2020 Kia Telluride

Sunroof will not close. This is a know issues that Kia is aware of, and they have created performance step for technicians and also created replacement. Consumers are having to pay out of pocket to have issues corrected. Wind deflector has broken and railling system as well. No open recall in the 2020 Kia telluride for this issue. Please view attached youtube video link of this issue. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car is a 2020 Kia Telluride. It was purchased in August 2023 at the time it was leaking oil took it back to the dealer and they replaced the housing put in a new filter and said all was good .For a year. it constantly needed oil took it back to the dealer, said that everything was fine. I would be driving and the car would stop. The oil lamp would come on and I would have to drive and put more oil in it every week. I was putting a quart of oil into the vehicle just about weekly because it seemed to be leaking oil and just a dying out. just a few days ago after putting a quart of oil in I’m driving my vehicle and all of a sudden Smoke comes out of the back a little bit out of the hood. It just stopped all the lights went on the car went dead. Had to call the police get the vehicle towed to the dealer at that point was told the engine had died. They want to put a new engine in the car Which it’s a five year-old car. It should not need a new engine what is causing it to need a newengine. Ever since I purchased the car, it had oil problems so did the oil lead to engine failure. I know I’m not the only one that this has happened to every time I would take it back to the Kia dealer. I was told everything‘s fine everything was not fine never got any warning lights or signals, except for when I was driving the car would literally sputter and stop at a light. I would have to restart it and then go get oil.

On [XXX] , my wife heard a rattling noise while driving. I verified the rattling noise on [XXX]. On [XXX], I researched online and there are a lot of 2020 Telluride owners that experienced the same issue. They mentioned they had no oil in their cars. I checked the oil that morning and confirmed my wife's car had no oil. I reviewed the manual and checked the oil again according to the instructions in the manual. The car still registered no oil in the dip stick. The car did not report any warning lights. There was no engine light or oil pressure light that came on at any point in time to indicate there was no oil in the engine. Per the instructions in the manual, I drove the vehicle carefully to the auto part store. I purchased and added 6 quarts of synthetic blend 5W 30 oil. After that, the rattling in the engine seized. I sent a text message to Kia in Alpharetta, GA. I spoke with Izzy and explained the situation and requested an appointment to have an oil consumption test performed. She advised that the oil consumption test had a $440 cost and consisted of performing a series of oil changes over the course of a specified time to determine how much oil the vehicle was burning/consuming. She said I could call consumer affairs and I asked her if she was referring to Kia consumer affairs or the national/federal consumer affairs. She verified it was the national/federal consumer affairs and provided me with this number to call 1-888-327-4236 which actually belongs to Kia's consumer affairs hotline. Izzy advised that I had pending recalls in my car and asked why I have not brought the car in. I mentioned that I live in Ball Ground, GA and the nearest Kia dealership to me is the one in Woodstock, GA. However, I stopped taking my car there because I previously took the car there to get the oil changes done and each time I did the car would have a nail in one of the tires a couple days after the service. I lost confidence in the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

My vehicle is using excessive amounts of oil. Every time I drive it, I can smell burnt oil. I took the vehicle to the dealership on 1/24/25 where they found a leak in the oil filter housing. This was repaired (same day) and the oil was topped off per the service report. After smelling the oil smell again, I checked my oil on 1/31/25 and found that the oil was marked between the min and max line on the dipstick. I have reported this to KIA and waiting to hear back. I am reading hundreds of 2020+ Telluride owners complaining of the same issue. I have had no indicator lights.

Our vehicle is 4 years old and has been experiencing excessive oil consumption (a quart every ~600 miles) and extreme shaking at speeds between 20-50mph. After months of trying to diagnose the issue we have been quoted a total engine and transmission replacement. After calling dealerships across the East coast for second opinions, this is a common diagnosis for our vehicle year and model and even within our small local dealership they are seeing other 2019 and 2020 Kia models experiencing failed piston rings. Kia declined our request for corporate intervention to address the issue.