROUGHT IT TO LAND ROVER ORLANDO AND WAS DIAGNOSED WITH A FAILED TRANSMISSION, WHICH WILL COST ME $5700 TO REPLACE. IM NOW STUCK WITH A BROKEN CAR, WITH AN UPSIDE DOWN BANK DEBT, AND AN ALMOST VALUE LESS "KELLY BLUE BOOK" CAR. FOR SOMEONE THAT HAS ONLY BEEN A YEAR AND A HALF IN THIS COUNTRY, AND STILL BUILDING MY CREDIT RECORD, I FEEL THAT THIS CAR WAS A REAL RIP OFF. THE MANUFACTURER OF THE CAR SHOULD BE ABLE TO HELP ME OUT IN THE DEEP HOLE THAT IM IN NOW. *TR
I PURCHASED THE 2004 LAND ROVER, FREELANDER IN 2006. IT HAS ONLY 28000 MILES ON IT. ABOUT A MONTH AFTER THE PURCHASE, I HAD TO TAKE IT IN TO REPLACE THE WINDOW REGULATOR. A FEW MONTHS LATER, I HEARD KNOCKING NOISES UNDER THE HOOD. I TOOK IT BACK IN (LR DEALERSHIP) AND THEY SAID THERE IS LOOSE WASHER SOMEWHERE. THEY WERE NOT ABLE…
Read full complaint
I PURCHASED THE 2004 LAND ROVER, FREELANDER IN 2006. IT HAS ONLY 28000 MILES ON IT. ABOUT A MONTH AFTER THE PURCHASE, I HAD TO TAKE IT IN TO REPLACE THE WINDOW REGULATOR. A FEW MONTHS LATER, I HEARD KNOCKING NOISES UNDER THE HOOD. I TOOK IT BACK IN (LR DEALERSHIP) AND THEY SAID THERE IS LOOSE WASHER SOMEWHERE. THEY WERE NOT ABLE TO REPLACE THE PART, THUS THEY ONLY REPAIRED THE PROBLEM. I COULD STILL HEAR THE NOISE, ESPECIALLY FROM A COLDSTART. I ALSO HAD TOOK IT IN FOR THEM TO LOOK AT AN AC PROBLEM. IT SPRAYS WATER OUT THROUGH THE AIR VENT. I REPORT THE PROBLEM AT LEAST 4 TIMES. EVERYTIME, THEY SAID THEY HAVE FIXED THE PROBLEMS. HOWEVER, AS OF NOW, WE STILL HAVE THAT PROBLEM. RECENTLY, WE HAVE A THERMOSTAT LEAK AT 52000 MILES. THE SUV MAINTENANCE SCHEDULES ARE UP TO DATE. THE SUV IS 5 MONTHS AND 3000 MILES PASS THE WARRANTY PERIOD. I HAVE TO PAY $800 TO REPAIR THE LEAK. TWO DAYS AGO, WILL ON THE FREEWAY (GOING 70MPH), THE SERVICE ENGINE LIGHT CAME ON. THEN THE ENGINE STALLED FOR A SECOND AND JERK FORWARD VIOLENTLY. THE SERVICE ENGINE LIGHT WENT OFF AND THE TC (TRACTION CONTROL) LIGHT TURNS ON AND THE 'DOWN HILL' CAR SYMBOL ON THE DASHBOARD ILLUMINATES. THE CAR WAS UNABLE TO START WHEN I TURNED IT OFF. I THEN LET IT SIT OVERNIGHT AND WAS ABLE TO START. AFTER THE CAR HAS STARTED, I NOTICE THE 'SERVICE ENGINE SOON' LIGHT ILLUMINATE. THE SUV HAS ONLY 53000 MILES ON IT AS OF NOW. I FEEL THAT THIS CAR IS POORLY DESIGNED. NOT ONLY IT PUT MY LIFE IN DANGER, BUT IT ALSO PUT THE LIVES OF MY WIFE AND MY 1 YEAR OLD DAUGHTER. WHEN WE BOUGHT THE SUV, WE THOUGHT THAT IT A SAFE SUV FOR OUR FAMILY. HOWEVER, THE INCIDENT TWO DAYS AGO ALMOST PUT OUR LIVES IN HARM WAYS. *TR
