Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1480–25K
1525–50K
1150–75K
1275–100K
6100–150K
2150K+
194 reports with mileage · 564 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Exterior Lighting. Review the 183 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility/wiper. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports9 fire reports8 injury reports
What owners actually said
758 reports
Mileage unknown · Jan 5, 2023
Visibility
The windshield cracked in the vehicle within the first few thousand miles of owning it. It was replaced by Kia via goodwill. The replacement windshield cracked less than a year later, and happened rapidly without the ability to repair before it spread. After research, it appears to be a widespread issue with the Kia Telluride…
Read full complaint
The windshield cracked in the vehicle within the first few thousand miles of owning it. It was replaced by Kia via goodwill. The replacement windshield cracked less than a year later, and happened rapidly without the ability to repair before it spread. After research, it appears to be a widespread issue with the Kia Tellurides.
NHTSA ODI #11500325
Mileage unknown · Jan 4, 2023
Exterior Lighting
I recently bought the Kia used at approximately 75000 miles. The high beams do not work and the only way to repair them is an expensive complete headlight assembly replacement. Headlights should not become defective so soon and I have read forum after forum of those with the Telluride who have experienced the same problem.
NHTSA ODI #11500230
Mileage unknown · Dec 28, 2022
Exterior LightingCrash
Hooded projector lights provide very limited vision on dark roads. We hit a deer and have significant damage to our vehicle due to this issue. Our brights do not come on either. Nothing happens when we select the bright option.
NHTSA ODI #11499167
Mileage unknown · Dec 23, 2022
Exterior Lighting
The High Beams have stopped working. This is a known issue as it can be found on many forums across the internet.
NHTSA ODI #11498649
Mileage unknown · Dec 20, 2022
Exterior Lighting
High beams not working
NHTSA ODI #11498334
45,000 miles · Dec 5, 2022
Electrical SystemExterior LightingTrailer Hitches
The contact owns a 2020 Kia Telluride. The contact received notification of NHTSA Campaign Numbers: 20V436000 (Electrical System, Forward Collision Avoidance, Exterior Lighting) and 22V626000 (Trailer Hitches) however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a re…
Read full complaint
The contact owns a 2020 Kia Telluride. The contact received notification of NHTSA Campaign Numbers: 20V436000 (Electrical System, Forward Collision Avoidance, Exterior Lighting) and 22V626000 (Trailer Hitches) however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The check engine warning light was illuminated. The contact stated that the brake pedal was firm while attempting to stop the vehicle. There was no warning light illuminated. The manufacturer was made aware of the failure. The approximate failure mileage was 45,000. Parts distribution disconnect.
NHTSA ODI #11496141
Mileage unknown · Nov 29, 2022
Suspension
My Telluride mileage just passed 30K. The rear suspension seems like no shock-absorbing capability since the car is so bumpy. The front suspension looks fine though. I went to a service center, but they told me they couldn't find any symptoms. I was shocked when I heard about that because I could see an apparent difference even …
Read full complaint
My Telluride mileage just passed 30K. The rear suspension seems like no shock-absorbing capability since the car is so bumpy. The front suspension looks fine though. I went to a service center, but they told me they couldn't find any symptoms. I was shocked when I heard about that because I could see an apparent difference even with pushing it with my hand! Strangely, there's no squicking noise. And they told me no oil leakage. But, it's bumpy. I'll try to visit the service center for the recall and ask them to check the suspension together with me. The rear suspension has the optional self-leveling shock that has a noise concern. I may need to replace them with a normal suspension.
NHTSA ODI #11495397
Mileage unknown · Nov 28, 2022
Exterior Lighting
Dim Headlights. Vehicle is available for inspection.Headlights do not illuminate the road resulting in not being able to see while driving at night. High beam lights no longer function. Vehicle was inspected and it was determined headlights would need to be replaced at owners expense. There were no warning messages that high bea…
Read full complaint
Dim Headlights. Vehicle is available for inspection.Headlights do not illuminate the road resulting in not being able to see while driving at night. High beam lights no longer function. Vehicle was inspected and it was determined headlights would need to be replaced at owners expense. There were no warning messages that high beams no longer worked.
NHTSA ODI #11495159
Mileage unknown · Nov 23, 2022
Exterior Lighting
At about 45,000 miles on the vehicle both bright lights no longer worked suddenly at the same time. I figured they had burn out so I purchased brand new bulbs for both sides at advanced auto parts. advanced auto parts installed the lightbulbs, and when I flipped the switch for brights again no bright lights. Apparently there’s a…
Read full complaint
At about 45,000 miles on the vehicle both bright lights no longer worked suddenly at the same time. I figured they had burn out so I purchased brand new bulbs for both sides at advanced auto parts. advanced auto parts installed the lightbulbs, and when I flipped the switch for brights again no bright lights. Apparently there’s an issue on the 2020 tellurides for some reason, the bright lights quit working. This is a serious safety issue, especially with it getting darker earlier and with deer running at this time of the year.
