2020 Kia Telluride

Paint failure and delamination on a 2021 Kia Telluride with Snow White Pearl (SWP) paint. The paint on the roof above the windshield and the hood has begun peeling in sheets, exposing the underlying layer. The vehicle has not been in any accidents and has never been repainted. The paint failure appears to be a manufacturing defect involving the adhesion of the factory paint. The issue began around year 4–5 of ownership at approximately 60,000 miles. The affected areas continue to expand as the paint separates from the vehicle surface. The vehicle is available for inspection. A dealership inspection appointment has been scheduled. This appears consistent with other reported cases of paint delamination on Kia vehicles with Snow White Pearl paint.

The satin window trim at the bottom the passenger and driver windows have come loose due to poor adhesive. The heat softened the glue over time and metal satin trim fell off in the middle of the expressway and the other 3 bottom trims have gotten loose due to the bad / wrong glue used to adhere them. The new model have this recall, but this issue is happening also to the 2020 SX trim. The issue is the trim is metal and it gets hot in the sun and the heat softens the glue which then over time the metal starts to separate from the plastic trim housing and fall off while driving which a can cause an accident / injury.

The sunroof malfunctioned while I was attempting to open it, producing a loud pop and causing the glass to become misaligned while the vehicle was parked. There have been numerous reports of this same issue, including incidents in which the sunroof glass has shattered. This appears to be a known defect; however, Kia has refused to acknowledge responsibility or perform the necessary repairs. Kia has quoted the cost of repair at $5,800.

Several oil housing changes. I’m not the first owner, the oil housing has been changed once already and I’m going to have to do it a second time, the car is only 5 years old. I’ve only owned the vehicle 2 years. The dealership did no diligence to check it, I went to the dealership for years and due to negligence with my oil changes and recalls I stopped going, now I’m having to pay out of pocket for issues they’ve caused. I thought I messed up my car and had a part dragging at the bottom, when I took it in to the dealership they said it was previously not bolted down properly. I had a recall, I was told 3 times my lights were connected and I was “good to go” each time I got in and the car said my lights were not connected. After this I never came back! Not sure if it’s the dealership issue or on the car for my oil housing leak.

The 2020 Kia Telluride has an issue with the metal window trim pieces. It was purchased as a Certified Pre-Owned vehicle and we have had to have the trim piece replaced at least three times by the Kia Dealer. The piece keep becoming loose and falling off. Some of the pieces on my vehicle have jus fallen off. At interstate speeds of 70 MPH it would be very dangerous. Fortunately, no incident has happened that has hurt anyone, yet. The 2023-2025 models have been recalled for this exact same issue, and it needs to happen for ALL Kia Telluride models including the 2020-2023 models. It is dangerous and Ken Ganley Kia of New Port Richey is no longer assisting with any sort of warranty or repair unless I do the work. I am having to reach out to Kia and open a case number every time and the dealership is no longer being helpful. This is our primary vehicle used for getting children to school, leisure travel, and daily commuting. Attached are three different incidents of the exact same issue happening. 8/24/2025, 8/11/2025, and 11/21/2025. The dealership also repair some when we initially purchased the vehicle. All work orders can be provided via Ken Ganley Kia of New Port Richey.

The original Telluride muffler developed a hole in the rear wall, hidden by the exhaust pipes. Within a week of the noise being noticeable I visited a car wash, afterwards someone asked me what I'd done to my rear bumper? I hadn't hit anything. When I looked, I was shocked. About 15" of the silver trimwork was torn off, still attached. Today I had the muffler replaced at Midas here in Toledo( (at a considerable cost) I asked the manager to look at the damage and told him it wasn't there until after the carwash. He said that the heat from the hole in the muffler had melted the bumper enough so that the brushes in the carwash were able to catch the edge and pull it off. Why is the muffler positioned SO CLOSE to the bumper? Tomorrow(11/18) I will visit the Taylor Kia Dealership(where I purchased the Telluride in 2020. Can there be a recall? Can future Tellurides be equiped with heat shield/different muffler placement?

Sunroof could not be retracted due to track breaking during normal operation. Repairs have been made and part is not available for inspection. Passenger safety put at risk due to exposure to rain and cold in the passenger compartment. Problem confirmed at an independent service center. Vehicle was inspected at the service center. This happened without warning. Other owners have experienced the same problem.