TRANSMISSION FAILURE WITH 50,739 MILES. *TR
IN MID-OCTOBER 2004, I BOUGHT A NEW LAND ROVER FREELANDER FROM THE JIM COLEMAN OF FREDERICK, MD DEALERSHIP. THE VEHICLE HAS HAD MASSIVE ELECTRICAL ISSUES. SINCE NOVEMBER OF '04, THE "HILL DESCENT" LIGHT (THE LR MANUAL SUGGESTS THIS MEANS A MAJOR PROBLEM), SRS (AIRBAG) AND THE CHECK ENGINE LIGHT COME ON SEVERAL TIMES. CAR HAS LE…
Read full complaint
IN MID-OCTOBER 2004, I BOUGHT A NEW LAND ROVER FREELANDER FROM THE JIM COLEMAN OF FREDERICK, MD DEALERSHIP. THE VEHICLE HAS HAD MASSIVE ELECTRICAL ISSUES. SINCE NOVEMBER OF '04, THE "HILL DESCENT" LIGHT (THE LR MANUAL SUGGESTS THIS MEANS A MAJOR PROBLEM), SRS (AIRBAG) AND THE CHECK ENGINE LIGHT COME ON SEVERAL TIMES. CAR HAS LEFT ME STRANDED TWICE BEFORE 2 MONTHS OLD. WHEN WE WENT TO GET THE CAR FOR PICK UP, THE CAR WAS DEAD. OTHER RECURRING PROBLEMS INCLUDE: NOT ACCELERATING PROPERLY FOR HIGHWAY ENTRY/INTERSECTIONS/LEFT TURNS. SLUGGISH, HESITANT, LUNGING FORWARD, VERY SLOW PICK UP. A NAUSEATING BURNING SMELL CONTINUES TO COME THROUGH THE VENTS INTO THE CAR AND SURROUNDS THE HOOD AREA WHEN VEHICLE IS RUNNING OR SHORTLY AFTER TURN OFF. BRAKES ARE SHUDDERING AND BRAKE PEDAL PUSHES BACK ON MY FOOT WHEN STOPPING FAST. I PARKED AND TURNED OFF VEHICLE. CAME BACK TO VEHICLE AN HOUR LATER WITH THE AC FANS BLOWING ON HIGH. CAR WAS OFF. NO KEY IN IGNITION. MECHANIC AND I WITNESSED THE REAR GATE WINDOW DROP WITHOUT THE CAR BEING ON AND THE KEY OUT OF THE IGNITION. THIS HAPPENS REGULARLY. AIR CONDITIONER SPITS THROUGH VENTS. WATER POURING OUT VENTS WHEN GOING AROUND CURVES. SIGNIFICANT AMOUNT OF AC-RELATED WATER ON FLOOR. A/C BROKE COMPLETELY. NO COLD AIR, ONLY FANS. A/C LIGHT WOULD NOT COME ON. AIR WOULD COME OUT, ONLY HOT AIR. FANS STOPPED WORKING. FRONT AND REAR WINDOWS COMPLETELY FOGGED UP ON TRIP TO MISSISSIPPI. HAD TO USE TOWELS TO WIPE WINDOWS DOWN. DRASTICALLY CUT VISIBILITY AS WINDOWS FOGGED UP. FORCED TO LEAVE WINDOWS DOWN IN THUNDER STORMS. DRIVERS SIDE WIND SHIELD WIPER IS DRAGGING AT THE BOTTOM CREATING A SMEARED EFFECT. *NM
2004 FREELANDER - FOUR HEATER AND AC BLOWER REPAIRS; WATER LEAKED FROM ROOF INTO DASHBOARD; REPLACED TRANSMISSION AT 15,000 MILES, WINDSHIELD WIPER MOTORS BLOWN OUT. *JB
Official recalls
307V041000 · Exterior Lighting:brake Lights:switch
Feb 9, 2007
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE LIGHTS MAY REMAIN ILLUMINATED EVEN WHEN THE BRAKE PEDAL IS NOT DEPRESSED. HILL DESCENT CONTROL (HDC), TRACTION CONTROL (TC) AND CRUISE CONTROL WARNING LIGHTS MAY ALSO BE ILLUMINATED.
