2006 Kia Sedona

DATE 7/24/20013 TOTAL FAILURE OF LOWER CONTROL ARM, FRONT WHEEL LEFT SIDE. MILEAGE: 76,450 PART #54500-4D101 PURCHASED NEW FEBRUARY 19, 2007 CAR GARAGED SINCE NEW, DRY SEMI-HEATED ATTACHED TO HOUSE. FAILURE: DUE TO EXTENSIVE CORROSION THROUGH OUT. POSSIBLY BECAUSE OF A SUB-STANDARD ANTI-CORROSION MANUFACTURING PROCESS. THE RIGHT SIDE LOWER CONTROL ARM SHOWS STANDARD WARE AND LITTLE RUST FOR THE SAME TIME IN SERVICE. MASSACHUSETTS STATE ANNUAL SAFETY INSPECTION: DATED 7-12-2013 DID NOT FIND THE DEFECT, BUT THE VEHICLE FAILED DUE TO CRACKS IN TAIL LIGHT LENS EVEN THOU A FRAME AND SUSPENSION CHECK IS PART OF THE INSPECTION? THIS IS VERY MUCH A HIGH END SAFETY CONCERN. AT HIGHWAY SPEEDS ROLL-OVER CAN AND DO CAUSE DEATH. PICTURES ARE AVAILABLE: SHOWING LEFT AND RIGHT CONTROL ARMS. MY SEARCH OF 2006 KIA SEDONA'S FOUND THREE FAILURES THIS MAKES FOUR. NO DEATHS YET, THAT'S A GOOD THING! THANKYOU AND PLEASE FEEL FREE TO CONTACT ME. *TR

AIRBAG LIGHT ON WITHOUT CRASH OR DEFECT IN WELL MAINTAINED AUTO. APPARENTLY THIS TOTALLY INACTIVATES ALL AIRBAGS. MULTIPLE SIMILAR COMPLAINTS IN NHTSA SYSTEM. NEEDS TO BE RECALL, SINCE MOST OWNERS ARE UNABLE TO AFFORD DEALER REPAIRS TO THIS DEFECTIVE SYSTEM ON THIS MODEL CAR. OFTEN ATTRIBUTED TO DEFECTIVE SEATBELT SENSORS. HOPEFULLY NO ONE WILL DIE BECAUSE OF THIS PROBLEM, AND KIA USA SHOULD PAY TO REPAIR THIS KNOWN DEFECT! *TR

THE DRIVER SIDE CONTROL ARM BROKE IN HALF AS THE VEHICLE WAS SLOWING TO A STOP (10-20 MPH) AT A TRAFFIC LIGHT. VEHICLE COULD NOT BE DRIVEN AFTER THE INCIDENT. AFTER INSPECTION, IT WAS DETERMINED THAT THE CONTROL ARM HAD RUSTED THROUGH AND FAILED. ALL REMAINING CONTROL ARMS WERE INSPECTED. IT WAS FOUND THAT THE PASSENGER SIDE FRONT CONTROL ARM WAS ALSO IN NEED OF REPAIR BEFORE AN EVENTUAL FAILURE WOULD OCCUR. *TR UPDATED 10/22/13*LJ UPDATED 10/25/2013 *JS

THE LEFT FRONT COIL SPRING BROKE AFTER I HAD PARKED THE VAN AT WORK. LATER WHEN I WENT OUT TO GO SOMEWHERE, I FOUND A PIECE OF METAL ABOUT 8" LONG LYING ON THE GROUND BEHIND THE LEFT FRONT TIRE. I THOUGHT THAT I SURE HOPED IT HAD NOT COME OFF OF MY CAR! WHEN I GOT IN AND PUT THE CAR IN REVERSE, IT WOULD NOT MOVE. I SHIFTED TO DRIVE AND IT WENT FORWARD, SO I SHIFTED BACK INTO REVERSE AND TRIED TO BACK UP. THERE WAS A LOUD BANG AND THE FRONT END ON THE CAR DROPPED HARD TO THE LEFT. WHEN I GOT OUT OF THE CAR, THE TIRE WAS COMPLETELY FLAT AND I COULD ACTUALLY SEE A FLAP STICKING UP FROM THE INSIDE WALL OF THE TIRE. I LATER DISCOVERED THAT THE COIL SPRING HAD BROKEN - THAT WAS THE PIECE OF METAL I HAD FOUND ON THE GROUND - AND HAD STABBED THE TIRE. IT WAS CORRODED. AFTER CHECKING ONLINE I LEARNED THAT THERE HAD BEEN AN ISSUE WITH THE FRONT COIL SPRINGS ON 2006 KIA SEDONAS, THAT THE FINISH WOULD GET CORRODED BY ROAD SALT AND WATER AND THE SPRINGS WOULD BREAK. A RECALL HAD BEEN ISSUED IN 21 STATES, INCLUDING MICHIGAN. WHEN I CONTACTED THE DEALER, I WAS TOLD THAT THE RECALL COVERED VEHICLES MADE FROM DECEMBER 2005 TO MARCH 20, 2012. MY VAN WAS MADE ON APRIL 18, 2012, AND THEREFORE WAS NOT COVERED BY THE RECALL BECAUSE THE 'ISSUE HAD BEEN RESOLVED.' WHY THEN DID THE SPRING BREAK? *TR

THE ELECTRICAL SYSTEM HAS SHORTS AND HARNESS ISSUES ALL OVER. YOU HAD A RECENT RECALL, BUT NOT INVOLVING 2006 SEDONAS ONLY 2007. OUR VEHICLE HAS SAME ISSUE AS FOUND IN THE RECENT RECALL. THE AIRBAG LIGHT IS ON AND I HAVE NEVER HAD AN ACCIDENT. THE LIGHTING IS ALSO AFFECTED DUE TO THE WIRING HARNESS. I HAVE ONE BLINKER I CONSTANTLY REPLACE AND SAME WITH ONE FRONT HEAD LAMP. I HAVE SEEN OTHER COMPLAINTS OF THE SAME THING WITH THE SAME EXACT VEHICLE. *TR