2022 Kia Telluride

The vehicle experiences a recurring mechanical failure where the electronic AWD coupling/rear axle locks up and binds when accelerating through turns. This creates an immediate safety hazard by altering steering dynamics and causing vehicle hesitation or severe wheel hop in intersection turns. A certified Kia dealership has already fully replaced the entire factory AWD Coupling assembly twice: first under the original warranty on July 16, 2024 at 48,054 miles, and again under warranty on May 2, 2025 at 59,350 miles. Following a preliminary check-in for the same symptom on April 9, 2025, this identical component failure has now recurred for a third time at approximately 77,000 miles.

The contact owns a 2022 Kia Telluride. The contact stated that while driving at an undisclosed speed at night, the side view mirror's blind-spot system generated phantom alerts while there was no object nearby. Additionally, the headlights inadvertently fluctuated between dim (low beam) and extremely bright (high beam) settings. The instrument cluster displayed that the vehicle unintendedly switched to Smart Drive Mode but failed to display the transmission gears. The trunk button intermittently failed to operate as needed. The back over prevention sensing system failed to alert that there was an object behind the vehicle while reversing. There were several unknown warning lights illuminated. The vehicle was towed to the dealer, who was unable to duplicate the failure, but twenty-six history trouble codes were retrieved, indicating the power steering, ABS, air bags, blind spot collision, front radar, and Integrated Charging Control Unit (ICCU) malfunctions. The contact stated that prior to the failure, a Voluntary Emissions Service Campaign: SC357 Engine Control Unit (ECU) was performed on the vehicle; however, the dealer informed the contact that the failure was not related. The dealer recalibrated the front radar, but the failure recurred at night while driving. The vehicle was towed back to the dealer, but the failure could not be duplicated. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 71,000.

While attempting to operate the sunroof on my Kia Telluride, the sunroof mechanism failed and became completely stuck in the open position. The sunroof will not close, bypass, or reset, leaving the cabin fully exposed. Upon inspection, it appears the internal mechanism arms or wind deflector components have failed/broken, which prevents the glass from sliding forward back into its sealed, closed position.

The vehicle began showing serious safety related symptoms before the engine failed. These included engine knocking, repeated sensor failures, the speedometer and odometer blacking out while driving, the navigation screen going dark, and the entire instrument cluster malfunctioning. These issues caused loss of speed information, loss of vehicle status, and loss of navigation visibility, creating unsafe driving conditions. Despite these warning signs, the engine later failed suddenly at around 71,399 miles with no warning lights, no oil pressure alerts, and no overheating indicators. The sudden loss of power created a highway safety hazard due to loss of propulsion and reduced steering and braking assist. The manufacturer and dealership also provided conflicting and misleading information about warranty coverage, including a claim of “no warranty on engine,” which contradicts the official warranty coverage documents. This has delayed proper repair of a safety related defect.

While operating my Kia vehicle, the vehicle experienced a sudden loss of braking capability and loss of acceleration/power while traveling downhill. Multiple warning lights reportedly illuminated during the event, including the battery light, oil light, and check engine light. The incident created a serious safety concern due to inability to properly control vehicle speed and operation. The vehicle was taken to an authorized Kia dealership for inspection. However, the dealership has refused to provide written confirmation that the vehicle is safe to drive and stated they would not assume liability regarding operation of the vehicle. The dealership further recommended towing the vehicle if I feel unsafe operating it. I am requesting investigation into the safety-related condition involving braking/drivability failure and related warning systems.

I was driving the vehicle and came to a stop sign. When I accelerated to turn and drive what was a steep windy downhill Road my car jerked some and the check engine light battery light and oil light came on the dash when I went to push the brakes they went all the way to the floor and the car did not stop. I continued to try the brakes and had to use the emergency break to pull up and down to stop and drive up on a hill to not crash into other vehicles I have my vehicle at Kia and they are claiming there is absolutely nothing wrong with the vehicle and I am to pick it up and leave the lot. They have not offered a loaner car or shown any concerns of my safety leaving the lot. I have asked for it to be in writing, but my car is safe to leave and they are not doing so this has caused major anxiety and PTSD to even begin to drive myself and my children are very shook up over this.

On three different occasions this car’s engine shuts off on me sometimes at highway speeds. It is terrifying being in the left lane and losing all propulsion and power steering. I have to quickly put the car in park (in the middle of the highway) and then restart the car to go again. When it starts failing it keeps shutting off when we come to a stop in stop and go traffic. It’s like the auto shutoff option shuts off the car abut won’t turn it back on. I took it to DCH Kia of Temecula to get to the bottom of this issue. They are saying because there are no check engine lights and they cannot replicate the problem they can’t do anything and want to return the car to us. We fought that and they started a techline report for engineering to help troubleshooting. Kia customer care was involved, but I was told I had 48 hours to pick my car up as is. Driving this car on long trips is now terrifying for me and my family, if you look online, nationwide Kia tellurides are having this same issue I’ve seen from the 2020 models to 2026. I am not the only person having this issue with a Kia telluride. Something needs to be done NATION WIDE before loss of life happens. I would venture to use the fall of the “Saturn” car company as an example of knowing there’s an issue and not fixing it. I want a solution to this issue and I do not feel that “just trade it in” is an acceptable answer.

The contact owns a 2022 Kia Telluride. The contact stated that while driving at 66 MPH, the sunroof unexpectedly exploded. There was no impact on the sunroof to cause the failure. The sunroof cover was closed during the failure. There were no injuries sustained. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was 21,178.