Consequence & remedy
Consequence: FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE BRAKE LAMP OPERATION AND WHERE REQUIRED, ADJUST AND/OR REPLACE THE BRAKE LIGHT SWITCHES WITH NEW SWITCHES OF THE SAME DESIGN UNTIL A NEWLY DESIGNED BRAKE LAMP SWITCH IS AVAILABLE IN MAY 2007. OWNERS WILL THEN BE RE-NOTIFIED TO BRING THEIR VEHICLES IN FOR THE NEW BRAKE LIGHT SWITCH. AN INTERIM LETTER FOR THE INITIAL INSPECTION WAS MAILED ON MARCH 26, 2007. THE SECOND LETTER FOR REPLACEMENT OF THE SWITCHES WAS MAILED BEGINNING JULY 30, 2007. OWNERS MAY CONTACT LAND ROVER AT 1-80-637-6837.
05V300000 · Latches/locks/linkages:doors:latch
Jun 28, 2005
ON CERTAIN FIVE DOOR SPORT UTILITY VEHICLES, IT IS POSSIBLE TO OPERATE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR WHEN THE CHILD SAFETY LEVER IS IN THE "ON" POSITION.
Consequence & remedy
Consequence: THE OCCUPANT MAY OPEN THE DOOR INADVERTENTLY WHILE THE VEHICLE IS IN MOTION AND FALL OUT INTO THE TRAFFIC, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSPECT AND REPLACE THE LATCH ASSEMBLY. THE RECALL BEGAN ON SEPTEMBER 8, 2005. OWNERS SHOULD CONTACT LAND ROVER AT 1-800-637-6837.
04V347000 · Structure:body:roof And Pillars
Jul 12, 2004
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT MARGINALLY ABOVE THE PERMITTED 1000 HEAD IMPACT CRITERIA. AT THE LEFT AND RIGHT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL REPLACE THE A-PILLAR TRIM WITH A REVISED COMPONENT THAT ENABLES THE VEHICLE TO FULLY MEET THE REQUIREMENTS OF FMVSS 201. THE RECALL BEGAN ON DECEMBER 6, 2005. OWNERS SHOULD CONTACT LAND ROVER AT 1-800-637-6837.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA05016 · Brake Light Switch Failure
Opened Oct 14, 2005 · Closed Feb 22, 2007
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
ON JUNE 16, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE05-034) TO INVESTIGATE ALLEGED STOP LAMP (BRAKE) SWITCH FAILURES IN CERTAIN MODEL YEAR (MY) 2004 LAND ROVER DISCOVERY SERIES II VEHICLES.ON OCTOBER 14, 2005, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS AND THE SCOPE EXPANDED TO INCLUDE CERTAIN MY 2002 THROUGH 2005 FREELANDER VEHICLES THAT USE A SUBSTANTIALLY SIMILAR SELF-ADJUSTING STOP LAMP SWITCH FURNISHED BY THE SAME SUPPLIER, METHODE ELECTRONICS MALTA, LTD. (METHODE).IN SEPTEMBER 2003, METHODE MOVED THE PRODUCTION OF AN INTERNAL SWITCH COMPONENT, KNOWN AS THE SLIDER MECHANISM, FROM A VALIDATED PLASTIC INJECTION-MOLDING TOOL (?CAVITY 1?) TO ANOTHER TOOL (?CAVITY 2?) THAT HAD NOT BEEN USED BEFORE TO PRODUCE PARTS FOR LAND ROVER.SLIDERS FROM