Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
1625–50K
1850–75K
2175–100K
16100–150K
7150K+
129 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Wheels. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports13 fire reports8 injury reports
What owners actually said
175 reports
10,000 miles · Jun 28, 2005
Power TrainService Brakes, Hydraulic
DT: TOOK KIA, SEDONA 2004 4 TIMES TO DEALER FOR BRAKE FAILURE. THE BRAKES SQUEAKED A LOT, AND THE PROBLEM HAS NOT BEEN FIXED PROPERLY. CONSUMER TOOK VEHICLE TO THE DEALER AND THE PROBLEM WAS FIXED. BUT, THEN AGAIN ONE COULD HEAR A SOUND ON THE BRAKES. CONSUMER WAS TAKEN BACK VEHICLE TO DEALER FOR THE 5TH TIME. TO …
Read full complaint
DT: TOOK KIA, SEDONA 2004 4 TIMES TO DEALER FOR BRAKE FAILURE. THE BRAKES SQUEAKED A LOT, AND THE PROBLEM HAS NOT BEEN FIXED PROPERLY. CONSUMER TOOK VEHICLE TO THE DEALER AND THE PROBLEM WAS FIXED. BUT, THEN AGAIN ONE COULD HEAR A SOUND ON THE BRAKES. CONSUMER WAS TAKEN BACK VEHICLE TO DEALER FOR THE 5TH TIME. TO SEE WHAT COULD BE DONE. ALSO TRANSMISSION WHEN IN DRIVE AROUND 5 MPH, WANTED TO STOP, THEN JUMPED TO NORMAL. ALSO WHEN THE CAR WAS IDLING IN PARK OR STOPPING IT SHOOK. *AK
NHTSA ODI #10126821
6,500 miles · Jun 28, 2005
Suspension
DT:CONTACT ATTEMPTED TO HAVE A RECALL TAKEN CARE OFF BUT THE PARTS WERE NOT AVAILABLE FROM KIA. THEY WERE ON BACK ORDER. CONTACT WAS TOLD BY THE DEALER AND BY KIA THEY WERE ON NATIONAL BACKORDER . HE HAS BEEN TOLD THAT BACK ORDER WILL TAKE APPROXIMATELY 2 WEEKS. HE WAS CONCERNED BECAUSE THE RECALL WAS FOR DAMAGED OUTER WHEE…
Read full complaint
DT:CONTACT ATTEMPTED TO HAVE A RECALL TAKEN CARE OFF BUT THE PARTS WERE NOT AVAILABLE FROM KIA. THEY WERE ON BACK ORDER. CONTACT WAS TOLD BY THE DEALER AND BY KIA THEY WERE ON NATIONAL BACKORDER . HE HAS BEEN TOLD THAT BACK ORDER WILL TAKE APPROXIMATELY 2 WEEKS. HE WAS CONCERNED BECAUSE THE RECALL WAS FOR DAMAGED OUTER WHEEL BEARINGS. HE KNEW THERE WAS DAMAGE TO THE WHEEL BEARINGS, AND THAT HE WAS DRIVING AN UNSAFE VAN, AND TRANSPORTING CHILDREN IN THE VAN.*AK
NHTSA ODI #10126794
Mileage unknown · Jun 24, 2005
Suspension
DT: CONSUMER RECEIVED A RECALL NOTICE. CONTACTED DEALER, AND THEY DO NOT HAVE THE PARTS FOR RECALL REPAIRS. DEALER DID RECEIVE SOME PARTS BUT NOT COMPLETE PARTS, THEN, CONTACTED THE MANUFACTURER, WHO FIRST SAID THEY DIDN'T HAVE ANY, AND SOME WERE NOT COMPLETE. MANAGER SAID THAT CONSUMER WOULD HEAR A HUMMING 10,000 MILES PRI…
Read full complaint
DT: CONSUMER RECEIVED A RECALL NOTICE. CONTACTED DEALER, AND THEY DO NOT HAVE THE PARTS FOR RECALL REPAIRS. DEALER DID RECEIVE SOME PARTS BUT NOT COMPLETE PARTS, THEN, CONTACTED THE MANUFACTURER, WHO FIRST SAID THEY DIDN'T HAVE ANY, AND SOME WERE NOT COMPLETE. MANAGER SAID THAT CONSUMER WOULD HEAR A HUMMING 10,000 MILES PRIOR.*AK
NHTSA ODI #10126491
Mileage unknown · Jun 15, 2005
Power Train
DT: TOOK VEHICLE TO DEALER AT LEAST 15 TIMES, THEY SAID NOT KICKING UP ANY ERA CODES. THE THROTTLE BODY WAS CHANGED ALSO TRANSMISSION CONTROL MODULE (TCM ) WAS THEN CHANGED. THIS DID NOT FIX THE PROBLEM. THEY DID SOMETHING WITH THE GROUNDS. IN FEBRUARY 2005 THEY PUT IN A NEW TRANSMISSION. LIKE THE CAR IT WAS LOSING POWE…
