IllustrationPassenger Air bag sensor light has come on and stayed on. Took to AutoZone and have them put it on the code reader and said it was something faulty in the sensor mat under the seat.
2007 Kia Spectra
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2007 Kia Spectra do not stand out strongly from the model-year median of 96.
About this comparison →How this year compares
Owner complaints by model year
Compare all Spectra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
270–25K
2125–50K
2550–75K
2275–100K
22100–150K
5150K+
122 reports with mileage · 30 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports6 fire reports15 injury reports
What owners actually said
152 reportsI purchased my 2007 Spectra5 used with 155,000 miles on it. The engine had no codes or any stored codes. It ran fine until I filled it up with gas. I DO NOT overfill the tank because I understand EVAP issues. After filling up the vehicle would stall at idle and occasionally lose power (momentarily) at highway speeds (55 m…
Read full complaint
I purchased my 2007 Spectra5 used with 155,000 miles on it. The engine had no codes or any stored codes. It ran fine until I filled it up with gas. I DO NOT overfill the tank because I understand EVAP issues. After filling up the vehicle would stall at idle and occasionally lose power (momentarily) at highway speeds (55 mph and up). Obviously this is an extremely dangerous situation! Once the gas level got below 1/2 tank the issues went away…but now I ONLY fill the tank to halfway and the problems arise again every so often. Since there are no codes present I cannot replicate the issue without possibly damaging components further and I already replaced the battery, plugs, IAC valve, MAF sensor, and oil to try to remedy this problem. From reading other’s comments about this same problem I do not want to keep pouring money into a problem that KIA itself seems unable, and unwilling, to fix. This is extremely frustrating and dangerous as occasionally the vehicle loses all power on the highway at speeds exceeding 55mph and I feel an accident is inevitable. I’m not financially well off enough to just eat the cost of this vehicle and get a new (used) vehicle though so KIA has really put me (AND OTHER DRIVERS) in a difficult and dangerous position. As others have stated from mechanics who have tried to diagnose this issue, there may be a serious issue with the EVAP system including, but not limited to, the charcoal canister and purge valve. I will try replacing the fuel filter in the gas tank but I do not have high hopes that this will fix this problem. Once again, there are no codes present before or after these stalling/power loss problems and live data from and OBD2 scanner is within parameters for this vehicle and it’s age. I need to report this now so everyone, ESPECIALLY KIA, is aware of this issue and information.
I first noticed my air bag light (the one by the clock) coming on and off when my granddaughters weight went from under weight to appropriate weight to ride in the front seat. It would come on and off as she would adjust herself or move around in the seat. Sometimes it would stay on or sometimes it would stay off. When that ligh…
Read full complaint
I first noticed my air bag light (the one by the clock) coming on and off when my granddaughters weight went from under weight to appropriate weight to ride in the front seat. It would come on and off as she would adjust herself or move around in the seat. Sometimes it would stay on or sometimes it would stay off. When that light stopped coming on and off the one in the dash console where the speedometer is, that light has been coming on and staying on warning there's a problem with the airbag according to the manual. I entered my VIN number because I know Kia has had problems with some of there airbags but my VIN number was not listed. I did go by an auto parts house to make sure that was indeed the airbag warning light and I was told that the airbag may or maynot go off in a cash or it could go off at anytime. THIS IS VERY DANGEROUS if I was told correctly and felt that this needed to be looked into further. Thank You
I was drive my 2007 Kia Spectra EX in Bakersfield, CA. All of a sudden I parked my car at the gas station, I filled the car up, and I tried putting the transmission into drive but the car would not go forward. I went and searched why the car would not go forward, and I found out other Kia Spectra owners had the same problem. Is…
Read full complaint
I was drive my 2007 Kia Spectra EX in Bakersfield, CA. All of a sudden I parked my car at the gas station, I filled the car up, and I tried putting the transmission into drive but the car would not go forward. I went and searched why the car would not go forward, and I found out other Kia Spectra owners had the same problem. Is there any way to make Kia recall those cars and replace or repair the transmissions under a national recall.
Doors LOCK and UNLOCK on their own. I have been locked out numerous times, some with the engine still running.I brought car to Kia numerous times, and was told there was nothing that could be done, it was a manufacturing defect. I feel this could prevent a very serious problem , both in a collision, or if a child were to be loc…
Read full complaint
Doors LOCK and UNLOCK on their own. I have been locked out numerous times, some with the engine still running.I brought car to Kia numerous times, and was told there was nothing that could be done, it was a manufacturing defect. I feel this could prevent a very serious problem , both in a collision, or if a child were to be locked in the car. At times the car locks by itself so quickly, I cannot even turn the key fast enough to open the door. I have owned this car since 2009, and it has happened at least 50 or more times.