CAVITY 2 MAY BE CHARACTERIZED BY POOR FILL, LACK OF DEFINITION IN THE SLIDER TEETH AND DIMENSIONAL INSTABILITY.CONSEQUENTLY, THE SLIDER MAY BE UNABLE TO RESTRAIN IMPROPER MOVEMENT OF THE PLUNGER DURING NORMAL BRAKE PEDAL OPERATION.THIS MAY CAUSE THE SWITCH TO FALL OUT OF ADJUSTMENT, THUS SIGNIFICANTLY REDUCING THE EFFORT REQUIRED TO ENERGIZE THE SWITCH AND ILLUMINATE THE STOP LAMPS.?CAVITY 2? SWITCHES WERE INSTALLED IN APPROXIMATELY 8,763 DISCOVERY SUBJECT VEHICLES BUILT FROM DECEMBER 2003 THROUGH MAY 2004 AND APPROXIMATELY 3,915 FREELANDER SUBJECT VEHICLES BUILT FROM OCTOBER 2003 THROUGH MAY 2004.ADDITIONALLY, STOP LAMP SWITCHES IN CERTAIN MY 2002 THROUGH 2005 FREELANDER SUBJECT VEHICLES MAY SLIP OUT OF ADJUSTMENT AS A RESULT OF SWITCH DAMAGE DUE TO AN INCORRECT SETTING PROCEDURE DURING VEHICLE MANUFACTURE OR AS A RESULT OF SWITCH MOUNTING BRACKET FLEX.ANALYSIS OF ALL AVAILABLE DATA INDICATES THE PREDOMINANT FAILURE MODE IS CONSTANT STOP LAMP ILLUMINATION.OTHER REPORTED CONSEQUENCES OF STOP LAMP SWITCH MALADJUSTMENT INCLUDE INOPERATIVE AUTOMATIC TRANSMISSION GEAR SELECTOR/BRAKE PEDAL SHIFT INTERLOCK, INOPERATIVE SPEED (CRUISE) CONTROL, AND TELLTALE ILLUMINATION AS DESCRIBED IN TECHNICAL SERVICE BULLETIN (TSB) NO. LT206-001 DATED OCTOBER 28, 2004 ISSUED BY THE MANUFACTURER TO LAND ROVER DEALERS IN THE UNITED KINGDOM (UK).TO DATE, ODI IS AWARE OF 77 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE STOP LAMP SWITCH FAILURE ON THE SUBJECT VEHICLES (10 COMPLAINTS ON MY 2004 DISCOVERY, 45 ON MY 2002 FREELANDER, 19 ON MY 2003 FREELANDER, AND 3 ON MY 2004 FREELANDER VEHICLES).ADDITIONALLY, 4,595 DISCOVERY AND 13,370 FREELANDER SUBJECT VEHICLES HAVE EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPLACE THE STOP LAMP SWITCH.OF THE 5,170 WARRANTY CLAIMS PAID TO REPLACE STOP LAMP SWITCHES ON DISCOVERY SUBJECT VEHICLES, APPROXIMATELY 31% OCCURRED BEFORE THE VEHICLE WAS SOLD NEW AND APPROXIMATELY 88% OCCURRED WITHIN THE FIRST 12 MONTHS OF VEHICLE SERVICE.THE WARRANTY TREND ON DISCOVERY SUBJECT VEHICLES IS IN DECLINE WITH 3,545 CLAIMS PAID IN CALENDAR YEAR (CY) 2004, 1,303 CLAIMS PAID IN CY 2005, AND 322 CLAIMS PAID IN CY 2006 THROUGH SEPTEMBER 28, 2006 (WHICH IS WHEN ODI LAST RECEIVED UPDATED WARRANTY CLAIMS DATA FROM LAND ROVER), AND IT APPEARS THAT THE ALLEGED DEFECT ON DISCOVER SUBJECT VEHICLES HAS BEEN REMEDIED THROUGH WARRANTY REPAIRS.HOWEVER, ODI ANALYSIS OF THE MANUFACTURER?S WARRANTY AND COMPLAINT RECORDS INDICATES THE FAILURE TREND ON CERTAIN FREELANDER SUBJECT VEHICLES IS ONGOING.BY LETTER DATED FEBRUARY 2, 2007, LAND ROVER HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 07V-041) TO REPLACE DEFECTIVE STOP LAMP SWITCHES IN APPROXIMATELY 33,247 MY 2002 THROUGH 2005 FREELANDER VEHICLES BUILT AT THE SOLIHULL, UK ASSEMBLY PLANT FROM SEPTEMBER 5, 2001 THROUGH MAY 19, 2005. ALTHOUGH ODI HAS CONCERN
