2021 Kia Telluride

My 2021 Kia Telluride has developed progressively worsening engine problems without any warning lights ever appearing that may present a serious safety concern. Approximately two months ago, the vehicle began experiencing significant engine shaking and rocking. Maintenance and repairs were performed, and the symptoms temporarily improved. The engine symptoms later returned. The vehicle began making a noticeable ticking noise that progressively became much louder and occurred both while idling and during acceleration. The vehicle subsequently shut off after being driven to an independent mechanic. Multiple warning/diagnostic alerts appeared, and the vehicle would not remain running when restarted. The mechanic checked the engine oil and found it essentially empty. Approximately 4½ quarts of oil were added. The ticking noise continued despite the addition of oil. Later that same day, the engine developed a pronounced knocking noise that continued while driving. There was also a hot smell, and I had noticed discolored smoke coming from the exhaust. The vehicle is currently parked and is available for inspection. I have stopped driving it because I am concerned about an engine failure and the possibility of the vehicle shutting off or losing power while being operated. The vehicle has been maintained and I have documentation of its maintenance and repair history. The underlying cause of the severe oil loss and engine symptoms has not been determined.

I believe my engine to be defective and Commonwealth Kia to be neglegent in finding the defect dispite having been tasked to repair an issue while my car was under warranty. I first mentioned the problem on the XXX visit at $85,000 miles. Asked them to check the filters. Mentioned again at the XXX visit at 92,000 there is not documentation of the complaints on either of these visits but it does say ont eh XXX visit that the car "STILL LACKS POWER..." indicating that there have been previous discussions about the issue. The car was at 99,000+ miles at the XXX visit (still under warranty) I returned on XXX and XXX and was told on 1/20 that they FINALLY found the problem and that I would have to pay to have the entire engine replaced. I have since done some research and the issues that I am having are very similar to the Class Action Suit against Kia and the THETA II engine. [XXX] I have also seen on multilple owners boards on social media and in reports found on the internet that 2020-2023 Kia Tellurides have been having the same issues as THETA II engine models. [XXX] I find it difficult to believe Commonwealth Kia Service have not heard similar complaints nor have the ability to diagnose the problem on the first or second mention of the problem (which was while the car was still under warranty) I have called Kia USA who can not help me due to the fact that I am the second owner. The car was sold to me as "Certified Pre-Owned" by Kia. I believe Commonwealth Kia willfully misdiagnosed my problems so as to push the replacement cost to me and not the warranty INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I purchased this 2021 Kia Telluride new and have had it routinely serviced and maintained by authorized Kia dealerships. At approximately 60,000–80,000 miles, the engine began consuming excessive oil. I reported the condition to the Kia dealer at approximately 80,000 miles, while the vehicle was still within Kia's 10-year/100,000-mile powertrain warranty. The dealer initially recommended a tune-up, but the oil consumption continued. During a later visit, the dealer identified an issue involving the OEM oil-filter housing and replaced the affected component. Despite this repair and continued maintenance, oil consumption progressively worsened. The vehicle now has approximately 160,000 miles and requires approximately one pint of oil every 2–3 weeks. The current diagnosis indicates potential internal engine damage, including cylinder-wall scoring that may allow oil to bypass the piston rings and burn in the combustion chambers. I have been advised the engine may require replacement at an estimated cost of approximately $13,000. My primary concern is that this condition began and was reported to Kia while the vehicle was still under the powertrain warranty, but the repairs did not correct it. Continued excessive oil consumption and internal engine damage create a safety concern because they could result in low oil pressure, engine seizure, stalling, or sudden loss of propulsion while driving. The vehicle is available for inspection, and its maintenance history, prior complaints, dealer repairs, and current condition are documented through Kia dealership service records.

Was low on oil and check oil light don't go on have to put oil very 2 week because it get low and I don't have no oil leak at all I found out because the motor start shaking and making noise tow it home and mechanical came to check it out and didn't have oil he say I was lurking I was not in the highway because it could lock the mortar and cause a accident

In August 2025, my Kia dealership serviced my 2021 Kia Telluride and billed me for 7 quarts of oil as part of the repair. Approximately four months later, in December 2025, the vehicle developed severe engine problems and became inoperable. The dealership diagnosed the failure as a collapsed timing tensioner and stated the engine required complete replacement. Kia Techline agreed with that diagnosis and used it as the basis for recommending a new engine. Despite acknowledging that engine replacement was necessary, Kia denied warranty coverage, leaving me responsible for an estimated $11,000 repair. I then obtained a second opinion from an independent, reputable repair facility. After inspecting the vehicle, the shop concluded the engine failure was not caused by a timing system failure. Instead, they found the engine contained only about one quart of oil and determined the damage resulted from oil starvation. They further stated that, in their professional opinion, the dealership had misdiagnosed the vehicle and that the low oil level was consistent with the possibility that the dealership failed to add the oil for which I was charged during the August 2025 service. What is especially concerning is that the dealership never documented or informed me that the engine was critically low on oil. Because the timing components rely on engine oil for lubrication, I believe it would have been impossible to properly inspect and diagnose a timing tensioner failure without recognizing and documenting the severely low oil level. Based on the independent inspection and the dealership's failure to identify or disclose the lack of oil, I believe the dealership either failed to perform the service as billed or failed to correctly diagnose the true cause of the engine failure. I am concerned that this incorrect diagnosis diverted attention from possible negligent workmanship during the prior service and led to an unnecessary recommendation for an $11,000 engine replacement.