NHTSA ODI #11494732
Mileage unknown · Nov 21, 2022
Visibility
Sunroof exploded while driving. Nothing hit it, heard a loud noise while driving, thought it was a tire. Took car to KIA dealership in Chula Vista CA, they said someone from KIA headquarters is coming to inspected since they dont believe the fact that nothing hit it. Car has been there for 2 days with no answer. This claim remai…
Read full complaint
Sunroof exploded while driving. Nothing hit it, heard a loud noise while driving, thought it was a tire. Took car to KIA dealership in Chula Vista CA, they said someone from KIA headquarters is coming to inspected since they dont believe the fact that nothing hit it. Car has been there for 2 days with no answer. This claim remains to be resolved as of 11/21/22.
Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The front power seat motor may overheat due to a stuck power seat slide knob or an improper recall 24V407 repair, which can result in a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install an electronic fuse assembly, free of charge. Owner notification letters are expected to be mailed August 13, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC374. This recall replaces NHTSA recall number 24V407. Vehicles already repaired under the previous recall will need to have the new remedy completed. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning July 17, 2026.
Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The front power seat motor may overheat due to a stuck power seat slide knob, which can result in a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a bracket for the power seat switch back covers and replace the seat slide knobs, free of charge. Owner notification letters were mailed July 30, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC316.
Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The intermediate shaft and right front driveshaft may not be fully engaged, which can result in vehicle roll away while in PARK.
Consequence & remedy
Consequence: A vehicle roll away increases the risk of a crash or injury.
Remedy: Owners are advised to manually engage the emergency parking brake prior to exiting the vehicle until the recall remedy is performed. Dealers will update the electronic parking brake software and replace any damaged intermediate shafts as necessary, free of charge. Owner notification letters were mailed May 15, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC303.
Kia America, Inc. (Kia) is recalling certain 2020 Telluride vehicles. The high beam headlights may fail.
Consequence & remedy
Consequence: Inoperable high beam headlights may reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and repair or replace the high beam headlights, as necessary free of charge. Owner notification letters were mailed August 9, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC299.
Kia America, Inc. (Kia) is recalling certain 2020-2022 Telluride vehicles potentially equipped with a Genuine Kia 4-pin tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse and a wiring harness extension. Dealers will also inspect and replace the tow hitch harness assembly, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed April 12, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC247.
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.
Additional source detail variants (3)
Forward Collision Avoidance: Adaptive Cruise Control
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.
Exterior Lighting:brake Lights
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.
Electrical System:wiring
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles. The seat belt assemblies in the front passenger, second, and/or third row seats may not tightly secure a child restraint system in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash.
Remedy: Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies. The repair will also include replacing the driver's seat belt which has a non-U.S. specified label, with a U.S. specification seat belt. The repairs will be performed free of charge. The recall began August 30, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC181.
Additional source detail variants (2)
Seat Belts:rear/other
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles. The seat belt assemblies in the front passenger, second, and/or third row seats may not tightly secure a child restraint system in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence: If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash.
Remedy: Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies. The repair will also include replacing the driver's seat belt which has a non-U.S. specified label, with a U.S. specification seat belt. The repairs will be performed free of charge. The recall began August 30, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC181.
Seat Belts:front
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles. The seat belt assemblies in the front passenger, second, and/or third row seats may not tightly secure a child restraint system in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence: If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash.
Remedy: Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies. The repair will also include replacing the driver's seat belt which has a non-U.S. specified label, with a U.S. specification seat belt. The repairs will be performed free of charge. The recall began August 30, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC181.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE23002 · Complete Loss Of High Beams
Opened Jan 27, 2023 · Closed Apr 17, 2024
Status: closed (inferred from source dates) · Exterior Lighting:headlights
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23002 to investigate allegations of loss of high beams with no warning and no re-engagement resulting in reduced visibility at night in the 2020 Kia Telluride. The investigation revealed that the halogen bi-function projector beam, used in vehicles built between January 2019 and November of 2019, is composed of one halogen bulb light source that provides light for both low beam and high beam. The heat generated by the halogen bulb will inflict damage to the gear mechanism and as a result the shutter’s electric motor will no longer be able to move the shutter to the open position to reveal the high beams. A loss of high beams, prevents the driver from having proper distance illumination, therefore increasing the risk of a crash. On February 24, 2024, Kia filed recall 24V-148 for certain MY 2020 Kia Tellurides. The recall remedy provides an inspection of the high beam shield gear mechanism and will either apply a clip to secure the shield gear to the shaft or replace the headlamp assembly with one that is resistant to heat damagefrom the halogen bulb. In view of the recall action being taken by Kia, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2020 Kia Telluride Problems, Complaints & Recalls | Skip That Year
Illustration