Exterior Lighting. Review the 183 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility/wiper. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

8 crash reports9 fire reports8 injury reports

Seats complaints

12 reports

Clear category filter

Mileage unknown · Aug 9, 2021

SeatsInjury

I dropped my phone between the seat and the console. I reached between it and got my arm caught. I tried for 15 minutes to get it out with no success. I drove myself and children to the fire station where they had to use a crowbar to push on a bar that was holding my arm. When I got my arm out, it was bloody, cut, and swollen.

NHTSA ODI #11428457

25 miles · Mar 2, 2019

Seats

Read full complaint

WHILE TEST DRIVING THE VEHICLE WE ACCELERATED THE VEHICLE AND HEARD A YELL FROM MY CHILDREN IN THE BACK ROW "THE SEAT IS CRUSHING THE BABY!". OUR 5 MONTH BABY WAS STRAPPED IN THE MIDDLE SEAT CENTER ROW AND THE BACK PART OF THE SEATS FOLDED FORWARD DISLODGING THE REAR FACING CAR SEAT AND TIPPING IT UPWARD A BIT. I HAD TO EMERGENCY STOP THE VEHICLE IN MID TRAFFIC, UNBUCKLE AND CRAWL IN THE BACK SEAT TO PUSH THE SEAT BACK OFF OF MY BABY. THIS IS A SAFETY ISSUE FOR SURE. IT IS POSSIBLE THAT THE CHILDREN IN THE BACK ROW PUSHED THE SEAT RETRACT BUTTON WHILE THE VEHICLE WAS MOVING OR THE SEAT WAS NOT LOCKED BACK IN POSITION AFTER THIRD ROW ONBOARDING DUE TO MECHANICAL FAILURE OR HUMAN ERROR. PLEASE INVESTIGATE BEFORE CHILDREN ARE INJURED OR KILLED.

NHTSA ODI #11183605

Official recalls

26V430000 · Seats:front Assembly:power Adjust

Jul 2, 2026

Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The front power seat motor may overheat due to a stuck power seat slide knob or an improper recall 24V407 repair, which can result in a fire while parked or driving.

Consequence & remedy

Consequence: A fire increases the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install an electronic fuse assembly, free of charge. Owner notification letters are expected to be mailed August 13, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC374. This recall replaces NHTSA recall number 24V407. Vehicles already repaired under the previous recall will need to have the new remedy completed. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning July 17, 2026.

24V407000 · Seats:front Assembly:power Adjust

Jun 5, 2024

Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The front power seat motor may overheat due to a stuck power seat slide knob, which can result in a fire while parked or driving.

Consequence & remedy

Consequence: A fire increases the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a bracket for the power seat switch back covers and replace the seat slide knobs, free of charge. Owner notification letters were mailed July 30, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC316.

24V214000 · Power Train:driveline:driveshaft

Mar 20, 2024

Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The intermediate shaft and right front driveshaft may not be fully engaged, which can result in vehicle roll away while in PARK.

Consequence & remedy

Consequence: A vehicle roll away increases the risk of a crash or injury.

Remedy: Owners are advised to manually engage the emergency parking brake prior to exiting the vehicle until the recall remedy is performed. Dealers will update the electronic parking brake software and replace any damaged intermediate shafts as necessary, free of charge. Owner notification letters were mailed May 15, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC303.

24V148000 · Exterior Lighting:headlights

Feb 26, 2024

Kia America, Inc. (Kia) is recalling certain 2020 Telluride vehicles. The high beam headlights may fail.

Consequence & remedy

Consequence: Inoperable high beam headlights may reduce visibility, increasing the risk of a crash.

Remedy: Dealers will inspect and repair or replace the high beam headlights, as necessary free of charge. Owner notification letters were mailed August 9, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC299.

22V626000 · Trailer Hitches

Aug 15, 2022

Kia America, Inc. (Kia) is recalling certain 2020-2022 Telluride vehicles potentially equipped with a Genuine Kia 4-pin tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Consequence & remedy

Consequence: A fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse and a wiring harness extension. Dealers will also inspect and replace the tow hitch harness assembly, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed April 12, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC247.

20V436000 · Electrical System:wiring; Exterior Lighting:brake Lights; Forward Collision Avoidance: Adaptive Cruise Control

Jul 28, 2020

Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.

Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.

Additional source detail variants (3)

Forward Collision Avoidance: Adaptive Cruise Control

Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.

Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.

Exterior Lighting:brake Lights

Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.

Electrical System:wiring

Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.

19V594000 · Seat Belts:front; Seat Belts:rear/other

Aug 13, 2019

Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles. The seat belt assemblies in the front passenger, second, and/or third row seats may not tightly secure a child restraint system in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash.

Remedy: Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies. The repair will also include replacing the driver's seat belt which has a non-U.S. specified label, with a U.S. specification seat belt. The repairs will be performed free of charge. The recall began August 30, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC181.

Additional source detail variants (2)

Seat Belts:rear/other

Consequence: If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash.

Remedy: Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies. The repair will also include replacing the driver's seat belt which has a non-U.S. specified label, with a U.S. specification seat belt. The repairs will be performed free of charge. The recall began August 30, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC181.

Seat Belts:front

Consequence: If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE23002 · Complete Loss Of High Beams

Opened Jan 27, 2023 · Closed Apr 17, 2024

Status: closed (inferred from source dates) · Exterior Lighting:headlights

On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23002 to investigate allegations of loss of high beams with no warning and no re-engagement resulting in reduced visibility at night in the 2020 Kia Telluride. The investigation revealed that the halogen bi-function projector beam, used in vehicles built between January 2019 and November of 2019, is composed of one halogen bulb light source that provides light for both low beam and high beam. The heat generated by the halogen bulb will inflict damage to the gear mechanism and as a result the shutter’s electric motor will no longer be able to move the shutter to the open position to reveal the high beams. A loss of high beams, prevents the driver from having proper distance illumination, therefore increasing the risk of a crash. On February 24, 2024, Kia filed recall 24V-148 for certain MY 2020 Kia Tellurides. The recall remedy provides an inspection of the high beam shield gear mechanism and will either apply a clip to secure the shield gear to the shaft or replace the headlamp assembly with one that is resistant to heat damagefrom the halogen bulb. In view of the recall action being taken by Kia, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.