TL*THE CONTACT OWNS A 2001 KIA SPORTAGE. WHILE DRIVING APPROXIMATELY 30 MPH, A CRACK FORMED IN THE EXHAUST MANIFOLD. THE STABILIZER BAR DISCONNECTED FROM THE RIGHT BALL JOINT WHILE TRAVELING AT APPROXIMATELY 5 MPH; AT THAT POINT, THE CONTACT WAS UNABLE TO TURN THE STEERING WHEEL TO THE LEFT. THERE WERE NO WARNINGS BEFORE THE FAI…
Read full complaint
TL*THE CONTACT OWNS A 2001 KIA SPORTAGE. WHILE DRIVING APPROXIMATELY 30 MPH, A CRACK FORMED IN THE EXHAUST MANIFOLD. THE STABILIZER BAR DISCONNECTED FROM THE RIGHT BALL JOINT WHILE TRAVELING AT APPROXIMATELY 5 MPH; AT THAT POINT, THE CONTACT WAS UNABLE TO TURN THE STEERING WHEEL TO THE LEFT. THERE WERE NO WARNINGS BEFORE THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED BUT NO REPAIRS HAD BEEN PERFORMED WHEN THE COMPLAINT WAS FILED. THE CURRENT MILEAGE WAS APPROXIMATELY 121,600. THE FAILURE MILEAGE WAS APPROXIMATELY 121,500. UPDATED 05/18/10. *LJ
NHTSA ODI #10323365
768 miles · Mar 29, 2005
Electrical SystemEngine And Engine CoolingEquipment
2001 KIA SPORTAGE SUFFERED TWO COMPLETE ENGINE FAILURES.*MR ALONG WITH THE ENGINE FAILURES, THERE WERE PROBLEMS WITH THE RADIO, BATTERY AND THE TERMINALS, FRONT BRAKES, A SENSOR KNOCK, EXHAUST SYSTEM, AIR CONDITION, VALVE COVER GASKET, FRONT WHEEL BEARINGS, FRONT PADS AND ROTORS, CRUISE CONTROL, AND A DEFECTIVE IDLER ARM. *JB
NHTSA ODI #10117452
Mileage unknown · Mar 10, 2005
Electrical SystemEngine And Engine CoolingEquipment
2001 KIA SPORTAGE, STOPPED DEAD IN THE MIDDLE OF A MAJOR HIGHWAY. *BF THE CONSUMER WAS UNABLE TO GET A FULL ALIGNMENT BECAUSE THE IDLER WAS DEFECTIVE, ON 2 OCCASIONS THE VEHICLE WOULD NOT START AND IT HAD TO BE JUMP STARTED, WHICH WAS DUE TO DEFECTIVE BATTERY TERMINALS, THE RADIO, FONT BRAKES EXHAUST SYSTEM, AIR CONDITION VAL…
Read full complaint
2001 KIA SPORTAGE, STOPPED DEAD IN THE MIDDLE OF A MAJOR HIGHWAY. *BF THE CONSUMER WAS UNABLE TO GET A FULL ALIGNMENT BECAUSE THE IDLER WAS DEFECTIVE, ON 2 OCCASIONS THE VEHICLE WOULD NOT START AND IT HAD TO BE JUMP STARTED, WHICH WAS DUE TO DEFECTIVE BATTERY TERMINALS, THE RADIO, FONT BRAKES EXHAUST SYSTEM, AIR CONDITION VALVE COVER GASKET, FRONT WHEEL BEARING, CRUISE CONTROL WERE ALL INOPERATIVE, THE VEHICLE HAS HAD 2 ENGINE REPLACEMENTS, AND THE DRIVE BELTS WERE OUT OF TENSION. *JB
NHTSA ODI #10115127
Mileage unknown · Apr 11, 2003
Steering
VEHICLE WAS UNSAFE FOR THE DRIVER, PASSENGERS AND OTHER MOTORISTS ON THE ROAD. WHILE DRIVING TWICE, CONSUMER LOSS CONTROL OF THE VEHICLE, AND WAS NEARLY INVOLVED IN COLLISION. *AK *JB *TS
NHTSA ODI #10015307
Mileage unknown · Dec 31, 2001
Steering
POWER STEERING IS HARD TO TURN AT TIMES, ESPECIALLY WHEN COLD FROM PARALLEL PARKING SPOT. DEALER SAID THEY COULD NOT FIND PROBLEM. PROBLEM UNRESOLVED. *AK
NHTSA ODI #756238
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ03007 · Seat Belt Buckle False Latch/malfunction
Opened Oct 14, 2003 · Closed Feb 27, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES INDICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.
Illustration