2023 Kia Sorento

The panoramic sunroof on my 2023 Kia Sorento intermittently fails to close. When commanded to close, the glass travels most of the way, then stops or reverses before reaching the fully closed position. It frequently takes many repeated attempts. In some cases the panel will not seat at all until the vehicle is driven over rough pavement, and the resulting vibration allows it to complete closure. The malfunction is accompanied by a loud grinding or scraping noise from the roof assembly during travel. This condition has been present since I purchased the vehicle new. The sunroof has seen very limited use. Safety risk: the glass panel cannot be reliably secured. An open or unseated panoramic panel at highway speed presents a risk of water intrusion, wind loading on an unsecured glass panel, and loss of roof structure integrity. Repeatedly operating the switch and monitoring the panel while driving is a significant distraction from the driving task, and driving specifically to induce vibration in order to force closure is itself an unsafe workaround. Dealer history: I have reported this to a Kia dealership on multiple occasions. I was told there is no defect and that the cause is debris, which is inconsistent with a vehicle purchased new with minimal sunroof use. On one visit the dealer cleaned the assembly as a goodwill gesture. This did not correct the noise or the closure failure. The vehicle was returned to me as repaired while the noise and the failure to close were both still present. Kia issued Technical Service Bulletin BOD125 (Rev 1, 02/27/2017) describing a slow-to-close condition and abnormal closing noise on the prior-generation Sorento (UMa), remedied by cleaning and lubricating the rear guide rails and replacing the rear tilt levers. My vehicle exhibits the same failure mode described in that bulletin. The component is available for inspection on request. No warning lamps or messages preceded or accompanied the failure.

I am submitting a vehicle safety and certification concern regarding a 2023 Kia Sorento Hybrid that was marketed and offered for sale as a Kia Certified Pre-Owned (CPO) vehicle by Shawnee Mission Kia, 7951 Shawnee Mission Pkwy, Mission, KS 66202. On [XXX], during an in-person inspection of the vehicle prior to purchase, I observed conditions inconsistent with expected Certified Pre-Owned inspection and preparation standards, including inverter coolant below the minimum level, engine oil materially above the normal operating range, and deteriorated windshield wiper condition. A third-party witness was present during the inspection. Because the vehicle was being represented as Certified Pre-Owned, I requested the vehicle’s CPO inspection checklist and supporting inspection documentation from dealership personnel. The requested documentation was not provided despite multiple follow-up requests. Subsequent written communications from dealership management acknowledged failures in dealership standards and handling related to the matter. After a formal complaint was submitted to the dealership’s corporate parent, the dealership’s General Manager responded in writing that an internal review had been initiated concerning CPO preparation and documentation practices. The requested inspection and service documentation were still not produced. The dealership later confirmed in writing that the vehicle “has since sold.” I am submitting this complaint because the vehicle was represented to consumers as Certified Pre-Owned despite observed maintenance and inspection concerns affecting vehicle condition and safety-related systems, while supporting certification documentation was not produced upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Even though the dealership reports that safety recall 23V610 / SC280 for the mounting clip replacement was completed on 2/16/24, my rearview camera has just fell out of its housing, hanging by its wires, with the mounting clips laying broken in my driveway. My rearview camera is currently unusable; its taped up so that it is not just swinging by the wires. When I contacted my dealership, they are pretty sure they can get this work covered under the warranty, but they are not sure. And my VIN# is currently not pulling up any "Active Recalls". Either the clips they used to replace the previous clips were also bad, or the dealership didnt actually complete the work as reported.

On the morning of July 14, 2024 I noticed a crack on the driver side on the window. The crack appeared on the bottom of the window and travel upwards where it ended. This morning July 15, 2024, the crack spread across towards the passenger side of the vehicle. Nothing hit the window for it to develop a crack as my car was parked in the driveway and there were no markings on the window. I do put on the window sun visor to keep the excessive heat out of the car.

Issue occurred and came to like during the past winter snow storm. The hood of the SUV does not allow and blocks the wiper blade arm from being lifted in order to clean ice off the wiper blade nor can the wiper arm be lifted to clear ice and snow under the wiper arm to allow proper operation. This design flaw does not allow safe and clear sight function of the windshield wipers.