2006 Kia Sportage

TL* THE CONTACT OWNS A 2006 KIA SPORTAGE. THE CONTACT STATED THAT THE ELECTRIC CONTROL HARNESS FAILED. WHILE DRIVING 60 MPH, THE VEHICLE DECELERATED TO 30 MPH AND THEN ACCELERATED BACK TO NORMAL. IN ADDITION, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO HERTRICH KIA (6546 OCEAN GATEWAY, EASTON, MD 21601, (410) 200-9784) WHERE IT WAS DIAGNOSED THAT THE ELECTRIC CONTROL HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO THE REPAIR FEES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 137,723. *BF*JB

TL* THE CONTACT OWNS A 2006 KIA SPORTAGE. THE CONTACT STATED THAT THE BRAKE LIGHTS REMAINED ILLUMINATED INDEPENDENTLY WHEN THE VEHICLE WAS TURNED OFF AND STATIONARY. IN ADDITION, THE ESC WARNING INDICATOR REMAINED ILLUMINATED AND THE CRUISE CONTROL WAS NOT WORKING. THE CONTACT ALSO STATED THAT IN ORDER TO TURN OFF THE BRAKE LIGHTS, HE HAD TO DISCONNECT THE VEHICLE'S BATTERY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 09V130000 (EXTERIOR LIGHTING), BUT THE VIN WAS EXCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 240,000.

BACK IN MAY OF THIS YEAR, I HEARD OF A RECALL FOR GAS TANK STRAPS ON MY CAR - SO CALLED KIA AND THEY SAID TANK STRAPS HAD BEEN RECALLED AND CORROSION PROTECTION (UNDERCOATING) WAS ALSO A REMEDY THAT WAS COVERED BY THE RECALL. I ARRANGED RECALL SERVICE AT CLOSEST DEALER (1 1/2 HOURS AWAY) WHO ORDERED THE TANK STRAPS FOR ME. UNFORTUNATELY, ONCE AT THE DEALERSHIP, THE SERVICE TECH SAID THAT HE COULD NOT REPLACE THE STRAPS BECAUSE HE WAS CONCERNED THAT THE GAS TANK "WOULD FALL APART DUE TO CORROSION ALONG THE WELDED SEAM OF THE TANK" A COMMON PROBLEM KNOWN TO KIA. BECAUSE THE TECH DID NOT HAVE A NEW TANK IN STOCK, I ASKED HIM IF HE COULD GET ONE FROM A JUNK YARD, HE SAID THAT SUCH A USED TANK "WOULD LIKELY HAVE THE SAME PROBLEM." I HAVE BEEN TRYING TO GET KIA TO REPLACE THE STRAPS AND TANK AT THEIR EXPENSE AND TO FOLLOW-UP WITH UNDERCOATING AS THEY ARE OBLIGATED TO DO - FOR MONTHS! I HAVE CALLED KIA CONSUMER AFFAIRS AND KIA AMERICA MANAGEMENT IN IRVINE CA MULTIPLE TIMES OVER THE PAST MONTHS. THE ONLY RESPONSE I HAVE HAD THUS FAR WAS FROM JESSICA WEAVER OF KIA'S CONSUMER AFFAIRS DEPT (520 772 4714) MS WEAVER HAS REPEATEDLY REQUESTED THAT I GIVE HER MORE TIME AND SHE REPEATEDLY FAILS TO FOLLOW-THROUGH ON HER COMMITMENTS TO CALL BACK. MY LATEST CONTACT FROM HER WAS TWO WEEKS AGO WHERE SHE AGAIN REQUESTED MORE TIME (FIVE DAYS) TO RESOLVE THE ISSUE - - I AGAIN NEVER HEARD BACK FROM MS WEAVER. WHAT MS WEAVER HAS CONVEYED TO ME IS THAT THE REGIONAL PARTS AND SERVICE MANAGER NEEDS TO APPROVE THE REPAIR AND REVIEW THE PHOTOS THAT WERE TAKEN OF THE GAS TANK ...AND SHE CANNOT GET TO HIM. I HAVE REPEATEDLY RESPONDED THAT THERE MUST BE SOMEONE AT KIA WHO CAN APPROVE THE REPAIR. MY SENSE IS THAT THIS POOR WOMAN HAS BEEN TOLD TO JERK ME AROUND UNTIL I GIVE UP ...THIS WILL NOT HAPPEN. THANKS FOR YOUR HELP IN GETTING KIA TO MEET THEIR OBLIGATION. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