Additional source detail variants (2)
Exterior Lighting:brake Lights
ON JUNE 16, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE05-034) TO INVESTIGATE ALLEGED STOP LAMP (BRAKE) SWITCH FAILURES IN CERTAIN MODEL YEAR (MY) 2004 LAND ROVER DISCOVERY SERIES II VEHICLES.ON OCTOBER 14, 2005, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS AND THE SCOPE EXPANDED TO INCLUDE CERTAIN MY 2002 THROUGH 2005 FREELANDER VEHICLES THAT USE A SUBSTANTIALLY SIMILAR SELF-ADJUSTING STOP LAMP SWITCH FURNISHED BY THE SAME SUPPLIER, METHODE ELECTRONICS MALTA, LTD. (METHODE).IN SEPTEMBER 2003, METHODE MOVED THE PRODUCTION OF AN INTERNAL SWITCH COMPONENT, KNOWN AS THE SLIDER MECHANISM, FROM A VALIDATED PLASTIC INJECTION-MOLDING TOOL (?CAVITY 1?) TO ANOTHER TOOL (?CAVITY 2?) THAT HAD NOT BEEN USED BEFORE TO PRODUCE PARTS FOR LAND ROVER.SLIDERS FROM CAVITY 2 MAY BE CHARACTERIZED BY POOR FILL, LACK OF DEFINITION IN THE SLIDER TEETH AND DIMENSIONAL INSTABILITY.CONSEQUENTLY, THE SLIDER MAY BE UNABLE TO RESTRAIN IMPROPER MOVEMENT OF THE PLUNGER DURING NORMAL BRAKE PEDAL OPERATION.THIS MAY CAUSE THE SWITCH TO FALL OUT OF ADJUSTMENT, THUS SIGNIFICANTLY REDUCING THE EFFORT REQUIRED TO ENERGIZE THE SWITCH AND ILLUMINATE THE STOP LAMPS.?CAVITY 2? SWITCHES WERE INSTALLED IN APPROXIMATELY 8,763 DISCOVERY SUBJECT VEHICLES BUILT FROM DECEMBER 2003 THROUGH MAY 2004 AND APPROXIMATELY 3,915 FREELANDER SUBJECT VEHICLES BUILT FROM OCTOBER 2003 THROUGH MAY 2004.ADDITIONALLY, STOP LAMP SWITCHES IN CERTAIN MY 2002 THROUGH 2005 FREELANDER SUBJECT VEHICLES MAY SLIP OUT OF ADJUSTMENT AS A RESULT OF SWITCH DAMAGE DUE TO AN INCORRECT SETTING PROCEDURE DURING VEHICLE MANUFACTURE OR AS A RESULT OF SWITCH MOUNTING BRACKET FLEX.ANALYSIS OF ALL AVAILABLE DATA INDICATES THE PREDOMINANT FAILURE MODE IS CONSTANT STOP LAMP ILLUMINATION.OTHER REPORTED CONSEQUENCES OF STOP LAMP SWITCH MALADJUSTMENT INCLUDE INOPERATIVE AUTOMATIC TRANSMISSION GEAR SELECTOR/BRAKE PEDAL SHIFT INTERLOCK, INOPERATIVE SPEED (CRUISE) CONTROL, AND TELLTALE ILLUMINATION AS DESCRIBED IN TECHNICAL SERVICE BULLETIN (TSB) NO. LT206-001 DATED OCTOBER 28, 2004 ISSUED BY THE MANUFACTURER TO LAND ROVER DEALERS IN THE UNITED KINGDOM (UK).TO DATE, ODI IS AWARE OF 77 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE