2021 Kia Sorento

COMPONENT: 2.5L T-GDI engine failed completely at 102,971 miles, requiring full replacement (~$8,000). Vehicle available for inspection at [XXX] Kia, [XXX] . SAFETY RISK: Engine lost power during normal operation. Sudden, uncontrolled loss of engine power creates a direct collision risk at highway speeds for the driver, passengers, and surrounding vehicles. CONFIRMED BY DEALER: Mark Kia performed a borescope inspection on April 10, 2026 confirming cylinder wall scoring, oil-fouled pistons, and worn honing patterns across multiple cylinders. Findings are consistent with Kia TSB ENG235 (January 2022), which documents a defective PCV check valve on 2021–2022 Sorento 2.5T engines allowing oil to contaminate combustion chambers. Vehicle was serviced exclusively at Mark Kia for all 17 visits since 2021. TSB ENG235 does not appear in any service record. PRIOR SYMPTOMS: No warning lamps or messages before failure. A certified 36-point inspection one week prior showed zero cautions. Spark plugs replaced at 74,534 miles (Jan 2025) were found fouled at ~102,000 miles, only 28,000 miles later — indicating silent, progressive oil contamination. The defect is undetectable by the driver until catastrophic failure. Kia America has not responded to two formal written dispute requests (Case #XXX, April–May 2026). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Kia Sorento. The contact stated that while driving 50-60 MPH, the check engine warning light illuminated. The vehicle hesitated and jerked while depressing the accelerator pedal. The vehicle was taken to Firestone, where the spark plugs and ignition coils were replaced; however, the failure recurred. The vehicle was taken back to Firestone, where it was diagnosed with transmission failure, and the contact was referred to the dealer for assistance. The vehicle was taken to the dealer, where the fuel injectors were replaced, and the transmission oil pump was replaced under NHTSA Campaign Number: 22V760000 (Power Train); however, the failure recurred after driving 6,000 miles. The vehicle was taken back to the dealer, where the transmission oil pump was replaced under warranty; however, the failure worsened. The contact stated that while driving approximately 30 MPH, the vehicle stalled in the middle of the roadway. The contact was unable to pull over to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed and it was determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was filed. The contact was referred to another dealer for a second opinion. The failure mileage was approximately 86,000.

Our 2021 Kia SORENTO has been to Elmhurst kia service numerous times . The chief complaint is the Kia Sorrento keeps losing power while in drive reverse middle traffic even on the highway but yeah every time we take it in, they say either it’s the battery .you can’t use it in the Eco mode .turn off the shut off while in drive mode when at stops ! always a different excuse, but yet no recall and it’s not showing up on their computer, but yeah it’s happening and Kia does not want to take ownership. The vehicle has been left there for numerous weeks at a time leaving us without a vehicle no loaner . But because cannot duplicate issue release vehicle back with no repairs or maintenance. Kia prefer you taking the car getting into a car accident before they decide to do anything or even a lawsuit because not enough people having same issue with the 2021 kia SORENTO s model ! If you also have these issues please report them here so they can be forced to open a recall !!! Before someone gets seriously hurt my SORENTO has loss power on highway and in the middle of train tracks with my little ones in SORENTO and we drove the vehicle from day one original owners not a used SORENTO

My check engine light came on and went to dealer ship jn Oct of 2025 they stated the Egr needed to be replaced and would cost 1300 to repair but inform me they didn't have the piece to replace at that time to reschedule app. Also reservoir coolant light keeps coming on . I called several times to Lumberton Kia at one time they stated that they didn't have but 1 mechanic that worked on hybrids and he was behind. I finally have a appointmentthis weekto see what is exactlygoing on with my suv cause now i have a hesitation when pressing the gas and my transmission jerks.

