2022 Kia Telluride

Small rock hit windshield on very edge, the initial impact only produced a chip not much larger than the tip of a ballpoint pen but within minutes a large crack has spread at least 18" across the windshield. Based on research online this is unfortunately a very common issue and has been going on since at least 2019 when the company acknowledged the issue with a "goodwill" customer service initiative to replace damaged windshields for this exact issue. Still waiting to hear from dealer on potential resolution.

While driving at approximately 35 MPH, with no vehicles, pedestrians, lawnmowers, trees, road hazards, etc., near, the windshield spontaneously cracked near the passenger side pillar. The initial crack was circular with spider-webbing, the longest of which was approximately 6 inches (not exact due to being measured with a hand as reference). The vehicle was immediately parked, and upon return to the vehicle 1 hour and 45 minutes later, the spider-webbing had spread to approximately half the length of the windshield from the initial crack at the passenger side, to the driver side. My wife confirmed that there were no vehicles traveling the opposite direction, no pedestrians, overpasses, trees, vehicles, or other logical causes near the vehicle immediately following the initial crack. It seemed to occur spontaneously, my wife stated she heard what she could best describe as "the sound of glass cracking like in a horror movie" and observed the initial crack. Due to the rate of the spreading, and fear of further integrity failures, the vehicle is parked. I contacted Kia due to the 2020 good will letter concerning windshields, and was told this did not apply to the 2022 due to it not being the appropriate year, and would have to cover the replacement of the window out of pocket or through insurance. No warnings, no noise indicative of something striking the windshield, no damage to any other components including the paint, etc. It just seemingly cracked, the only reason I could deduce is due to the temperature today being approximately 85 degrees, and the vehicle was parked in the sunlight due to the parking not being shaded. Perhaps the exposure resulted in the initial failure and subsequent spider-webbing. This vehicle was purchased brand new on 12 June, 2022.

I was the first car in line stopped at a traffic light - no vehicles in front of me - and I heard a loud pop. Immediately, I noticed a curved crack in the upper center of the windshield that wrapped below the rear view mirror area. There was no impact to the glass at the time - the windshield just simply popped for seemingly no reason whatsoever. This has been an issue on 2020 and 2021 Kia Tellurides, and Kia has been aware of this issue for a while, blaming it on a "windshield bonding problem" at the factory.

We have had the vehicle for less than a year and the windshield has already broken twice from very small/light pebbles. The star caused by the most recent one was so small we didn't even hear it and has now spread to a 30"+ crack across windshield. We learned through researching that the windshields on these cars are becoming notorious for easy breakage and we do not feel safe having such a weak windshield.I have been driving for 18 years and have only ever once before had a windshield need replacement. The crack is so large I am afraid the glass will fall through while driving and it distorts the view. Should not have to keep replacing the windshield for every grain of sand that strikes it!