CATASTROPHIC FAILURE TIMELINE (13 DAYS) XXX: Delivery taken at 105,439 miles.XXX: My boyfriend noticed a cloud of smoke from exhaust as I pressed the accelerator pedal to leave the parking lot. I didn't notice because it was almost dark outside when leaving. He didn't notice again so he didn't stop me and told me when we got home. XXX (Day 12): Check Engine Light (CEL) on. Dipstick found dry. 2 quarts of oil purchased and added. Which brought the level right above the L line. Sent texts to both salesmen (Freedom and Driveway). Went to work in [XXX]. XXX (Day 13): Got home with Odometer: 106,974. Plugged Code reader into the vehicle and got Code P0597 logged at 1:04 AM. Tried both salesmen again through texts, email and or call. Have yet to get a reply from either. XXX posted review updates on both of my previous posted reviews for Freedom and Driveway. Received my first response from the Driveway review team only. XXX rear brake pads had been cutting into rotors a few days prior. I had to purchase a tool and pads to replace. XXX Documented loss of an additional 4 quarts of oil across 4 dates. XXX subscribed to Kia connect and the app also detected issue fault code P0597. And at a later date the app detected a 2nd fault code P0598 which went away a couple days later. May 14th finally got a hold of Justin Grable (GM Freedom) to discuss options. XXX trade-in is only option being given to me. DOCUMENTED DEFECTS & ROOT CAUSE Code P0597 (Thermostat Heater Control/Open): An electrical/mechanical failure that caused internal engine "hot spots." Engine Failure: Pre-existing piston ring tension loss causing catastrophic oil consumption (1 quart/wk). Consequential Damage: Chronic oil burning will poison the Catalytic Converters and foul all Oxygen (O2) Sensors. As of XXX my vehicle is now consuming 1 qt/day. ac is not working and now giving me 6 codes for engine light. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Constant jerking and shuttering when accelerating/shifting gears. Oil consumption done last year as dealership thought it was engine related. Engine replaced. Problem continues. Fuel in MAP sensor. Continued shuttering at acceleration, shuttering at parked idle, shuttering at braking idle, engine stalls at red lights but car stays on. When car is started, exhaust is pushing out gusts of strong fuel smell and sputtering little puffs. Replaced engine, MAP, upper intake gaskets, spark plugs, cleaned throttle body, battery. Wiper pauses mid wipe (in driving view) when in intermittent setting and when turning them off.

The contact owns a 2021 Kia Telluride. The contact stated that while driving at an undisclosed speed, the contact noticed a trail of fluid leaking. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a warped oil filter. The contact was informed that the warped oil filter needed to be replaced. The vehicle was repaired. The contact later received a warranty extension notification detailing a similar failure description. The manufacturer was made aware of the failure, a case was filed, and a reimbursement claim remained pending. The failure mileage was approximately 93,157.

Engine is consuming excessive amounts of oil between oil changes, causing valve train to produce a metallic clanking noises. Vehicle did not display any type of warning sign on dashboard. Safety concerns if Engine would seize or shut off while driving on freeway/highway becoming a hazard on the road for self and other motorist. Vehicle has been taken to dealership multiple times, dealerships first remedy was replacing the oil filter housing. Dealership claimed oil filter housing was cracked causing oil to leak. Dealership replaced under warranty. Next oil change Dealership advised me again that oil was low in the engine and recommended an oil change and to replace the EGR valve. Service advisor also said to bring the vehicle back after driving it 1000 miles so they can run an oil consumption test. Vehicle was brought back to dealership after the 1000 miles, oil consumption test confirmed engine was consuming more oil than manufacturer allowance and valve train noise did return.

NHTSA Vehicle Safety Complaint – 2021 Kia Telluride - VIN: [XXX] I am filing a safety complaint regarding my 2021 Kia Telluride. I purchased the vehicle on XXX, with approximately 124,000 miles. An oil and filter change was performed shortly before the sale. After about 2,000 miles/126K, the vehicle suddenly lost power and stopped. It was towed to a repair shop, where technicians found the engine oil level was extremely low or empty, despite no low-oil warning light appearing. The oil was serviced, and the vehicle was returned to operation. About 3,000/129K miles later, the vehicle again lost power and stopped in Ardmore TX. It was road side mobile mechanic found little to no oil and he refill the oil. After 100 miles/129.1K again same problem engine stopped and no oil. was towed to the same shop, where technicians found little to no oil and diagnosed severe engine damage requiring engine replacement. Mechanic informed there was no oil leak from the engine however, excessive oil burning in engine causing this issue. My concern is safety. On all three occasions, the vehicle lost power on the freeway at night while my family with two kids was in the vehicle. I believe excessive oil consumption and the lack of a warning before engine failure may represent a safety defect. I request that NHTSA investigate this issue and require Kia to review the vehicle’s engine design and warning systems. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)