IllustrationDRIVER PASSED OUT MAKING LEFT TURN GOING 5 MPH AND HIT THE CONCRETE POLE FOR THE TRAFFIC LIGHT ON THE EAST SIDE OF U.S. 19. *TR
2007 Kia Spectra
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2007 Kia Spectra do not stand out strongly from the model-year median of 96.
About this comparison →How this year compares
Owner complaints by model year
Compare all Spectra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
270–25K
2125–50K
2550–75K
2275–100K
22100–150K
5150K+
122 reports with mileage · 30 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports6 fire reports15 injury reports
What owners actually said
152 reportsI REPORTED MULTIPLE COMPLAINTS ON FUEL TANK OVER FILLING, TANK WAS REPLACED BUT PROBLEM STILL EXISTS. LOST OF POWER WHEN DRIVING AND EXHILARATION WHEN TRYING TO STOP. ALSO HAVE PROBLEMS WITH ENGINE,ENGINE WAS REPLACED BUT PROBLEM STILL EXISTS. *TR
FRONT PASSENGER SEAT FAILED TO REGISTER AN ADULT IN SEAT AND "PASSENGER AIR BAG OFF" LIGHT REMAINED ILLUMINATED. TWO DAYS LATER THE AIR BAG WARNING LIGHT ILLUMINATED AND "PASSENGER AIR BAG OFF" WOULD NOT STAY ON WHEN SEAT WAS EMPTY. KIA DEALERSHIP DETERMINED IT WAS A FAILED OCCUPANT SENSOR MAT. APPROXIMATE COST OF REPAIR IS $1…
Read full complaint
FRONT PASSENGER SEAT FAILED TO REGISTER AN ADULT IN SEAT AND "PASSENGER AIR BAG OFF" LIGHT REMAINED ILLUMINATED. TWO DAYS LATER THE AIR BAG WARNING LIGHT ILLUMINATED AND "PASSENGER AIR BAG OFF" WOULD NOT STAY ON WHEN SEAT WAS EMPTY. KIA DEALERSHIP DETERMINED IT WAS A FAILED OCCUPANT SENSOR MAT. APPROXIMATE COST OF REPAIR IS $1500. *TR
THE AIR BAG WARNING LIGHT ILLUMINATED WHILE AN ADULT PASSENGER WAS IN THE FRONT SEAT. DURING A VISIT TO OUR LOCAL KIA DEALERSHIP WE WERE TOLD THE AIRBAG SENSOR MAT IN THE PASSENGER SEAT WAS DEFECTIVE AND THE SEAT (WHERE THE MODULE WAS LOCATED) NEEDED TO BE REPLACED. COST $1008 FOR THE PART, AND $222 FOR LABOR. SINCE THE 60,00…
Read full complaint
THE AIR BAG WARNING LIGHT ILLUMINATED WHILE AN ADULT PASSENGER WAS IN THE FRONT SEAT. DURING A VISIT TO OUR LOCAL KIA DEALERSHIP WE WERE TOLD THE AIRBAG SENSOR MAT IN THE PASSENGER SEAT WAS DEFECTIVE AND THE SEAT (WHERE THE MODULE WAS LOCATED) NEEDED TO BE REPLACED. COST $1008 FOR THE PART, AND $222 FOR LABOR. SINCE THE 60,000 MILE WARRANTY HAD EXPIRED, THERE WAS NO WARRANTY COVERAGE. WHEN WE CONTACTED THE KIA MOTOR CORPORATION TO ASK FOR FINANCIAL ASSISTANCE WITH THIS REPAIR, WE WERE TOLD THERE WAS NOTHING THEY COULD DO. AN AIR BAG SENSOR SHOULD NOT BE CONSIDERED A WEAR-AND TEAR ITEM. IT IS ABSURD THAT KIA WOULD REQUIRE THE CONSUMER TO COVER THE COST OF REPLACING A DEFECTIVELY DESIGNED SAFETY COMPONENT. THERE SHOULD BE A RECALL FOR THIS COMPONENT AND REPLACEMENT AT NO COST FOR THOSE OWNERS WHOSE AIR BAG SENSORS ARE FOUND TO BE DEFECTIVE. *TR