Read full complaint
DT: TOOK VEHICLE TO DEALER AT LEAST 15 TIMES, THEY SAID NOT KICKING UP ANY ERA CODES. THE THROTTLE BODY WAS CHANGED ALSO TRANSMISSION CONTROL MODULE (TCM ) WAS THEN CHANGED. THIS DID NOT FIX THE PROBLEM. THEY DID SOMETHING WITH THE GROUNDS. IN FEBRUARY 2005 THEY PUT IN A NEW TRANSMISSION. LIKE THE CAR IT WAS LOSING POWER, AND CAR WAS GEARING DOWN ON ITS OWN. AT FIRST THIS ONLY HAPPENED ONCE OR TWICE A WEEK, BUT CURRENTLY IT HAPPENED EVERY TIME CONSUMER GOT INTO THE CAR. THE LAST THIS HAPPENED CONSUMER PULLED OUT ONTO A ROAD AND CAR HAD NO POWER, AND DID NOT WANT TO ACCELERATE. IT WAS ALMOST HIT BY A TRACTOR TRAILER. DROVE TO DEALERSHIP DID NOT TURN OFF THE CAR. TECHNICIAN DROVE THE CAR, AND HE SAID THAT THE TRANSMISSION KICKED ITSELF INTO SAFE MODE, WHICH MEANT THE CAR STAYED IN SECOND GEAR WHILE DRIVING. *AK
NHTSA ODI #10125427
600 miles · Jun 3, 2005
Suspension
THUMPING NOISE FROM FRONT END..WHEELS OR STRUTS. USUALLY OCCURS AT SLOW SPEEDS ON UNEVEN SURFACES. NOT AS NOTICABLE AT HIGHER SPEEDS. THIS CONCERNS ME BECAUSE SOMETHING IS APPARENTLY LOOSE AND VIBRATING YET THEY HAVE YET TO CORRECT THE PROBLEM. IF YOU LOOK AT WW.KIA-FORUMS.COM AND LOOK UNDER SEDONA, YOU WILL SEE NUMEROUS PEO…
Read full complaint
THUMPING NOISE FROM FRONT END..WHEELS OR STRUTS. USUALLY OCCURS AT SLOW SPEEDS ON UNEVEN SURFACES. NOT AS NOTICABLE AT HIGHER SPEEDS. THIS CONCERNS ME BECAUSE SOMETHING IS APPARENTLY LOOSE AND VIBRATING YET THEY HAVE YET TO CORRECT THE PROBLEM. IF YOU LOOK AT WW.KIA-FORUMS.COM AND LOOK UNDER SEDONA, YOU WILL SEE NUMEROUS PEOPLE WITH THE SAME PROBLEM AND KIA HAS YET TO FIX IT. I GUESS THEY WON'T BE HAPPY UNTIL THE FRONT END FALLS OUT OR SOMETHING. PEOPLE HAVE HAD THEIR WHOLE FRONT END BASICALLY REPLACED AND STILL THEY HAVE THE PROBLEM.
NHTSA ODI #10124043
Mileage unknown · Jun 1, 2005
Electrical System
DT: THE CONTACT OWNS A 2004 KIA SADONA. THE DASH LIGHTS HAVE REPEATEDLY FAILED IN LESS THAN ONE YEAR. A COUPLE OF TIMES THE DEALER PUT FUSES IN THE VEHICLE, AND THEY CLAIMED THAT SOMETHING HAD BEEN PLUGGED INTO THE CIGARETTE LIGHTER THAT DID NOT WORK. THE MASTER TECHNICIAN PUT A NEW INSTRUMENT CLUSTER BOARD. THIS WOULD SOLVE THE…
Read full complaint
DT: THE CONTACT OWNS A 2004 KIA SADONA. THE DASH LIGHTS HAVE REPEATEDLY FAILED IN LESS THAN ONE YEAR. A COUPLE OF TIMES THE DEALER PUT FUSES IN THE VEHICLE, AND THEY CLAIMED THAT SOMETHING HAD BEEN PLUGGED INTO THE CIGARETTE LIGHTER THAT DID NOT WORK. THE MASTER TECHNICIAN PUT A NEW INSTRUMENT CLUSTER BOARD. THIS WOULD SOLVE THE PROBLEM FOR A WEEK UP TO A MONTH, AND THE PROBLEM WOULD COME BACK. AT NIGHTS, THEY CANNOT SEE THE SPEED OR FUEL OR ANY LIGHTS ON THE DASHBOARD. PREVIOUS OWNER HAD THIS VEHICLE IN THE SHOP THREE TIMES FOR ELECTRICAL REASONS. *AK
NHTSA ODI #10123844
Mileage unknown · Jun 1, 2005
TiresUnknown Or Other
