2006 Kia Sedona

THE BACK FRAME OF MY 2006 KIA SEDONA IS ALL CORRODED. CANNOT DRIVE THE CAR ANY MORE. I BOUGHT THE CAR IN NOV-2006 AND IN DECEMBER 2011 I HAD TO CHANGE THE FRONT FRAME DUE TO CORROSION. IN MARCH 2014, I HAD TO CHANGE THE FRONT SUSPENSION DUE TO CORROSION AND NOW THE BACK FRAME IS ALL CORRODED. I WOULD LIKE THAT SOMEONE REALLY CHECK ON KIIA'S MATERIALS. IS INCREDIBLY THAT AFTER 5 YEARS I HAD TO CHANGE THE FRONT FRAME. AND UP TODAY'S DAY. I HAVE THE SAME CORROSION ISSUE. I LEAVE IN NEW JERSEY AND I KNOW THAT IN THE WINTER, THERE IS LOTS OF SALT ON THE STREETS BUT I HAVE NEVER SEEN A PROBLEM LIKE THIS ON ANY OTHER BRAND. THIS ISSUE GOES DIRECTLY TO THE SAFETY OF THE CAR.

ON THE MORNING OF THE INCIDENT I DROVE TO WORK (APPROX 25 MILES) AT SPEEDS IN EXCESS OF 60 MPH WITH NO INCIDENT. AFTER PARKING I ENTERED MY WORKPLACE. DURING LUNCH I GOT IN THE VEHICE AND BEGAN TO TRAVEL TO A NEARBY REASTAURANT. I WAS DRIVING AT APPROXIMATELY 45 MPH WHEN THE VHEICLE'S HOOD BECAME UNLATCHED AND OPENED. THE HOOD OPENED WITH SUCH FORCE THAT THE HOOD LIFT STRUT SUPPORTS BROKE, ALLOWING THE HOOD TO OPEN, OVER EXTEND, OBSTRUCT MY VISION, AND STRIKE THE WINDSHIELD. UPON STRIKING THE WINDSHIELD THE GLASS SHATTERED. I SLOWLY PULLED TO A NEARBY PARKING LOT, TOOK A PICTURE WITH MY PHONE,AND CLOSED THE HOOD. I LATER CALLED KIA CUSTOMER SERVICE AT 1-800-333-4542 AND REPORTED THE INCIDENT. I WAS GIVEN A CASE NUMBER OF 13015302. I WAS ADVISED TO PROCEED TO AN AUTHORIZED KIA DEALEARSHIP AND BE SEEN FOR NHTSA RECALL NUMBER 16V-389. IF THE LATCH WAS FAULTY, I WAS TOLD THAT KIA WOULD COVER THE COSTS OF REPAIRS. WHEN THE DEALERSHIP WAS CALLED, I WAS ASSURED THAT THERE WERE NOT RECALLS ON MY VEHICLE, WHEN TO THE CONTRARY, I WAS SENT A RECALL DOCUMENT SC134 FROM KIA CASE WORKER, BILLY WELLS. I WAS FINALLY ABLE TO SCHEDULE AN APPOINTMENT. I DROPPED THE VEHICLE OFF FOR THE APPOINTMENT. AFTER APPROXIMATELY 4 HRS THE LOCAL KIA DEALERSHIP SERVICED THE VEHICLE AND PRODUCED PAPER WORK STATING THAT THERE WAS NO PROBLEM WITH THE EQUIPMENT.

