2018 Kia Sorento

I have less than 100,000 miles on my 2018 Kia sorento. When I reached probably 50,000 miles this car went DOWN HILL. I feel like I’ve replaced everything on this car. Now every oil change was saying no oil on the dip stick, so I take it to the Kia dealership. They tell me that I need an ENTIRE engine. My car is less than 100,000 miles. I saw something that said if it was under that threshold, it could be covered but they said they couldn’t find anything. This car has been failing me. I still owe HALF of the car, what it’s not even worth on carfax anymore. AND the engine cost is exactly 50% of what I owe on this car. I don’t know what to do, but never buy a Kia again. This is a hazard for everyone around me the gas it is putting into the air. I don’t know what else to do. I even paid them to do an oil change and the oil light lit up as SOON as I left the parking lot. There are no leaks whatsoever. I even had someone from the Kia engine settlement verify my VIN # and told me that it was eligible and she told me that everything would be taken care of at the dealership without charge. She then told me to wait for the dealership to call and let me know because I was on hold while they were talking. But right after I received a call asking how I was going to pay for it because they could not find anyway to cover it. I don’t know how to ask for a second opinion. Kia is never available to speak with or try to resolve the issue. This has just been a nightmare.

On January 30, 2026, I was driving with my daughter from Kansas City to Platte City when the vehicle experienced a sudden and catastrophic mechanical failure. As we approached our exit, the engine unexpectedly revved and the vehicle rapidly decelerated to approximately 30 mph. When I attempted to accelerate, the vehicle was unable to properly gain speed. Upon reaching the top of a hill at an intersection, the engine completely shut off and the vehicle became disabled in the roadway. The vehicle was towed and inspected by two independent repair facilities. Both repair facilities confirmed catastrophic internal engine failure. A bore scope inspection identified a broken valve in cylinder 4, along with severe internal engine damage. The first repair facility estimated the cost of engine replacement at $9,600. The second repair facility confirmed the same diagnosis and recommended full replacement of the long block assembly. Copies of the inspection reports and repair estimates are attached. Due to the extent of the internal damage and the high cost of repair, the vehicle is considered mechanically inoperable and beyond reasonable repair. The cost of repair is substantial and exceeds our ability to proceed with repairs. At the time of the mechanical failure, approximately two years remained on the finance agreement, with an outstanding loan balance of approximately $12,000. As a result of this catastrophic mechanical failure, the vehicle is unusable, and a financial deficiency remains on the loan. Although the engine carried a warranty, we were informed that the specific failure was caused by internal component failure and material shedding, which is not covered under the warranty terms. Supporting documentation, including diagnostic findings, repair estimates, and photographs of the failed engine components, are attached. Due to the sudden and catastrophic mechanical failure, the vehicle has sustained a total mechanical loss and is no longer operable.

2018 Kia Sorento 2.4 GDI. In late 2024 a Kia dealer performed an oil-consumption test and confirmed the engine was burning excessive oil. In Feb 2025 the engine long block was replaced. Within about 4,000 miles the vehicle began setting P1326 warnings, misfiring, losing power, and struggling to climb hills. On a highway trip from South Carolina back to Indiana, the vehicle could barely maintain 30–40 mph on grades with the accelerator floored while traffic was moving much faster. The check-engine light returned repeatedly. The vehicle eventually died on an exit ramp and had to be pushed out of traffic and towed. I felt it was unsafe to drive but was repeatedly told by dealers that it was “OK to drive” or that the issue was “bad gas.” After visits to multiple dealers, the current Kia service center finally diagnosed a severely clogged exhaust. They report the manifold catalytic converter and underbody converter have broken down internally and are heavily coated in carbon/oil deposits, and state this likely came from the engine burning oil before and around the time of the rebuild. Exhaust temperatures have been recorded at very high levels, and the engine will only run briefly with an O2 sensor removed to vent exhaust; with the exhaust sealed it will not stay running. The dealer has warned there may now be internal engine damage from prolonged backpressure. The vehicle has been undriveable for many months and the failed converters are being retained and are available for inspection. My concern is that excessive oil consumption on these GDI engines is causing secondary catalytic-converter failure, extreme power loss, stalling risk, and possible fire risk from overheated exhaust components, even after engine replacement.

My car had an issue that was covered under a class action lawsuit. I even had an extended Warranty which was still valid at the time. I was intimidated by the warranty company when they said well if there is carbon build up in the engine the cost of the repair is on you. So I didn't have it fixed and the engine blew up and is now inoperable in my driveway. So bottom line I couldn't get KIA to help me or the extended warranty company when clearly it was KIA's responsibility to fix there defect in the engine.

Noticed excessive oil consumption that turned into burning oil when the exhaust turned back of car black. Engine started knocking due to gummed up spark plugs. Replaced the spark plugs but within weeks the new plugs where gummed up as well. Took to Kia for diagnosis and potential repair for theta 2 class action. Mechanic confirmed damaged spark plugs, piston issues and needs for new engine.

I was driving from richlands coming home and my vechial kept trying to die on me like i didnt have any gas and then i had to suddenly pull off the side of the road without any power and i sat their and even try to restart the vechial and it wouldn't start back then a woman come out of nowhere in an ambulance and i was trying to tell her that it was alright and she was trying to tell me that the vechial was on fire underneath the vechial and i didnt see that it was a fire at all i though i was overheating so i was sitting in the vechial waiting on it to cool down thank god i was not hurt really bad if this would have happened somewere else i know i would be dead i already have smoke in my lungs from breathing in all that smoke i though was just steam but i still dont know what in my engine caught on fire but i do know it started from either in the engine or under it somewhere then everything caught fire and it was all melted the whole thing is completely gone even the tag melted i have never seen that kind of fire before ever and i have own alot of vechicle and they usally break down but this was the first time one caught on fire and thus happens to kia alot even the day this happened the fire dept told me they just put another kia out just the week before how is it that kia are keeping these vechicle on the road it is awful and im trying to do something about it but noone will help me and i dont know what i need yo do to make kia pay for this i only had this vechial almost 6 months and it didnt have alot of miles on it 100000 thats not alot but the kia everything i have read have flew apart after the warranty has expired so its great for them i say they are happy and they have had a few recalls on this vechial and know about the fire but have something stupid like a tow hitch its saying my vechial has that recall but i didnt see a tow hitch anywere but it still caught fire so i would love for someone to take these vechial off the road they are not safe not what kia