DT: THE SPARE TIRE UNDERNEATH THE VAN SITS ON A METAL RACK. THE METAL RUBED ON THE TIRE AND MADE RIDGES ON THE TIRE. CONSUMER CONTACTED MANUFACTURER. *AK *SB *NM
NHTSA ODI #10120093
100 miles · Mar 8, 2005
Service Brakes, Hydraulic
CONSUMER COMPLAINED ABOUT A BRAKE PROBLEM. THE BRAKES LOCKED UP WHILE THE VEHICLE WAS COMING TO A STOP. VEHICLE MADE A LARGE CLANKING SOUND WHEN APPLYING THE BRAKES. CONSUMER TOOK THE VEHICLE TO THE DEALER. HOWEVER, THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. *AK THE CONSUMER STATED THAT THE BRAKES HAVE NOT WORKED PROP…
Read full complaint
CONSUMER COMPLAINED ABOUT A BRAKE PROBLEM. THE BRAKES LOCKED UP WHILE THE VEHICLE WAS COMING TO A STOP. VEHICLE MADE A LARGE CLANKING SOUND WHEN APPLYING THE BRAKES. CONSUMER TOOK THE VEHICLE TO THE DEALER. HOWEVER, THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. *AK THE CONSUMER STATED THAT THE BRAKES HAVE NOT WORKED PROPERLY SINCE PURCHASE. *TC
NHTSA ODI #10111567
4,350 miles · Mar 2, 2005
Vehicle Speed Control
WHEN THE VEHICLE IS COLD THE ACCELERATOR PEDAL WILL NOT GO DOWN. VEHICLE HAS TO WARM UP BEFORE THE ACCELERATOR PEDAL WILL OPERATE NORMALLY. OWNER WAS INFORMED THAT THE ACCELERATOR THROTTLE CABLE NEEDED TO BE REPLACED. DEALER REPLACED THE CABLE, AND THE VEHICLE WAS OPERATING NORMALLY. *AK THE CONSUMER STATED THAT THE GAS PEDAL…
Read full complaint
WHEN THE VEHICLE IS COLD THE ACCELERATOR PEDAL WILL NOT GO DOWN. VEHICLE HAS TO WARM UP BEFORE THE ACCELERATOR PEDAL WILL OPERATE NORMALLY. OWNER WAS INFORMED THAT THE ACCELERATOR THROTTLE CABLE NEEDED TO BE REPLACED. DEALER REPLACED THE CABLE, AND THE VEHICLE WAS OPERATING NORMALLY. *AK THE CONSUMER STATED THAT THE GAS PEDAL STUCK AND THE VEHILCE REACHED 90 MPH. *TC
NHTSA ODI #10109560
1,825 miles · Feb 18, 2005
Electrical SystemEngine And Engine CoolingPower Train
WHILE DRIVING 50 MPH VEHICLE STALLED. VEHICLE WAS STILL DRIVEABLE. DEALERSHIP INFORMED THE CONSUMER THAT THERE TRANSMISSION FAILED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK DEALER STATED PROBLEM WAS CAUSED BY ELECTRICL HARNESS. ALSO HAVING MULTIPLE FAILURES WITH OUTPUT SPEED SENSOR; TRANSMISSION 3 TIMES; …
Read full complaint
WHILE DRIVING 50 MPH VEHICLE STALLED. VEHICLE WAS STILL DRIVEABLE. DEALERSHIP INFORMED THE CONSUMER THAT THERE TRANSMISSION FAILED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK DEALER STATED PROBLEM WAS CAUSED BY ELECTRICL HARNESS. ALSO HAVING MULTIPLE FAILURES WITH OUTPUT SPEED SENSOR; TRANSMISSION 3 TIMES; THERMOSTAT ASSEMBLY; POWER STEERING LEAKED; INPUT SPEED SENSOR; LOW GROUND VOLTAGE FAILED; FUSE BLOCK PROBLEMS; CRUISE CONTROL. CONSUMER WAS ADVISED THAT DUE TO THE DESIGN OF THE CRUISE CONTROL, THE VEHICLE ACCELERATES OFTEN WHILE ON AN INCLINE AT 45 TO 55 MPH AS IF VEHICLE'S ENGINE/TRANSMISSION WAS RACING. *TT *TC
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence & remedy
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence & remedy
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
2004 Kia Sedona Problems, Complaints & Recalls | Skip That Year
Illustration