AFTER STOPPING AT STOP SIGN DRIVING ON A CITY STREET (SPEED LIMIT 30), I, MADE A RIGHT TURN AND THE LEFT (DRIVER) SIDE, REAR SLIDING DOOR UNLATCHED AND SLID WIDE OPEN. MY DOG ALMOST SLID OUT BUT HAD HIS LEASH ON AND I MANAGED TO GRAB IT BEFORE HE WENT OUT THE DOOR. I GOT OUT AND SLAMMED THE DOOR MANUALLY, TOOK OFF AND MADE ANOTHER RIGHT TURN WHEN AGAIN THE SAME DOOR SLID WIDE OPEN AGAIN. PARKED SAFELY AND TRIED CLOSING DOOR BUT IT WOULD NOT STAY SHUT EVERY TIME I TRIED TO CLOSE THE DOOR IT WOULD OPEN ON ITS OWN AT LEAST 6 INCHES REMAINING LOOSE IN ITS TRACK (SO WHILE DRIVING IT WOULD SLIDE BACK AND FORWARD. I THEN TIED IT CLOSED/SHUT BUT IT WAS CLEARLY VERY DANGEROUS SO I CONTACTED MY LOCAL KIA THE NEXT MORNING AND TOOK IT IN. KIA COMPLETED 2 OTHER RECALLS BUT THOSE DID NOT FIX THE ISSUE. KIA REPORTED THAT THEY TRACED THE ISSUE BACK TO THE REAR DOOR CONTROLLER WHICH WAS NOT PART OF THE RECALLS BUT WAS CAUSING THE PROBLEM SO THEY RE-TIED THE DOOR (SIMILAR TO HOW I HAD) USING MY STRAP. I DECLINED TO PAY TO HAVE THIS FIXED AS KIA HAS ALREADY ISSUED A TECHNICAL SERVICE BULLETIN ON THIS SO IT IS HAPPENING FREQUENTLY - HAD A PASSENGER BEEN IN THAT SEAT ON THE HIGHWAY THEY COULD HAVE LITERALLY BLOWN OUT THE DOOR ONTO THE HIGHWAY. I THINK THIS IS EXTREMELY DANGEROUS AND A RECALL SHOULD BE ISSUED. MY KIA DOOR HAS NOT BEEN REPAIRED YET AND IS AVAILABLE TO BE LOOKED AT IN DETAIL AS NEEDED. AT THE VERY LEAST OTHER KIA OWNERS NEED TO BE MADE AWARE OF THIS SO THAT CHILDREN (AND ANYONE SITTING IN THE REAR SEAT) ARE NOT HARMED OR KILLED. I DO HOPE THAT KIA DOES ISSUE A RECALL ON THIS VERY DANGEROUS ISSUE.

WE HAVE A 2006 KIA SEDONA MINIVAN WITH LITTLE OR NO RUST ON THE BODY. IN 2013 WHILE MY WIFE WAS DRIVING IN TOWN SHE HAD THE PASSENGER FRONT CONTROL ARM BREAK THANKFULLY AT LOW SPEED. I CONTACTED KIA ABOUT THE PROBLEM AND THEY SAID THEY WOULD NOT REIMBURSE FOR THE REPAIR. A COUPLE WEEKS LATER THEY CALLED AND OFFERED TO REIMBURSE ME FOR THE NEW CONTROL ARMS AND LABOR WHICH THEY DID. SHORTLY AFTERWARDS A RECALL WAS ISSUED FOR THIS EXACT PROBLEM. LESS THAN 2 WEEKS AGO ON 9/28/17 AS A WAS RETURNING HOME FROM WORK THE WHEEL BEGAN SHAKING AND THERE WAS A GRINDING AND SHUDDERING WHILE BRAKING ABRUPTLY AND I WAS ABLE TO LIMP THE VAN HOME. I HAD IT TOWED TO MY MECHANIC AND THE SUBFRAME JUST THE OTHER SIDE OF THE FRONT DRIVER CONTROL ARM HAD SNAPPED AND THE WHEEL IS JUST FLOATING AROUND IN THE WHEEL WELL. I WAS SURPRISED HOW THIN THE STEEL IS AT THE BREAK POINT CONSIDERING IT NEEDS TO SUPPORT A QUARTER OF THE WEIGHT OF THE VAN. THE SUPPORT STRUCTURE OF THE VAN IS ROTTED AT MORE THAN JUST THIS LOCATION UPON FURTHER INSPECTION.

