2021 Kia Sorento

Power train incident - • transmission holding gears, jerking between shifts, gear shifted into S mode on its own and stuck there, unresponsive acceleration, locked up steering/inability to turn the steering wheel and total loss of drive power. • happened while merging onto a highway in one of two split lanes for highway access. A merging semi truck in the other merging lane almost ran into me because I could not give it gas. Me and a local police officer who saw me broke down and stopped to provide additional cover, were nearly hit several (6) times from other vehicles and semi trucks due to malfunctions happening. • diagnosed by Kia dealership and was told there was a major electrical failure which caused the electrical oil pump to fail and need a new transmission. Although my VIN doesn’t list recalls, similar issue to the recall on my same year/make/model under NHTSA Campaign Number 21V519. • Warning lamps/messages shown in photos attached. __________________________________ Forward Collision warning incident - • front forward safety system light appeared on dash, then moments later a warning appeared and the vehicle braked on its own detecting a vehicle in front of me when there was not another vehicle in front of me within vision!! • happened while driving in a 55mph zone, a vehicle was driving behind me when this occurred and that vehicle almost slammed into the back end of mine causing a crash. • problem not yet inspected on vehicle due to blown transmission from above incident and inability to start/move the vehicle.

My 2021 Kia Sorento (VIN: [XXX] , built July 2021) has a persistent scraping/metal-on-metal noise when turning the steering wheel. This noise comes from inside the steering column. It matches exactly what Kia documents in TSB CHA111, which identifies failure of the worm shaft small bearing inside the C-MDPS (Column-Mounted Motor Driven Power Steering) system. My vehicle uses the same steering column system covered in that bulletin, though my VIN is not included in the bulletin’s range. The video embedded in CHA111 features the exact noise my vehicle is producing. I recorded it and sent it to Kia Consumer Affairs, along with proof of the C-MDPS configuration and production date. Despite clear evidence that my steering system is affected by the same design flaw, Kia declined support unless I pay for a dealer inspection — despite the issue being a known, documented defect. This noise has been present as far back as I can remember. and is steadily worsening. The steering column bearing is a critical safety component. If it fails, it could lead to steering resistance or failure. Other Kia and Hyundai vehicles using this system have already had the part replaced under warranty or goodwill coverage. I can provide a video of my vehicle making the noise. I’m submitting this complaint because Kia refuses to address a defect they’ve already acknowledged when it appears in later VINs. I am asking NHTSA to investigate and consider requiring Kia to expand the scope of TSB CHA111 or issue a recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2021 Kia Sorento X-Line Prestige comes with Driver Assist features. One is for steering. Without warning it will disengage, particularly on a 2-lane highway, or when entering a curve in the road. This is dangerous. It needs to come with a warning that Driver Assist can flake out on 2-lanes and on curves, and is fairly useless unless you are on a straightaway on an interstate. This has happened to me multiple times since I bought the car from the Heiser dealership in Wisconsin.

The car drifts from right to left all the time on any road surface. This was addressed at about 2,000 miles months ago and they could not get it to steer straight. I brought this up on the oil change visit and the tech never addressed this at all ! The dual clutch transmission does not shift properly. The vehicle larches hard into reverse, feels like it will sometimes stall when starting out from a stop sign or traffic light. (This is dangerous) The idle goes up and down from 750 RPM to 1,100 RPM when the car comes to a stop. (This is dangerous) The brakes feel like they are weak. (This is uncomfortable at best) There is a lot of wind noise at 45 MPH and up. Had you do a $65.00 oil change. When I got home, I checked the oil and it's at least 1/8 quart short. I have not had time to come back for your techs to add more oil yet. So, your tech did not address issues (1) (2) (3) (4) at all. Instead, he wrote up the issue (2) as being normal for that type of transmission. After your service advisor Joshua Mills saw I was very dissatisfied with the lazy diagnosis, he took me to J.D. McClure with the list of problems I had outlined to your company. JD explained he was brand new at KIA and did not have KIA experience which was disheartening at best. I asked that he contact KIA corporate to have a certified KIA rep come look at this vehicle. He assured me he would do so and call me back to see if and when a rep can come look at my vehicle. As of today, he has not called me. Yesterday my wife Ann called right after she used the vehicle and experienced a lot of potential stalling issues and spoke with Christina. She explained that all principles were in a morning meeting but she would tell JD about your issue and have him call you. He did not call !!! What are you going to do about these issues ??? These issues are all over the KIA forums and registered complaints are listed on the N.T.S.B. (National transportation safety board) on all of the above.