PREVIOUSLY REPORTED ENGINE SURGES / ERRATIC IDLE AT 177800 MILES, AND THROTTLE BODY CLEANED AT 177900 MILES. AT 178345 THE IDLE AIR CONTROL VALVE WAS CLEANED AS A PRECAUTION, DUE TO THE PREVIOUS SYMPTOMS. AT 178377 WHILE DRIVING ON THE HIGHWAY I FOUND THE THROTTLE STUCK IN THE FULL OPEN POSITION. AFTER SAFELY STOPPING THE VEHICLE, I HAD TO MANUALLY RETURN THE THROTTLE TO THE NORMAL POSITION. UPON RESTARTING THE VEHICLE I BEGAN EXPERIENCING ERRATIC IDLING 3000 TO 4000 RPM. ONCE PARKED AT 178382 THE IDLE AIR CONTROL VALVE WAS RECHECKED, AND ENGINE IDLE RPM RETURNED TO NORMAL. I CHECKED THE OBDII AND FOUND NO PREVIOUS OR PENDING CODES. I WILL REPLACE THE IDLE AIR CONTROL VALVE.

I PREVIOUSLY REPORTED AT 177,800 MILES THAT I WAS EXPERIENCING ENGINE SURGES. WHILE DRIVING IF I DEPRESSED THE CLUTCH ENGINE WOULD RISE TO 2000 RPMS. IF I PULLED THE ACCELERATOR PEDAL UP WITH TIP OF MY FOOT, THE ENGINE RPMS WOULD RETURN NORMAL. AT 177, 900 MILES THE THROTTLE BODY ASSEMBLY WAS CLEANED, AND I AM NO LONGER EXPERIENCING ENGINE SURGES.

WHILE BRAKING THE VEHICLE APPEARED TO BE PICKING UP SPEED. WHEN I DEPRESSED THE CLUTCH THE ENGINE SURGED PAST 2000 RPM. WHILE DRIVING ON A DOWNGRADE THE VEHICLE WAS PICKING UP SPEED, AND I DEPRESSED THE CLUTCH AND THE ENGINE RPM WENT 2000 RPM FOR SEVERAL SECONDS. FROM MY EXPERIENCES WITH OTHER VEHICLES I THOUGHT: MAYBE THE DRIVER'S MAT SHIFTED, OR SOME OTHER OBJECT MAY HAVE FALLEN AND WAS INTERFERING WITH THE ACCELERATOR PEDAL. I FELT AROUND THE PEDAL WITH MY FOOT, BUT FOUND NO FOREIGN OBJECTS. I USED THE TIP OF MY FOOT TO MAKE THE ACCELERATOR PEDAL WAS UP ALL THE WAY, AND THEN ENGINE RPM APPEARED TO GO TO NORMAL. WHEN I REACHED MY DESTINATION I TAPPED ON THE ACCELERATOR PEDAL A FEW TIMES TO RE-CREATE THE PROBLEM. THE ENGINE WENT TO 2000 RPM FOR ABOUT 3 SECONDS, AND CAME BACK DOWN. I CHECKED FOR ANY CODES USING AN OBD II SCANNER, HOWEVER NONE WERE FOUND.

I HAD THIS ISSUE MULTIPLE TIMES. AND THE DEALER COULDN'T FIND THE PROBLEM SO THEY ONLY DELETE THE ERROR. THE FIRS ISSUE IS THE PASSENGER AIR BAG (AIRBAG LIGHT ERROR) THE ERROR SEEMS TO BE THE SENSOR INSIDE THE SEAT.. AND THE SECOND ERROR THE SPEEDOMETER IS NOT SHOWING THE CORRECT SPEED. THE SPEEDOMETER IS READING ABOUT 5 MILE OFF.