I WAS SHOPPING AT THE GROCERY STORE AND AS I AM BACKING OUT OF THE PARKING SPACE, MY STEERING WHEEL BECAME VERY VERY STIFF AS I CUT THE WHEEL TO POSITION MY CAR TO MOVE FORWARD. I WAS ABLE TO DRIVE FORWARD, BUT WHEN MAKING A RIGHT OR LEFT TURN THE STEERING WHEEL WAS VERY RESISTANT TO THE POINT THAT I ACTUALLY HAD TO TURN THE WHE…
Read full complaint
I WAS SHOPPING AT THE GROCERY STORE AND AS I AM BACKING OUT OF THE PARKING SPACE, MY STEERING WHEEL BECAME VERY VERY STIFF AS I CUT THE WHEEL TO POSITION MY CAR TO MOVE FORWARD. I WAS ABLE TO DRIVE FORWARD, BUT WHEN MAKING A RIGHT OR LEFT TURN THE STEERING WHEEL WAS VERY RESISTANT TO THE POINT THAT I ACTUALLY HAD TO TURN THE WHEEL ALL THE WAY TO RIGHT OR LEFT TO MAKE MY TURN.ON 3/10/2020, I TOOK MY CAR TO THE MECHANIC AND AT FIRST I WAS TOLD I NEED THE BELTS FOR A/C, ALT AND PS, REPLACED WHICH I AUTHORIZE AND PAID $171.60 TAX INCLUDED. ON 3/26/2020 I HAD TO RETURN MY CAR TO THE MECHANIC DUE TO SAME HARD TO STEER PROBLEM. I WAS THEN TOLD I NEEDED TO HAVE MY POWER STEERING PUMP REPLACED WHICH I AUTHORIZED AND PAID $353.93 TAX INCL. NEXT ON 4/7/20 THE SAME PROBLEM OF STEERING HAPPENED. I TOOK IT BACK TO MECHANIC AND WAS TOLD I NEEDED A RACK AND PINION (P/S RACK), AT A COST OF $848.63 TOTAL, WHICH I PAID. I HAD TO TAKE IT BACK FOR THE SAME PROBLEM ON 7/14/202 AND 8/17/2020 AND 9/16/2020. I WAS NOT CHARGED THE LAST THREE DATES OF REPAIR. I RECENTLY GOOGLE SEARCHED FOR RECALLS AND SAW THAT THE 2007 KIA SPECTRE HAD INDEED BEEN RECALLED. I CALLED 800-333-4542 AND WAS TOLD MY VIN NUM SHOWS NO SERVICE CAMPAIGN. I CONTEST THEIR FINDINGS I WOULD LIKE MY COMPLAINT TO BE INVESTIGATED. I AM ALSO REQUESTING A TOTAL REIMBURSEMENT OF $1374.16. THANK YOU, [XXX]. I LOOK FORWARD TO HEARING FROM YOU. REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *CC
THE 2007 KIA SPECTRA WAS IN MOTION ON THE HIGHWAY AND WAS IN AN ACCIDENT WITH MAJOR IMPACT. THE AIRBAG DID NOT DEPLOY. THE KIA HIT ANOTHER CAR AND HAD MAJOR DAMAGES.
PASSENGER SIDE OCS SENSOR FAILING.
WHEN STOPPED (FOR EXAMPLE AT A STOP SIGN), WITH THE CAR IN DRIVE AND THE ENGINE RUNNING, THE ENGINE WILL SOMETIMES GO FROM "IDLE" TO A HIGHER SPEED (IT ACCELERATES). MY FOOT WAS NOT ON THE BRAKE AND GAS PEDALS AT THE SAME TIME AND THIS IS NOT AN ISSUE WITH THE FLOOR MAT. (I KNOW BECAUSE I LOOKED.)
ENGINE 💡 CAME ON IMIDIATELY AFTER PULLING OUT OF DEALERSHIP. SO I CA"ED THEM AND THEY STATED IT WASNT ANYTHING TO WORRY ABOUT. SEVERAL CUSTOMERS WERE CALLING IN ABOUT THE SAME ISSUE. THEY SAID IT WAS JUST THE CHANGE IN WEATHER AND THE GAS CAP. THEY RESET ENGINE 💡 SEVERAL TIMES. NO SOONER THAN I WOULD PULL OF…
Read full complaint
ENGINE 💡 CAME ON IMIDIATELY AFTER PULLING OUT OF DEALERSHIP. SO I CA"ED THEM AND THEY STATED IT WASNT ANYTHING TO WORRY ABOUT. SEVERAL CUSTOMERS WERE CALLING IN ABOUT THE SAME ISSUE. THEY SAID IT WAS JUST THE CHANGE IN WEATHER AND THE GAS CAP. THEY RESET ENGINE 💡 SEVERAL TIMES. NO SOONER THAN I WOULD PULL OFF THE LOT, IT WOULD COME BACK ON. THEN I ASK THEM FOR AN AUTO CHECK HISTORY REPORT SHOWING ODOMETER DESCIIPANCIES. ROLL BACK CALCULATIONS. THE RADIATOR IS CRACKED, THE EMERGENCY BRAKE DOESN'T WORK, AND THE BRAKES AND STUFF ARE BAD.
Official recalls
111V256000 · Fuel System, Other:storage:tank Assembly:mounting
Apr 25, 2011
KIA IS RECALLING CERTAIN MODEL YEAR 2004-2007 SPECTRA LD VEHICLES MANUFACTURED FROM NOVEMBER 7, 2003, THROUGH MARCH 6, 2007, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. THERE IS A POSSIBILITY THAT CORROSION OF THE FUEL TANK STRAPS WHICH HOLD THE TANK MAY OCCUR AS A RESULT OF PROLONGED EXPOSURE TO ROAD SALT. AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY SEPARATE ALLOWING THE FUEL TANK TO CONTACT THE GROUND AND POSSIBLY DISRUPT THE INTEGRITY OF THE TANK.
Consequence & remedy
Consequence: THE FUEL TANK CAN FALL FROM THE VEHICLE AND STRIKE THE GROUND WHICH COULD CAUSE A FUEL LEAK. LEAKING FUEL CAN CREATE A FIRE HAZARD.
Remedy: DEALERS WILL REPLACE THE FUEL TANK STRAPS AND ATTACHING HARDWARE WITH NEW ZINC COATED PARTS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 6, 2011. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE15031 · Occupant Classification System
Opened Sep 1, 2015 · Closed Feb 11, 2016
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:sensor:occupant Classification
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Additional source detail variants (4)
Air Bags:frontal
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags:frontal:sensor/control MODULE-INACTIVE
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags:sensor:occupant Classification
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,