This has been occurring intermittently since my 2021 Kia Sorento reached approx. 15k miles and now has 26,600 miles. There are no lights or indicators on the dash letting me know anything is wrong. When the vehicle is stopped at a traffic light or stopped in heavy traffic, the vehicle will start idling high and shaking and the engine will seize up. I am not able to steer, the brakes lock up, I cannot accelerate, all functionality is lost. The only thing I can do is put the vehicle in park (in heavy traffic) and shut the car off and wait a minute and turn it back on and it seems to reset itself. This is EXTREMELY dangerous for myself and my passengers (some of which are children) and can cause a serious accident. At no point should I ever need to be concerned with my vehicle seizing up in the middle of the road and having to park and restart my car. This has happened on several occasions already. I have taken my car to 2 separate Kia dealerships to address this problem I have been experiencing. The first dealership failed to attempt to duplicate the problem and instead informed me the firmware update the performed from a previous recall should remedy the problem. It did not. Then I recently took it to another Kia dealer in another state and explained the situation. I specifically asked them to take the vehicle for a test drive and they argued with me that my battery was low and needed to be replaced and it would not be covered under the warranty. I have been driving this vehicle for a while and it has been having this issue around 15k miles so I know it is not the battery. They totally disregarded the safely of myself and my family and only focused on making money for themselves. This is a serious safety issue with this vehicle and has continuously been swept under the rug by Kia. Even the customer service is rude and I have reported this to them and asked for an escalation to their consumer affairs dept and have received no response.

My vehicle completely shut off while I was driving with my children in the car. The dealership replaced the battery but never identified the root cause. Since then my car has been experiencing RPM surging while in Park — the engine revs up and down repeatedly on its own. The vehicle also feels sluggish and does not want to accelerate properly while driving. Additionally since taking ownership of the vehicle my window has squealed every time it rains and I roll down the window. The dealership has replaced the seals, lubricated and cleaned the window multiple times and the problem persists. The defective window seal also caused a gash in my window tint requiring replacement. I have taken my car to my Kia dealership multiple times and they have been unable to fully resolve these issues. My car is currently at the dealership right now and they still cannot find the problem. I contacted Kia Corporate on March 20, 2026 and opened a formal case. These defects have put my children in danger and I am requesting a formal federal investigation.

I was driving my car on [XXX] and my car suddenly lost power and when I pressed the gas pedal the RPM quickly increased but the car was hesitating between gears and not engaging. Shortly thereafter a malfunction code showed up on my car screen along with an engine warning indicator. The code was DCT P193B79. That code indicates a High Pressure Electric Oil Pump Performance issue pointing to problems with the 8WDCT; the same issue and symptoms associated with the recall bulletin for the 2021 Kia Sorento Transmission. When I brought it to Ken Gariff Kia in Phoenix Arizona they stated there is no such recall for my vehicle with this problem and that since I have 76000 miles on the car it is not covered. I feel that this repair falls squarely within the scope of the recall for the Kia transmission and would like it replaced at the manufacturers expense. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Kia Sorento. The contact stated that while driving approximately 10 MPH over a speed bump, the vehicle shut off. The contact was unable to pull over to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed with a bad connection at the fuel pump fuse box. The dealer performed a minor wiring repair. The contact stated that while driving 60-80 MPH, the vehicle failed to accelerate as intended, and the vehicle shuddered and then jolted. The vehicle was taken to Calavan Kia [XXX] ), but the failure could not be duplicated; however, the coils were replaced. The contact stated that upon starting the vehicle, several unknown warning lights were illuminated, and the vehicle was inoperable. The contact stated that upon restarting the vehicle, the warning lights were turned off, and the vehicle operated as needed. The contact also stated that the vehicle was making an abnormal rattling and ticking sound while driving. The vehicle was taken back to the second dealer, where the failure could not be duplicated; however, the failure persisted. The vehicle was taken to a third dealer, Ed Voyles Kia [XXX] ), where the failure could not be replicated. Additionally, the contact stated that A/C system was inoperable. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 6,099. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)