OVER THE PAST TWO YEARS, MY KIA HAS STALLED MULTIPLE TIMES UPON REFUELING. I NEVER TOPPED OFF WHILE FUELING AND DO NOT UNDERSTAND WHAT'S GOING ON. THE CAR CUTS OFF WHILE DRIVING OR SITTING AT A STOP LIGHT. IT ALSO GIVES OFF AN AWFUL GAS SMELL. I AM TERRIFIED OF DRIVING THE VEHICLE BECAUSE IT'S VERY DANGEROUS ESPECIALLY ON HIG…
Read full complaint
OVER THE PAST TWO YEARS, MY KIA HAS STALLED MULTIPLE TIMES UPON REFUELING. I NEVER TOPPED OFF WHILE FUELING AND DO NOT UNDERSTAND WHAT'S GOING ON. THE CAR CUTS OFF WHILE DRIVING OR SITTING AT A STOP LIGHT. IT ALSO GIVES OFF AN AWFUL GAS SMELL. I AM TERRIFIED OF DRIVING THE VEHICLE BECAUSE IT'S VERY DANGEROUS ESPECIALLY ON HIGHWAYS WHERE THE SPEED LIMIT IS AT LEAST 50MPH. I AM CONCERNED AS I HAVE VERY SMALL CHILDREN THAT COULD BE HARMED. I HAVE RESEARCHED THIS ISSUE TO THE BEST OF MY ABILITY & FIND MANY KIA OWNERS WITH THE SAME PROBLEM. I AM CONSTANTLY GIVEN DIFFERENT DIAGNOSTICS FROM SERVICE CENTERS. *TR
THIS CAR ACTS LIKE ITS RUNNING OUT OF GAS ABOUT EVERY 4 MONTHS SINCE I'VE OWNED IT, ITS USUALLY AFTER I FILL IT UP, IT STALLS AT LIGHTS AND SPUTTERS GOING DOWN THE ROAD, HAVE ACTUALLY HAD IT DIE GOING AROUND CORNERS. MENTION IT EVERY TIME I GO TO DEALERSHIP FOR MAINTENANCE AND OF COURSE THERE IS NO CODE BECAUSE THE CHECK ENGIN…
Read full complaint
THIS CAR ACTS LIKE ITS RUNNING OUT OF GAS ABOUT EVERY 4 MONTHS SINCE I'VE OWNED IT, ITS USUALLY AFTER I FILL IT UP, IT STALLS AT LIGHTS AND SPUTTERS GOING DOWN THE ROAD, HAVE ACTUALLY HAD IT DIE GOING AROUND CORNERS. MENTION IT EVERY TIME I GO TO DEALERSHIP FOR MAINTENANCE AND OF COURSE THERE IS NO CODE BECAUSE THE CHECK ENGINE LIGHT NEVER COMES ON WHEN IT HAPPENS. THIS IS A VERY UNSAFE CAR AND IF I COULD BUY SOMETHING ELSE I WOULD. WILL NEVER BUY A KIA AGAIN! *TR
I HAVE ALWAYS HAD A PROBLEM WITH THE PASSENGER SIDE AIRBAG LIGHT, NO MATTER THE WEIGHT OF THE PERSON IT SOMETIMES SAYS ITS OFF. HAVE TAKEN IT TO DEALER AND THEY HAVE NO SOLUTION, THEY CANNOT EVEN DIAGNOSE IT BECAUSE THERE IS NO ERROR CODE STORED. THIS IS SUPPOSED TO BE A SAFE CAR AND IT SCARES ME TO EVEN DRIVE WITH A PASSENGER.…
Read full complaint
I HAVE ALWAYS HAD A PROBLEM WITH THE PASSENGER SIDE AIRBAG LIGHT, NO MATTER THE WEIGHT OF THE PERSON IT SOMETIMES SAYS ITS OFF. HAVE TAKEN IT TO DEALER AND THEY HAVE NO SOLUTION, THEY CANNOT EVEN DIAGNOSE IT BECAUSE THERE IS NO ERROR CODE STORED. THIS IS SUPPOSED TO BE A SAFE CAR AND IT SCARES ME TO EVEN DRIVE WITH A PASSENGER. NEED TO HAVE A RECALL. *TR
FRONT PASSENGER SEAT AIR BAG SENSOR IS DEFECTIVE. WEIGHT SENSOR ON DASH WILL NOT WORK AND THE AIR BAG SYMBOL IS TURNED ON THE DASH. *TR
TL* THE CONTACT OWNS A 2007 KIA SPECTRA. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG WARNING INDICATOR ILLUMINATED, WHICH INDICATED THAT THE AIR BAG WAS DEACTIVATED. THE INDICATOR HAD BEEN ILLUMINATED SINCE THE VEHICLE WAS BOUGHT BRAND NEW. THE DEALER COULD NOT DUPLICATE THE FAILURE. WHEN THE VEHICLE WAS TAKEN IN FOR INSP…