STOP LAMP SWITCH FAILURE ON THE SUBJECT VEHICLES (10 COMPLAINTS ON MY 2004 DISCOVERY, 45 ON MY 2002 FREELANDER, 19 ON MY 2003 FREELANDER, AND 3 ON MY 2004 FREELANDER VEHICLES).ADDITIONALLY, 4,595 DISCOVERY AND 13,370 FREELANDER SUBJECT VEHICLES HAVE EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPLACE THE STOP LAMP SWITCH.OF THE 5,170 WARRANTY CLAIMS PAID TO REPLACE STOP LAMP SWITCHES ON DISCOVERY SUBJECT VEHICLES, APPROXIMATELY 31% OCCURRED BEFORE THE VEHICLE WAS SOLD NEW AND APPROXIMATELY 88% OCCURRED WITHIN THE FIRST 12 MONTHS OF VEHICLE SERVICE.THE WARRANTY TREND ON DISCOVERY SUBJECT VEHICLES IS IN DECLINE WITH 3,545 CLAIMS PAID IN CALENDAR YEAR (CY) 2004, 1,303 CLAIMS PAID IN CY 2005, AND 322 CLAIMS PAID IN CY 2006 THROUGH SEPTEMBER 28, 2006 (WHICH IS WHEN ODI LAST RECEIVED UPDATED WARRANTY CLAIMS DATA FROM LAND ROVER), AND IT APPEARS THAT THE ALLEGED DEFECT ON DISCOVER SUBJECT VEHICLES HAS BEEN REMEDIED THROUGH WARRANTY REPAIRS.HOWEVER, ODI ANALYSIS OF THE MANUFACTURER?S WARRANTY AND COMPLAINT RECORDS INDICATES THE FAILURE TREND ON CERTAIN FREELANDER SUBJECT VEHICLES IS ONGOING.BY LETTER DATED FEBRUARY 2, 2007, LAND ROVER HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 07V-041) TO REPLACE DEFECTIVE STOP LAMP SWITCHES IN APPROXIMATELY 33,247 MY 2002 THROUGH 2005 FREELANDER VEHICLES BUILT AT THE SOLIHULL, UK ASSEMBLY PLANT FROM SEPTEMBER 5, 2001 THROUGH MAY 19, 2005. ALTHOUGH ODI HAS CONCERN
Exterior Lighting:brake Lights:switch
ON JUNE 16, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE05-034) TO INVESTIGATE ALLEGED STOP LAMP (BRAKE) SWITCH FAILURES IN CERTAIN MODEL YEAR (MY) 2004 LAND ROVER DISCOVERY SERIES II VEHICLES.ON OCTOBER 14, 2005, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS AND THE SCOPE EXPANDED TO INCLUDE CERTAIN MY 2002 THROUGH 2005 FREELANDER VEHICLES THAT USE A SUBSTANTIALLY SIMILAR SELF-ADJUSTING STOP LAMP SWITCH FURNISHED BY THE SAME SUPPLIER, METHODE ELECTRONICS MALTA, LTD. (METHODE).IN SEPTEMBER 2003, METHODE MOVED THE PRODUCTION OF AN INTERNAL SWITCH COMPONENT, KNOWN AS THE SLIDER MECHANISM, FROM A VALIDATED PLASTIC INJECTION-MOLDING TOOL (?CAVITY 1?) TO ANOTHER TOOL (?CAVITY 2?) THAT HAD NOT BEEN USED BEFORE TO PRODUCE PARTS FOR LAND ROVER.SLIDERS FROM CAVITY 2 MAY BE CHARACTERIZED BY POOR FILL, LACK OF DEFINITION IN THE SLIDER TEETH AND DIMENSIONAL INSTABILITY.CONSEQUENTLY, THE SLIDER MAY BE UNABLE TO RESTRAIN IMPROPER MOVEMENT OF THE PLUNGER DURING NORMAL BRAKE PEDAL OPERATION.THIS MAY CAUSE THE SWITCH TO FALL OUT OF ADJUSTMENT, THUS SIGNIFICANTLY