2025 Kia Sorento

While driving my 2025 Kia Sorento on the highway, I noticed a coolant leak and an overheating warning. I immediately pulled over, and the vehicle was towed to a Kia dealership for inspection. After diagnosing the issue, the dealership claimed that small pebbles had damaged the radiator, leading to the coolant leak. They stated that this was considered an accident, not a defect, and therefore was not covered under warranty. Why This is a Concern: After researching online, I discovered that many other Kia owners are experiencing the same issue, suggesting that the radiator may be vulnerable to road debris due to poor design or insufficient protection. A radiator should be durable enough to withstand normal highway driving conditions. A failure like this could cause engine overheating and sudden breakdowns, posing a serious safety risk to drivers and passengers. Request for Investigation: Since this issue is affecting multiple Kia Sorento owners, I believe it should be investigated as a possible design flaw. If the radiator is too fragile to handle everyday road debris, Kia should issue a recall or Technical Service Bulletin (TSB) to address the defect and ensure driver safety.

The contact owns a 2025 Kia Sorento. The contact stated while his wife was driving approximately 25 MPH in the snow with the windshield wipers activated, the windshield wipers became stuck in the middle of the windshield due to snow accumulation in the area between the windshield and the hood. The contact's wife pulled over to the side of the road and noticed that the accumulated snow had turned into built-up ice, which obstructed the windshield wipers functionality. The contact's wife removed the ice in the area between the windshield and the hood and continued driving. The contact stated that the failure recurred while driving. The vehicle was taken to the dealer, where it was diagnosed that the windshield wiper gear shaft was damaged and the arm that originated from the windshield wiper motor was bent due to the built-up ice. The dealer determined that the windshield wipers motor assembly needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 1,600.

The contact leased a 2025 Kia Sorento. The contact stated that while driving, the vehicle failed to increase over 20 MPH. The 20 MPH limited message was displayed. The brake pedal was hard to depress. The driver pulled over and called the salesman at the dealer, who discussed red flags. The contact turned the vehicle off and restarted. While driving 45 MPH, turning left, the brake pedal was applied, but the brakes violently pumped upwards for about nine car lengths. The vehicle eventually slowed down. The speed decreased from 40 MPH to 20 MPH, and he crashed into a Toyota Corolla stopped at the light. There was an unknown abnormal warning sound detected. There were no reported injuries, airbags, fire, or police report filed. The vehicle was towed to the local dealer, where it was diagnosed that the bumper was cracked and two unknown sensors were damaged. The vehicle was not repaired. The manufacturer was contacted, who investigated the failure and determined that the brakes and smart cruise control were working as designed. Additionally, informed  him not to utilize the cruise control in the city, read the manual, and learn the vehicle. The approximate failure mileage was 65.