2021 Kia Sorento

I am filing this complaint regarding my 2021 Kia Sorento, which has suffered a transmission failure. The transmission slips, shifts harshly, hesitates during acceleration, loses power unexpectedly, and has become unsafe to drive. This defect has put my safety and the safety of others at risk. On several occasions the vehicle failed to respond properly when accelerating, including while entering highways and driving in traffic. The hesitation and sudden loss of power created fear and anxiety because I could not trust the vehicle to operate as expected. The problem has been reproduced and confirmed by a repair facility, and the symptoms are consistent with a transmission torque converter clutch failure. I also contacted Kia and provided the vehicle information. Kia informed me that they would not repair the vehicle because it has exceeded 100,000 miles and that the recall or warranty extension had expired. However, my vehicle is experiencing the same transmission-related symptoms reported by many other Kia owners.I never received any recall notification because I purchased the vehicle from a dealership as the second owner. Had I been properly notified, I would have taken the vehicle in for inspection much earlier or would never have purchased the dangerous vehicle in the first place. It is extremely frustrating and costly to be denied assistance solely because of mileage when the failure appears to be related to a known transmission defect.Before the failure, the check engine light illuminated and then went away even though the issue did not. Prior to that warning, the vehicle had already shown delayed shifting, slipping, hesitation, rough gear changes, and loss of power, which became progressively worse. I reported this to Kia on a previous service visit to Romeo Kia in Lake Katrine, NY and was told they did not find anything wrong. This situation has caused significant emotional stress and anxiety. I am requesting a full review and a fair resolution from kia. Thank

The vehicle experienced a sudden and dangerous loss of motive power while driving due to a failure of the 8-speed dual-clutch transmission's (DCT) high-pressure electric oil pump causing loss of shifting and dropping to lower gears at a very high rpm and slowing the car almost instantly creating a hazard for a crash with following vehicles. ​This vehicle was previously serviced under Kia Safety Recall Campaign SC250 (NHTSA ID: 22V-760). However, the initial recall remedy failed to permanently resolve the underlying defect. Despite the recall work being marked as completed, the transmission component has failed again.

The contact owns a 2021 Kia Sorento. The contact stated that while parking the vehicle, the vehicle jerked abnormally. The contact stated that while the vehicle was in drive, the vehicle jerked and unexpectedly accelerated while driving 55 MPH and was dragging. There were no warning lights illuminated. The contact stated that the vehicle was serviced by the dealer for a transmission failure, but the failure persisted. The contact stated that the manufacturer was made aware of the failure. The failure mileage was approximately 35,000.

The vehicle is suffering from a chronic, cascading powertrain and fuel management defect that has resulted in a critical safety hazard: sudden engine stalling. Over the last 17,000 miles, the vehicle has experienced three severe engine/emissions failures that the manufacturer has been unable to permanently resolve. At approximately 30,000 miles (on 29-Jun-2025), the engine suffered a severe Cylinder 3 misfire (Code P0303). At approximately 39,000 miles (on 02-Jan-2026), the unresolved fuel issue caused a failure of the Catalytic Converter (Code P0420) and an Evaporative Emission System leak (Code P0456). At 47,000 miles (Current Event), the fuel delivery system failed completely. The engine began running excessively rich (Code P2178), causing the engine idle to drop dangerously low (Code P0506). This defect caused the vehicle to suddenly stall out, resulting in a complete loss of motive power and leaving me stranded. Because the manufacturer's authorized repair facilities have only addressed the symptoms rather than the root cause of the fuel system failure, the vehicle repeatedly loses power and stalls without warning. This poses a severe safety risk to myself and other motorists, especially when operating the vehicle in traffic or at highway speeds.

My vehicle lost power and accelerated quickly yet unpredictably, and the check engine light came on. A local shop told me it was "an old code" for the transmission and that if it does that again to take it to dealer. It occurred again. Kia dealer states this vehicle has a recall and has been repaired twice, but that they will not repair it again. This is such an unsafe issue they will not allow me to drive the vehicle. I will have to pay almost $7,000 to replace the transmission.

The contact owns a 2021 KIA Sorento. The contact stated while driving the vehicle on a hill he states the vehicle stutters very hard and moves back and forth with hesitation to accelerate. The vehicle was seen by a dealer 3 months before and was made aware of a transmission failure starting, the contact moved to an area that has much more hills and is now experiencing hard transmission failure symptoms. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage 136,577.

The contact owns a 2021 Kia Sorento. The contact stated that while driving rotating noise coming from and louder when accelerating. The was taken to local mechanic transmission. The vehicle was taken to the local dealer who diagnosed that the transmission needed to the be replaced. A transmission software update was performed but the failure continued to occur. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the vehicle was previously service under the NHTSA Campaign Number: 22V760000(POWER TRAIN). The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 80,000.

COMPONENT: 2.5L T-GDI engine failed completely at 102,971 miles, requiring full replacement (~$8,000). Vehicle available for inspection at [XXX] Kia, [XXX] . SAFETY RISK: Engine lost power during normal operation. Sudden, uncontrolled loss of engine power creates a direct collision risk at highway speeds for the driver, passengers, and surrounding vehicles. CONFIRMED BY DEALER: Mark Kia performed a borescope inspection on April 10, 2026 confirming cylinder wall scoring, oil-fouled pistons, and worn honing patterns across multiple cylinders. Findings are consistent with Kia TSB ENG235 (January 2022), which documents a defective PCV check valve on 2021–2022 Sorento 2.5T engines allowing oil to contaminate combustion chambers. Vehicle was serviced exclusively at Mark Kia for all 17 visits since 2021. TSB ENG235 does not appear in any service record. PRIOR SYMPTOMS: No warning lamps or messages before failure. A certified 36-point inspection one week prior showed zero cautions. Spark plugs replaced at 74,534 miles (Jan 2025) were found fouled at ~102,000 miles, only 28,000 miles later — indicating silent, progressive oil contamination. The defect is undetectable by the driver until catastrophic failure. Kia America has not responded to two formal written dispute requests (Case #XXX, April–May 2026). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)