Engine. Review the 155 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

10 crash reports19 fire reports10 injury reports

Suspension complaints

2 reports

Clear category filter

Mileage unknown · Mar 5, 2024

Suspension

Read full complaint

I purchased my 2019 Kia Sorento with 7,000 miles on it. A few moths after purchase, I began having suspension issue with it. My rear tires were being worn out very quickly and a tire repair shop suggested that I have Kia dealership check out the shocks, which I did. Kia Service Center diagnosed the vehicle and replaced the shock absorbers due to leakage. Almost 2 months later, I took my Sorento back to the same Service Center due to loud squeaking noises and the up and down of the vehicle anytime I drove over the smallest hump or bump in the road. Kia found that the strut mount and bearings were coming apart and Kia supposedly replaced the sway bar along with the bearings and struts. After one month, I had to take the vehicle back for the same issue. It was supposedly fixed again but a few moths later, the loud squeaking came back and has gotten worse over time. I took my truck to Kia again for the same issue and they are now saying that the sway bar bushings have went bad. Well they supposedly just replaced the old sway bar last year and it is already needing new bushings. I have searched online and found the front sway bar of KIA's to be a major defect problem and consumer's having to continuously replace the front sway bar on their KIA. A bad sway bar can not only impede your ability to control and handle your vehicle, but it can also be the cause of an accident. With so many consumer complaints on this issue, I am unsure why there has been no recall on the sway bar and bushings of KIA vehicles. Whether the vehicle is new with new parts or the part has been replaced, this is definitely an issue that needs to be investigated immediately.

NHTSA ODI #11575564

Mileage unknown · Sep 6, 2022

Forward Collision AvoidancePower TrainSuspension

Read full complaint

I purchased my Kia Sorento in 2020. It was a used 2019 with 7,000 miles. I immediately noticed that it would squeak rather loud and bounce high when driving over very small humps on the roads. Being that I'm no mechanical savvy, I assumed this was normal for SUV's because I've driven sedans all my life. Anyways, I was informed of the issue when going to a tire repair shop asking why my back tires sounds so harsh when driving. I was told that there are waves in my tires due to the shocks. and that the shocks has had to have issues for a while to now change the formation of the tires. I have now read several Kia forums and there are lots of Kia Sorento owners who have suspension issues close or the same as mine. Another issue is the automatic emergency brake. I was unaware of this feature until one day having to make a sudden stop and the vehicle stopped and shut off on its own almost causing me to be hit in the rear. This event was very traumatizing. I googled this feature and thought that I had turned it off but I realize that I can't make it go away and it is a very dangerous feature to have. My vehicle does not have as much driving experience as I do and I am capable of controlling my vehicle to avoid an accident if I need to without the assistance of a computer which has almost caused nearly fatal accidents by immediate stops or shutting off the vehicle causing me to not be able to control the vehicle myself. Another defect is the powered trunk. Whether I open it from the button near the steering wheel or the button on the rear gate, the trunk will immediately close on its own after opening; sometimes closing down on the top of the head of my children or myself. I selected to disable the "smart" feature but it does not stop it. The last defect is electrical. I have replaced the same internal light near the rear view mirror, and it continues to go out. This is an indication of an electrical issue and with my Kia only having 54,000 miles, further action is needed.

NHTSA ODI #11483030

Official recalls

23V639000 · Back Over Prevention: Sensing System: Camera

Sep 15, 2023

Kia America, Inc. (Kia) is recalling certain 2019 Sorento vehicles. Due to a manufacturing error, water may leak into the rearview camera, which can cause the rearview camera image not to appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence & remedy

Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash.

Remedy: Dealers will inspect the rearview camera and add additional water proofing to the camera harness, or replace the camera as necessary, free of charge. Owner notification letters were mailed March 8, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC282.

22V703000 · Trailer Hitches

Sep 19, 2022

Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Consequence & remedy

Consequence: A fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Go deeper into Kia Sorento problems

Kia Sorento transmission problems →Kia Sorento electrical problems →