Read full complaint
TL* THE CONTACT OWNS A 2007 KIA SPECTRA. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG WARNING INDICATOR ILLUMINATED, WHICH INDICATED THAT THE AIR BAG WAS DEACTIVATED. THE INDICATOR HAD BEEN ILLUMINATED SINCE THE VEHICLE WAS BOUGHT BRAND NEW. THE DEALER COULD NOT DUPLICATE THE FAILURE. WHEN THE VEHICLE WAS TAKEN IN FOR INSPECTION, THE MECHANIC DISCOVERED THAT THE DRIVER SIDE CLUSTER INDICATOR ON THE AIR BAG WAS CONSTANTLY ILLUMINATED. THE VEHICLE FAILED THE INSPECTION. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 10.
TL* THE CONTACT OWNS A 2007 KIA SPECTRA. THE CONTACT STATED THAT AFTER REFUELING, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE WAS RESTARTED AND THE FAILURE HAD OCCURRED ONCE BEFORE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL CANISTER…
Read full complaint
TL* THE CONTACT OWNS A 2007 KIA SPECTRA. THE CONTACT STATED THAT AFTER REFUELING, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE WAS RESTARTED AND THE FAILURE HAD OCCURRED ONCE BEFORE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL CANISTER AND FUEL VALVE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 68,000. THE VIN WAS NOT AVAILABLE.
Official recalls
111V256000 · Fuel System, Other:storage:tank Assembly:mounting
Apr 25, 2011
KIA IS RECALLING CERTAIN MODEL YEAR 2004-2007 SPECTRA LD VEHICLES MANUFACTURED FROM NOVEMBER 7, 2003, THROUGH MARCH 6, 2007, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. THERE IS A POSSIBILITY THAT CORROSION OF THE FUEL TANK STRAPS WHICH HOLD THE TANK MAY OCCUR AS A RESULT OF PROLONGED EXPOSURE TO ROAD SALT. AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY SEPARATE ALLOWING THE FUEL TANK TO CONTACT THE GROUND AND POSSIBLY DISRUPT THE INTEGRITY OF THE TANK.
Consequence & remedy
Consequence: THE FUEL TANK CAN FALL FROM THE VEHICLE AND STRIKE THE GROUND WHICH COULD CAUSE A FUEL LEAK. LEAKING FUEL CAN CREATE A FIRE HAZARD.
Remedy: DEALERS WILL REPLACE THE FUEL TANK STRAPS AND ATTACHING HARDWARE WITH NEW ZINC COATED PARTS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 6, 2011. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE15031 · Occupant Classification System
Opened Sep 1, 2015 · Closed Feb 11, 2016
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:sensor:occupant Classification
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Additional source detail variants (4)
Air Bags:frontal
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags:frontal:sensor/control MODULE-INACTIVE
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags:sensor:occupant Classification
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,