RECALL: 16V389000 - HOOD OPENS WHILE DRIVING WE WERE NEVER NOTIFIED THAT THERE WAS A RECALL FOR THIS ISSUE. WE FOUND OUT ABOUT THE RECALL AFTER THE INCIDENT DESCRIBED BELOW: WHILE DRIVING ON A FREEWAY, THE HOOD UNEXPECTEDLY OPENED UP AND HIT THE WINDSHIELD. LUCKILY, I WAS ABLE TO SLOW DOWN AND GET ON THE SHOULDER TO AVOID A MAJOR ACCIDENT. THE ENTIRE WINDSHIELD IS CRACKED AND THE HOOD IS DAMAGED BEYOND REPAIR. I'M NOT SURE IF THE IMPACT DAMAGE ANY OTHER PARTS OF THE CAR BUT AN INSPECTION WILL BE PERFORMED BY MY INSURANCE TO FIND OUT.

DRIVING MY KIA IN FREEWAY ABOUT 55 MPH AND UNEXPECTEDLY HOOD OPEN AND CRASH MY WINDSHIELD, I TRY TO DRIVE TO FREEWAY SIDE WITH THE LITTLE VISIBLE SPACE BETWEEN DASHBOARD AND HOOD, A GUY DRIVING BESIDES ME HELP WITH THE TRAFFIC SO I REDUCE SPEED AND HIT GUARDRAIL, I DAMAGE MY BUMPER AND ALL RIGHT FRONT SIDE OF MY KIA, I WAS THINKING THAT WAS MY BAD LUCK OR THAT I DIDN'T CLOSE HOOD PROPERLY. I TRIED TO PUT HOOD IN PLACE AND USING AN ETHERNET CABLE TO SECURE HOOD AND DRIVE AT 10-20 MPH TO HOME. NEXT DAY I CALL A GUY FROM CRAIGSLIST TO REPLACE WINDSHIELD, I REMOVE HOOD AND TRIED TO UNBEND IT, FIX LATCHES AND TRIED IT TO PUT IT IN PLACE I BUY ONE USED AND REPLACE OLD ONE, I AM STILL USING MY VEHICLE BECAUSE WANT TO AVOID FINES AND I WAS NOT PHYSICALLY AFFECTED, JUST THE SCARE AND VEHICLE DAMAGE, I DIDN'T REPORT INCIDENT TO POLICE. I JUST READ ABOUT LATCH KIA PROBLEM, KIA'S RECALL NUMBER SC134, I AM STILL USING MY KIA BECAUSE CANNOT BUY ANOTHER CAR FOR THE MOMENT, ALL MY KIA IS MESSED UP IN THE BODY(BUMPER/RIGHT PASSENGER SIDE, ETC. BUT MOTOR/TRANS WORKED LIKE A CHAMP BUT COSMETICALLY LOOKS VERY UGLY BECAUSE THAT INCIDENT WITH OPEN HOOD. CAN KIA PAY FOR MY REPAIRS?

TL* THE CONTACT OWNS A 2006 KIA SEDONA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30 MPH, THE REAR PASSENGER SIDE SLIDING DOOR OPENED WITHOUT WARNING. THE CONTACT ALSO STATED THAT THE SLIDING DOOR WAS ONLY ABLE TO OPERATE MANUALLY AND FAILED TO OPERATE WITH THE KEY FOB. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 7,000. THE VIN WAS NOT AVAILABLE.

SIDE SLIDING DOOR OPENS WHILE CAR IS IN DRIVE. LUCKILY I WAS ABLE TO PULL OVER AND PUSH IT CLOSED, BUT IT SCARES ME WHEN I'M DRIVING AND MY SON IS IN HIS CAR SEAT AND THE DOOR CHIME WILL GO OFF BECAUSE THE DOOR IS OPENING. THIS NEEDS TO BE FIXED ASAP. AIR BAG LIGHT IS ON QUITE OFTEN AND HAD TO TAKE TO MECHANIC TO SEE WHAT WAS WRONG. *TR