REDUCING THE EFFORT REQUIRED TO ENERGIZE THE SWITCH AND ILLUMINATE THE STOP LAMPS.?CAVITY 2? SWITCHES WERE INSTALLED IN APPROXIMATELY 8,763 DISCOVERY SUBJECT VEHICLES BUILT FROM DECEMBER 2003 THROUGH MAY 2004 AND APPROXIMATELY 3,915 FREELANDER SUBJECT VEHICLES BUILT FROM OCTOBER 2003 THROUGH MAY 2004.ADDITIONALLY, STOP LAMP SWITCHES IN CERTAIN MY 2002 THROUGH 2005 FREELANDER SUBJECT VEHICLES MAY SLIP OUT OF ADJUSTMENT AS A RESULT OF SWITCH DAMAGE DUE TO AN INCORRECT SETTING PROCEDURE DURING VEHICLE MANUFACTURE OR AS A RESULT OF SWITCH MOUNTING BRACKET FLEX.ANALYSIS OF ALL AVAILABLE DATA INDICATES THE PREDOMINANT FAILURE MODE IS CONSTANT STOP LAMP ILLUMINATION.OTHER REPORTED CONSEQUENCES OF STOP LAMP SWITCH MALADJUSTMENT INCLUDE INOPERATIVE AUTOMATIC TRANSMISSION GEAR SELECTOR/BRAKE PEDAL SHIFT INTERLOCK, INOPERATIVE SPEED (CRUISE) CONTROL, AND TELLTALE ILLUMINATION AS DESCRIBED IN TECHNICAL SERVICE BULLETIN (TSB) NO. LT206-001 DATED OCTOBER 28, 2004 ISSUED BY THE MANUFACTURER TO LAND ROVER DEALERS IN THE UNITED KINGDOM (UK).TO DATE, ODI IS AWARE OF 77 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE STOP LAMP SWITCH FAILURE ON THE SUBJECT VEHICLES (10 COMPLAINTS ON MY 2004 DISCOVERY, 45 ON MY 2002 FREELANDER, 19 ON MY 2003 FREELANDER, AND 3 ON MY 2004 FREELANDER VEHICLES).ADDITIONALLY, 4,595 DISCOVERY AND 13,370 FREELANDER SUBJECT VEHICLES HAVE EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPLACE THE STOP LAMP SWITCH.OF THE 5,170 WARRANTY CLAIMS PAID TO REPLACE STOP LAMP SWITCHES ON DISCOVERY SUBJECT VEHICLES, APPROXIMATELY 31% OCCURRED BEFORE THE VEHICLE WAS SOLD NEW AND APPROXIMATELY 88% OCCURRED WITHIN THE FIRST 12 MONTHS OF VEHICLE SERVICE.THE WARRANTY TREND ON DISCOVERY SUBJECT VEHICLES IS IN DECLINE WITH 3,545 CLAIMS PAID IN CALENDAR YEAR (CY) 2004, 1,303 CLAIMS PAID IN CY 2005, AND 322 CLAIMS PAID IN CY 2006 THROUGH SEPTEMBER 28, 2006 (WHICH IS WHEN ODI LAST RECEIVED UPDATED WARRANTY CLAIMS DATA FROM LAND ROVER), AND IT APPEARS THAT THE ALLEGED DEFECT ON DISCOVER SUBJECT VEHICLES HAS BEEN REMEDIED THROUGH WARRANTY REPAIRS.HOWEVER, ODI ANALYSIS OF THE MANUFACTURER?S WARRANTY AND COMPLAINT RECORDS INDICATES THE FAILURE TREND ON CERTAIN FREELANDER SUBJECT VEHICLES IS ONGOING.BY LETTER DATED FEBRUARY 2, 2007, LAND ROVER HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 07V-041) TO REPLACE DEFECTIVE STOP LAMP SWITCHES IN APPROXIMATELY 33,247 MY 2002 THROUGH 2005 FREELANDER VEHICLES BUILT AT THE SOLIHULL, UK ASSEMBLY PLANT FROM SEPTEMBER 5, 2001 THROUGH MAY 19, 2005. ALTHOUGH ODI HAS CONCERN